← New search

2011 Chevrolet Tahoe

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Chevrolet Tahoe do not stand out strongly from the model-year median of 246.

About this comparison →

When problems were reported

Mileage at the reported incident

274 reports with mileage · 172 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 185 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports2 fire reports3 injury reports

Unknown Or Other complaints

211 reports
Clear category filter
58,000 miles · Jan 18, 2016
Unknown Or Other

I HAVE A 2011 TAHOE WHICH I PURCHASED NEW. IT HAS ALWAYS BEEN PARKED IN A COVERED PARKING GARAGE DURING THE DAY AND IN MY COVERED CARPORT IN THE EVENINGS. IT HAS 58,000. MILES AND WHILE CLEANING THE TRUCK I NOTICED A CRACK IN THE DASH ON THE DRIVERS SIDE APPROXIMATELY 3.5 INCHES LONG AND ANOTHER CRACK ON THE PASSENGERS SIDE, I…

Read full complaint

I HAVE A 2011 TAHOE WHICH I PURCHASED NEW. IT HAS ALWAYS BEEN PARKED IN A COVERED PARKING GARAGE DURING THE DAY AND IN MY COVERED CARPORT IN THE EVENINGS. IT HAS 58,000. MILES AND WHILE CLEANING THE TRUCK I NOTICED A CRACK IN THE DASH ON THE DRIVERS SIDE APPROXIMATELY 3.5 INCHES LONG AND ANOTHER CRACK ON THE PASSENGERS SIDE, IN THE CORNER OF WHERE THE AIRBAG IS LOCATED. I AM VERY CONCERNED THAT IN CASE OF AN ACCIDENT THESE CRACKS COULD JEOPARDIZE THE INTEGRITY OF THE AIRBAGS. THE DEALERSHIP HAS STATED THAT I WOULD HAVE TO INCURE THE COST OF REPLACEMENT. THIS TRUCK IS STILL IN ABSOLUTE PERFECT CONDITION OTHERWISE.

NHTSA ODI #10820835

42,000 miles · Jan 17, 2016
Unknown Or Other

MY DASH HAS CRACKED AND I'M WORRIED THAT IF I'M EVER IN AN ACCIDENT THAT I MAY BE INJURED IF THE AIR BAGS DEPLOY AND SEND PIECES OF THE DASH AT ME. SEEMS TO BE A BIG PROBLEM WITH GM SUV'S AND TRUCKS. THERE IS EVEN A FACEBOOK PAGE WITH A COUPLE THOUSAND MEMBERS: HTTPS://WWW.FACEBOOK.COM/GROUPS/GMDASHCRACK/

NHTSA ODI #10820685

76,000 miles · Jan 17, 2016
Air BagsUnknown Or Other

HI I CURRENTLY OWN A 2011 CHEVY TAHOE LT MODEL WITH 78,547 MILE ON IT AND THE DASH IS CRARCKED AROUND THE PASSENGER AIRBAG AND OVER THE INSTRUMENT CLUSTER AND WHICH I THINK MIGHT COMPRIMISE THE AIRBAG ON DEPLOYMENT WHICH WOULD PUT MY CHILDREN AND PASSENGERS AT RISK OF A FATALITY IN THE EVENT THAT AN ACCIDENT OCCURS AND GM SHOUL…

Read full complaint

HI I CURRENTLY OWN A 2011 CHEVY TAHOE LT MODEL WITH 78,547 MILE ON IT AND THE DASH IS CRARCKED AROUND THE PASSENGER AIRBAG AND OVER THE INSTRUMENT CLUSTER AND WHICH I THINK MIGHT COMPRIMISE THE AIRBAG ON DEPLOYMENT WHICH WOULD PUT MY CHILDREN AND PASSENGERS AT RISK OF A FATALITY IN THE EVENT THAT AN ACCIDENT OCCURS AND GM SHOULD RECALL THIS PROBLEM ITS NOT JUST MINE BUT MOST ALL GM MODELS 07-13 ARE AFFECTED BY THIS AND WE AS THE CUSTOMERS ARE CONCERNED WITH OUR PASSENGERS SAFETY AND WOULD LIKE TO GET THIS RECALLED BEFORE SOMETHING FATAL DOES OCCUR THANKS .

NHTSA ODI #10820682

40,000 miles · Jan 16, 2016
Unknown Or Other

I WAS WIPING DUST OFF THE DASHBOARD AND SAW A SMALL CRACK ON THE CORNER OF THE DASH THAT MEETS THE AIRBAG COMPARTMENT AS WELL AS A CRACK ON THE SAME DASH PANEL ON THE DRIVER'S SIDE. AT THE TIME MY VEHICLE WAS ONLY THREE YEARS OLD BUT A FEW HUNDRED MILES PAST WARRANTY. I IMMEDIATELY REPORTED IT TO THE DEALERSHIP. I WAS TOLD THEY …

