Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
180–25K
3825–50K
5450–75K
4575–100K
64100–150K
24150K+
243 reports with mileage · 50 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 126 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports14 fire reports9 injury reports
What owners actually said
293 reports
92,000 miles · Nov 10, 2010
Power Train
THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER DOES NOT ILLUMINATE AT VARIOUS TIMES. THIS HAS HAPPENED ON AND OFF FOR A WHILE AND I DECIDED TO RESEARCH THE ISSUE. I FOUND A SIMILAR RECALL FOR THIS MODEL YEAR VEHICLE ON YOUR WEBSITE, BUT GM REFUSES TO COVER THE DEFECT ON MY VIN. I RECENTLY ALMOST HIT …
Read full complaint
THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER DOES NOT ILLUMINATE AT VARIOUS TIMES. THIS HAS HAPPENED ON AND OFF FOR A WHILE AND I DECIDED TO RESEARCH THE ISSUE. I FOUND A SIMILAR RECALL FOR THIS MODEL YEAR VEHICLE ON YOUR WEBSITE, BUT GM REFUSES TO COVER THE DEFECT ON MY VIN. I RECENTLY ALMOST HIT SOMEONE BEING IN THE WRONG GEAR. THIS MATCHES A PREVIOUS RECALL ID OF 05V055000. *TR
NHTSA ODI #10365277
92,188 miles · Oct 12, 2010
Electrical System
2005 CHEVY TAHOE W/ APPROX. 86,000 MILES OIL PRESSURE GAUGE AND SPEEDOMETER NOT WORKING PROPERLY. BOTH GAUGES CONTINUE TO MOVE BACK AND FORTH SOMETIMES GOING ALL THE WAY TO THE LEFT(IN THE RED) AND SOMETIMES ALL THE WAY TO THE RIGHT. *TR
NHTSA ODI #10360048
Mileage unknown · Jun 17, 2010
Exterior Lighting
POOR QUALITY ELECTRICAL TO EXTERIOR LAMPS (BRAKES/SIGNALS/HEADLIGHTS) CAUSES THEM TO GO OUT EVEN WHEN THE BULB IS STILL GOOD. HAVE REPLACED BULBS IN EXCESS OF "NORMAL". SAFETY CONCERN REGARDING ASSUMPTION THAT ALL LAMPS ARE WORKING (ESPECIALLY WHEN RECENTLY REPLACED) ONLY TO FIND OUT THROUGH LAW ENFORCEMENT OR OTHER MOTORISTS …
Read full complaint
POOR QUALITY ELECTRICAL TO EXTERIOR LAMPS (BRAKES/SIGNALS/HEADLIGHTS) CAUSES THEM TO GO OUT EVEN WHEN THE BULB IS STILL GOOD. HAVE REPLACED BULBS IN EXCESS OF "NORMAL". SAFETY CONCERN REGARDING ASSUMPTION THAT ALL LAMPS ARE WORKING (ESPECIALLY WHEN RECENTLY REPLACED) ONLY TO FIND OUT THROUGH LAW ENFORCEMENT OR OTHER MOTORISTS THAT ONE OR MULTIPLE LAMPS ARE NOT FUNCTIONING. EVENT HAS OCCURRED MULTIPLE TIMES AND WITHOUT WARNING. INCIDENTAL OBSERVATION OF VEHICLES OF SIMILAR MAKE/MODEL ON THE ROAD INDICATE THIS IS A COMMON PROBLEM. ALSO, CONVERSATIONS WITH AUTO PARTS STORES INDICATE THIS IS A COMMON PROBLEM WITH THIS VEHICLE TYPE. REMEDIED BY REPLACING BULBS AND/OR RE-SEATING BULB IN SOCKET.
NHTSA ODI #10336899
75,000 miles · Jun 9, 2010
Air BagsCrash
TL*THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE CRASHED INTO A DEER BUT THE AIR BAGS DID NOT DEPLOY. THERE WAS EXTENSIVE DAMAGE TO THE VEHICLE. A POLICE REPORT WAS FILED. THE DEALER STATED THAT THE VEHICLE COULD BE INSPECTED AT THE CONTACT'S EXPENSE. THE BODY…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE CRASHED INTO A DEER BUT THE AIR BAGS DID NOT DEPLOY. THERE WAS EXTENSIVE DAMAGE TO THE VEHICLE. A POLICE REPORT WAS FILED. THE DEALER STATED THAT THE VEHICLE COULD BE INSPECTED AT THE CONTACT'S EXPENSE. THE BODY DAMAGE HAD BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000. THE CURRENT MILEAGE WAS APPROXIMATELY 100,000.
