TWO CRACKS HAVE APPEARED ON MY DASH, ONE ON THE DRIVER'S SIDE AND A SMALL ONE ON THE PASSENGER SIDE. THE CAR HAS 34,000 MILES, IS GARAGED AND ONLY DRIVEN ON PAVED ROADS. WHEN PARKED IN A LOT, A WINDOW VISER IS ALWAYS USED. I NOTICED THE LARGER CRACK ABOUT TWO MONTHS AGO. IT GETS BIGGER EVERY DAY.
2013 Chevrolet Tahoe
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2013 Chevrolet Tahoe do not stand out strongly from the model-year median of 246.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tahoe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
162 reports with mileage · 70 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
56 reportsDASHBOARD HAS CRACKED ABOVE THE PASSENGER AIRBAG AND ABOVE THE INSTRUMENT CLUSTER ON THE DRIVER'S SIDE. IT IS UNKNOWN IF THE VEHICLE WAS PARKED OR MOVING AT THE MOMENT THE CRACKS OCCURRED. NOTHING HAS EVER BEEN PLACED ON THE DASHBOARD THAT COULD CAUSE THE CRACKS.
I'M SEEING LARGE STRUCTURALLY UNSOUND CRACKS IN THE TOP OF THE DASHBOARD, BUT ON TOP OF THE MAIN SPEEDOMETER ETC DOME AND OVER BY THE PASSENGER SIDE AIRBAG AREA. THE ONES OVER ON THE DRIVER SIDE ARE LARGE ENOUGH TO ACTUALLY FLOP AROUND. IT DOES APPEAR TO BE A SAFETY HAZARD ESPECIALLY IN CASE OF ACCIDENT WHEN JAGGED PIECES WOUL…
Read full complaint
I'M SEEING LARGE STRUCTURALLY UNSOUND CRACKS IN THE TOP OF THE DASHBOARD, BUT ON TOP OF THE MAIN SPEEDOMETER ETC DOME AND OVER BY THE PASSENGER SIDE AIRBAG AREA. THE ONES OVER ON THE DRIVER SIDE ARE LARGE ENOUGH TO ACTUALLY FLOP AROUND. IT DOES APPEAR TO BE A SAFETY HAZARD ESPECIALLY IN CASE OF ACCIDENT WHEN JAGGED PIECES WOULD BE ABOUT. VEHICLE WAS PURCHASED IN THIS CONDITION (NOTICED AFTER PURCHASE WHEN ON ROUGHER ROADS WITHOUT RADIO AND THE VARIOUS PIECES STARTED MAKING QUITE A RACKET.)
THE DASH ON THIS VEHICLE HAS SEVER CRACKS IN 2 DIFFERENT PLACES. THE VEHICLE HAS NEVER BEEN WRECKED AND HAS BEEN VERY WELL MAINTAINED. THIS IS A KNOWN PROBLEM WITH CHEVROLET TAHOES. IT IS FORESEEABLE THAT INJURIES WOULD BE SIGNIFICANTLY INCREASED IN THE CASE OF A FRONT-END COLLISION SHOULD THE DASH COME COMPLETELY APART AND LEAV…
Read full complaint
THE DASH ON THIS VEHICLE HAS SEVER CRACKS IN 2 DIFFERENT PLACES. THE VEHICLE HAS NEVER BEEN WRECKED AND HAS BEEN VERY WELL MAINTAINED. THIS IS A KNOWN PROBLEM WITH CHEVROLET TAHOES. IT IS FORESEEABLE THAT INJURIES WOULD BE SIGNIFICANTLY INCREASED IN THE CASE OF A FRONT-END COLLISION SHOULD THE DASH COME COMPLETELY APART AND LEAVE SHARP EDGES EXPOSED.
I WAS DRIVING AT ABOUT 45 MPH AND HEARD A RATTLE COMING FROM MY DASHBOARD. THE VENT NEAR THE WINDSHIELD WAS VISIBLY VIBRATING. I THEN NOTICED A CRACK EXTENDING FROM THE CORNER OF THE AIRBAG COVER TO THE VENT. THE DEALER SAID THAT THIS HAPPENS ON SOME MODELS/YEAR. THIS IS MY THIRD TAHOE IN OVER 20 YEARS AND IT HASN'T HAPPENED BEF…
Read full complaint
I WAS DRIVING AT ABOUT 45 MPH AND HEARD A RATTLE COMING FROM MY DASHBOARD. THE VENT NEAR THE WINDSHIELD WAS VISIBLY VIBRATING. I THEN NOTICED A CRACK EXTENDING FROM THE CORNER OF THE AIRBAG COVER TO THE VENT. THE DEALER SAID THAT THIS HAPPENS ON SOME MODELS/YEAR. THIS IS MY THIRD TAHOE IN OVER 20 YEARS AND IT HASN'T HAPPENED BEFORE. THE VIBRATION IS GOING TO MAKE THE CRACK WORSE AND THE DASHBOARD WILL START TO BREAK APART. I BELIEVE THAT THE AIRBAG COMPARTMENT IS ALSO AT RISK.