Read full complaint

I WAS WIPING DUST OFF THE DASHBOARD AND SAW A SMALL CRACK ON THE CORNER OF THE DASH THAT MEETS THE AIRBAG COMPARTMENT AS WELL AS A CRACK ON THE SAME DASH PANEL ON THE DRIVER'S SIDE. AT THE TIME MY VEHICLE WAS ONLY THREE YEARS OLD BUT A FEW HUNDRED MILES PAST WARRANTY. I IMMEDIATELY REPORTED IT TO THE DEALERSHIP. I WAS TOLD THEY HAD RECEIVED NUMEROUS COMPLAINTS, BUT I WOULD HAVE TO PAY FOR A REPLACEMENT. I WAS ALSO TOLD THAT SEVERAL OF THOSE THAT HAD THEIR DASH REPLACED WERE EXPERIENCING THE SAME PROBLEM AGAIN. AFTER SEEING THE SAME TYPE OF COMPLAINT FROM OTHER OWNERS AND THE CRACKS ON MY DASH CONTINUING TO SPREAD, I DECIDED TO FILE A COMPLAINT. MY CONCERN IS A SAFETY ISSUE WITH THESE CRACKS CAUSING THE AIR BAGS TO MALFUNCTION AND INFLATE WHILE DRIVING CAUSING INJURY. EVERY PERSON I KNOW THAT HAS THIS VEHICLE IS EXPERIENCING THE SAME PROBLEM. I AM REQUESTING THAT YOU INVESTIGATE THIS ISSUE. I BELIEVE THERE SHOULD BE A RECALL AND A REPLACEMENT WITH A DASH THAT IS MADE OF A MORE DURABLE, SAFER MATERIAL.

NHTSA ODI #10820612

62,000 miles · Jan 10, 2016
Unknown Or Other

WHILE DRIVING ON INTERSTATE I10 SEPT 2015, NOTICED A SMALL CRACK DEVELOPED ON DASH OVER THE INSTRUMENT CLUSTER HUMP. INITIAL CRACK WAS APPROXIMATELY 3" AND HAS CONTINUED TO CRACK AND EXTEND TOWARD THE DRIVER POSITION. DASH CRACK IS NOW 7". CONCERNED THE SHARP PLASTIC DASH COULD CAUSE ADDITIONAL INJURY IN THE EVENT OF AN ACCIDENT…

Read full complaint

WHILE DRIVING ON INTERSTATE I10 SEPT 2015, NOTICED A SMALL CRACK DEVELOPED ON DASH OVER THE INSTRUMENT CLUSTER HUMP. INITIAL CRACK WAS APPROXIMATELY 3" AND HAS CONTINUED TO CRACK AND EXTEND TOWARD THE DRIVER POSITION. DASH CRACK IS NOW 7". CONCERNED THE SHARP PLASTIC DASH COULD CAUSE ADDITIONAL INJURY IN THE EVENT OF AN ACCIDENT. VEHICLE HAS 68,000 MILES.

NHTSA ODI #10819203

53,000 miles · Jan 8, 2016
Unknown Or Other

ONE DAY WHILE DRIVING I NOTICED A SMALL CRACK IN MY DASHBOARD RIGHT ABOVE THE LEFT SIDE OF PASSENGER AIRBAG PANEL COVER.

NHTSA ODI #10818921

63,000 miles · Jan 6, 2016
Unknown Or Other

MY DASHBOARD STARTING CRACKING ABOVE THE INSTRUMENT PANEL. YOU CAN HEAR IT CRACKING AS YOU ARE OPERATING THE VEHICLE AND CONTINUES TO CRACK DEPENDING ON HOT AND COLD TEMPS.

NHTSA ODI #10818547

59,000 miles · Jan 6, 2016
Unknown Or Other

DASHBOARD CRACKING OVER INSTRUMENT PANEL AND CORNER OF PASSENGER AIRBAG.

NHTSA ODI #10818380

90,000 miles · Jan 6, 2016
Unknown Or Other

MY DASH HAS A LARGE CRACK JUST ABOVE THE INSTRUMENT PANEL.

NHTSA ODI #10818350

Mileage unknown · Jan 5, 2016
Unknown Or Other

FRONT DASH BOARD HAS CRACKED IN TWO PLACES.

NHTSA ODI #10818243

Official recalls

5

21V050000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

21V054000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

14V827000 · Electrical System:ignition

Dec 30, 2014

General Motors LLC (GM) is recalling certain model year 2011-2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado HD, Silverado LD, Suburban, Tahoe, GMC Sierra LD, Sierra HD, Yukon, and Yukon XL vehicles. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.

Consequence & remedy

Consequence: If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.

Remedy: GM will notify owners, and dealers will inspect and replace the ignition lock housing, as necessary, free of charge. The recall began on February 12, 2015. Owners may contact GM customer service at 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14696 for the original equipment, and 14912 for the service replacement parts.

11V339000 · Steering:linkages

Jun 28, 2011

GM IS RECALLING CERTAIN MODEL YEAR 2011CADILLAC ESCALADE, ESCALADE ESV; CHEVROLET SILVERADO HD, SILVERADO LD, SUBURBAN, TAHOE; AND GMC SIERRA HD, SIERRA LD, YUKON, AND YUKON XL VEHICLES. THE INTERMEDIATE STEERING SHAFT ATTACHING BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.

Consequence & remedy

Consequence: THIS COULD ALLOW THE JOINTS TO SEPARATE, AND THE DRIVER COULD EXPERIENCE LOSS OF STEERING INCREASING THE RISK OF A CRASH.

Remedy: GM DEALERS WILL INSPECT AND ENSURE THAT THE INTERMEDIATE STEERING SHAFT BOLTS ARE TIGHTENED TO THE PROPER SPECIFICATION. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 13, 2011. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.

11V007000 · Suspension:rear:axle:spindle

Jan 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.

Consequence & remedy

Consequence: THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.