NHTSA ODI #10335468
60,000 miles · May 24, 2010
Tires
TL*THE CONTACT OWNS A 2005 CHEVROLET TAHOE EQUIPPED WITH FIRESTONE STEEL RADIAL A/T TIRES, SIZE LT245-75-R16. WHILE DRIVING ON THE HIGHWAY AT APPROXIMATELY 60 MPH, THE RIGHT REAR TIRE BLEW. THE INNER SIDE WALL FAILED. THE CONTACT CALLED THE MANUFACTURER BUT WAS TOLD THAT THE TIRE WAS NOT INCLUDED IN ANY RECALLS. THE TIRE MILEAGE…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET TAHOE EQUIPPED WITH FIRESTONE STEEL RADIAL A/T TIRES, SIZE LT245-75-R16. WHILE DRIVING ON THE HIGHWAY AT APPROXIMATELY 60 MPH, THE RIGHT REAR TIRE BLEW. THE INNER SIDE WALL FAILED. THE CONTACT CALLED THE MANUFACTURER BUT WAS TOLD THAT THE TIRE WAS NOT INCLUDED IN ANY RECALLS. THE TIRE MILEAGE WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 60,000.
NHTSA ODI #10331984
120,000 miles · Apr 4, 2010
Electrical System
I CURRENTLY OWN A 2005 CHEVROLET TAHOE, RECENTLY THE SPEEDOMETER AND OIL GAUGE METER STOPPED WORKING COMPLETELY. CHEVY REFUSES TO FIX THE CONDITION UNLESS I PAY OUT OF POCKET 800.00. *TR
NHTSA ODI #10323679
480,000 miles · Apr 4, 2010
Service Brakes, Hydraulic
TOTAL BRAKE FAILURE IN A 2005 CHEVY TAHOE DUE TO RUSTED BRAKE LINES ONLY 48,000 MILES. *TR
NHTSA ODI #10323648
105,000 miles · Mar 1, 2010
Electrical System
2005 CHEVY TAHOE SPEEDOMETER WILL NOT READ CORRECTLY, STICKS AND CAN BE 20MPH OFF AT TIMES OR STUCK OVER 100. *TR
NHTSA ODI #10315217
105,000 miles · Mar 1, 2010
Electrical System
2005 CHEVY TAHOE SPEEDOMETER WILL NOT READ CORRECTLY, STICKS AND CAN BE 20MPH OFF AT TIMES OR STUCK OVER 100. *TR
NHTSA ODI #10315216
37,700 miles · Feb 16, 2010
Power Train
WHILE DRIVING ON THE FREEWAY, VEHICLE LOST ACCELERATION ALTHOUGH GAS PEDAL WAS ENGAGED. WHEN I RELEASED MY FOOT FROM THE PEDAL, THE GEAR ENGAGED AND VEHICLE CONTINUED FOR A SHORT TIME BEFORE REPEATING SAME SYMPTOM. VEHICLE DID NOT FIX ITSELF. SAFELY COASTED TO SHOULDER OF FREEWAY. PUT VEHICLE IN PARK. LET IT SIT A MOMENT AN…
Read full complaint
WHILE DRIVING ON THE FREEWAY, VEHICLE LOST ACCELERATION ALTHOUGH GAS PEDAL WAS ENGAGED. WHEN I RELEASED MY FOOT FROM THE PEDAL, THE GEAR ENGAGED AND VEHICLE CONTINUED FOR A SHORT TIME BEFORE REPEATING SAME SYMPTOM. VEHICLE DID NOT FIX ITSELF. SAFELY COASTED TO SHOULDER OF FREEWAY. PUT VEHICLE IN PARK. LET IT SIT A MOMENT AND SHIFTED BACK TO DRIVE. WAS ABLE TO GET VEHICLE OFF FREEWAY AND TO SAFE LOCATION, BUT IT CONTINUED TO SLIP FROM GEAR. IT FINALLY STUCK IN 1ST GEAR AND WOULD NOT SHIFT UP. *TR
Monroe Truck Equipment (Monroe) is recalling certain model year 2006, 2008 and 2009 Chevrolet C7500 vehicles, 2005-2006 Chevrolet Tahoe vehicles, and 2009 Ford F-350, and F-450 vehicles, equipped with Sure Power-brand battery equalizers or DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
Consequence & remedy
Consequence: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
Remedy: Monroe will notify owners, and Sure Power will replace the equalizers or converters, free of charge. The recall began on March 24, 2014. Owners may contact Monroe at 1-608-328-8127.
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF BRAKES WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR THE BRAKE PEDAL PUSHROD RETAINER AND INSTALL ONE IF IT IS MISSING FREE OF CHARGE. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON MARCH 10, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Chevrolet Tahoe Problems, Complaints & Recalls | Skip That Year
Illustration