LOW MILEAGE VEHICLE, STORED IN A GARAGE AT WORK AND AT HOME. DASHBOARD CRACKED AT PASSENGER SIDE AIRBAG. SERIOUS SAFETY ISSUE AS PLASTIC PARTS FROM BROKEN DASHBOARD CAN BECOME DEADLY MISSILES DURING AIRBAG DEPLOYMENT AND POTENTIALLY HARM OR CAUSE DEATH TO PASSENGER (MY CHILD). SPENT NEARLY $600 FOR A DASHBOARD ASSEMBLY THAT SHO…
Read full complaint
LOW MILEAGE VEHICLE, STORED IN A GARAGE AT WORK AND AT HOME. DASHBOARD CRACKED AT PASSENGER SIDE AIRBAG. SERIOUS SAFETY ISSUE AS PLASTIC PARTS FROM BROKEN DASHBOARD CAN BECOME DEADLY MISSILES DURING AIRBAG DEPLOYMENT AND POTENTIALLY HARM OR CAUSE DEATH TO PASSENGER (MY CHILD). SPENT NEARLY $600 FOR A DASHBOARD ASSEMBLY THAT SHOULD HAVE NEVER REQUIRED REPLACING.
CRACKED DASH - DASH HAS SEPARATED/CRACKED AT AIRBAG RELEASE LOCATION AS WELL AS AT THE INSTRUMENT CLUSTER. UNKNOWN IF THIS WILL AFFECT AIRBAG DEPLOYMENTS OR ELECTRICAL ISSUES IN SPEEDO CLUSTER. WAS TOLD TO REPORT THIS BY DEALER.
TL* THE CONTACT OWNS A 2013 CHEVROLET TAHOE. THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED FROM THE TOP DRIVER'S SIDE TO THE FRONT PASSENGER SIDE AIR BAG AREA. THE CRACK WAS RAPIDLY EXPANDING AND THE CONTACT WAS CONCERNED THAT THE FRONT PASSENGER AIR BAG COULD DEPLOY. THE VEHICLE WAS TAKEN TO NELSON HALL CHEVROLET (1811 SOUT…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHEVROLET TAHOE. THE CONTACT STATED THAT THE DASHBOARD WAS CRACKED FROM THE TOP DRIVER'S SIDE TO THE FRONT PASSENGER SIDE AIR BAG AREA. THE CRACK WAS RAPIDLY EXPANDING AND THE CONTACT WAS CONCERNED THAT THE FRONT PASSENGER AIR BAG COULD DEPLOY. THE VEHICLE WAS TAKEN TO NELSON HALL CHEVROLET (1811 SOUTH FRONTAGE ROAD, MERIDIAN, MS 39301, (601) 621-4324) WHERE THEY STATED THAT THEY WERE AWARE OF THE DEFECTIVE DASHBOARD AND DETERMINED THAT THE DRIVER'S DOOR PANEL WAS FRACTURED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
DASHBOARD CRACKING CAN RESULT IN STRUCTURAL INTEGRITY ISSUES THAT CAN RESULT IN THE CREATION OF PROJECTILES IN THE INSTANCE OF A COLLISION, AIRBAGS BEING UNABLE TO PROPERLY DEPLOY, ETC. ALMOST ALL GM VEHICLES IN THIS MODEL YEAR RANGE HAVE THIS ISSUE; IS OF WIDESPREAD CONCERN. I JUST PURCHASED THIS CAR AND AM WORRIED THAT IF I W…
Read full complaint
DASHBOARD CRACKING CAN RESULT IN STRUCTURAL INTEGRITY ISSUES THAT CAN RESULT IN THE CREATION OF PROJECTILES IN THE INSTANCE OF A COLLISION, AIRBAGS BEING UNABLE TO PROPERLY DEPLOY, ETC. ALMOST ALL GM VEHICLES IN THIS MODEL YEAR RANGE HAVE THIS ISSUE; IS OF WIDESPREAD CONCERN. I JUST PURCHASED THIS CAR AND AM WORRIED THAT IF I WERE EVER TO BE IN AN ACCIDENT, MY SAFETY WOULD BE JEOPARDIZED.
CRACKING IN THE DASHBOARD THAT HAS CARRIED INTO THE AIRBAG SECTION OF THE DASH THAT PREVENTED DEPLOYMENT IN AN ACCIDENT ON BOTH PASSENGER AND DRIVER SIDES OF DASH
Official recalls
421V053000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.
21V054000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.
14V614000 · Electrical System
Oct 1, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.
Consequence & remedy
Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GMs number for this recall is 14515.
13V001000 · Power Train:automatic Transmission; Steering:column LOCKING:ANTI-THEFT Device
Jan 2, 2013
General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.
Consequence & remedy
Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.
Additional source detail variants (2)
Power Train:automatic Transmission
General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.
Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.
Steering:column LOCKING:ANTI-THEFT Device
General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.
Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration