TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. WHILE THE VEHICLE WAS IDLING AT A TRAFFIC LIGHT, THERE WAS A STRONG ODOR OF COOLANT COMING FROM THE VEHICLE. THE CONTACT ALSO NOTICED WHITE SMOKE COMING THROUGH THE AIR VENTS, WHICH RESULTED IN A BURNING ODOR. UPON INSPECTING THE VEHICLE, THE CONTACT NOTICED WATER IN THE OIL WHEN CHEC…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. WHILE THE VEHICLE WAS IDLING AT A TRAFFIC LIGHT, THERE WAS A STRONG ODOR OF COOLANT COMING FROM THE VEHICLE. THE CONTACT ALSO NOTICED WHITE SMOKE COMING THROUGH THE AIR VENTS, WHICH RESULTED IN A BURNING ODOR. UPON INSPECTING THE VEHICLE, THE CONTACT NOTICED WATER IN THE OIL WHEN CHECKING THE DIPSTICK. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #11181444
125,441 miles · Mar 30, 2015
Engine And Engine Cooling
WAS DRIVING TO WORK WHEN MY TRUCK READ "REDUCED ENGINE POWER", LUCKILY I WAS PULLING INTO THE PARKING LOT OF MY JOB! TODAY I'M IN A WHOLE OTHER CITY AND IT JUST HAPPENED AGAIN SO I'M STRANDED! *TR
NHTSA ODI #10702486
117,000 miles · Nov 10, 2014
Engine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED WHILE DRIVING AT 60 MPH, THERE WAS A SUDDEN INCREASE IN ENGINE RPMS AND THE VEHICLE FAILED TO SLOW DOWN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT COOLANT WAS LEAKING INTO THE TRANSMISSION. THE MANUFACTURER WAS MADE AWARE OF T…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED WHILE DRIVING AT 60 MPH, THERE WAS A SUDDEN INCREASE IN ENGINE RPMS AND THE VEHICLE FAILED TO SLOW DOWN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT COOLANT WAS LEAKING INTO THE TRANSMISSION. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 117,000.
NHTSA ODI #10653897
98,000 miles · Jul 10, 2014
EngineEngine And Engine Cooling
TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT TWO OF THE REAR EXHAUST MANIFOLD BOLTS SHEARED OFF ON BOTH SIDES OF THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE BOLTS HAD TO BE DRILLED OUT IN ORDER TO BE REPLACED. THE MANUFACTURER AND DEALER WERE MADE AWARE OF THE FAILURE.…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET TAHOE. THE CONTACT STATED THAT TWO OF THE REAR EXHAUST MANIFOLD BOLTS SHEARED OFF ON BOTH SIDES OF THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE BOLTS HAD TO BE DRILLED OUT IN ORDER TO BE REPLACED. THE MANUFACTURER AND DEALER WERE MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 98,000. THE DEALERS EXPLANATION WAS AN ALUMINUM HEAD VERSUS A CAST IRON EXHAUST MANIFOLD VERSUS CASE HARDENED BOLTS ALL EXPANDED AND CONTRACTED TOGETHER, WHICH CAUSE A POOR DESIGN. UPDATED 08/18/14
NHTSA ODI #10609626
90,000 miles · Dec 7, 2011
Engine And Engine Cooling
EXHAUST MANIFOLD BOLTS BREAKING OFF. EPA EMISSIONS . EXHAUST LEAK UNDER HOOD CAN GET INTO PASSENGER COMPARTMENT. *TR
NHTSA ODI #10438877
80,000 miles · Aug 27, 2008
Engine And Engine Cooling
2005 CHEVY TAHOE... MANUFACTURERS DEFECT IN THE CAM SHAFT, ROCKER ARM, AND LOBE. LEADING TO A KNOCKING NOISE. GM WILL NOT STAND BY THEIR PRODUCT AND REPLACE THE ENGINE PARTS! *TR
NHTSA ODI #10240017
11,583 miles · Aug 11, 2006
Electrical SystemEngine And Engine Cooling
DT: THE CONTACT STATED WHILE DRIVING 40 MPH THERE WAS A CLUNKING NOISE AND THE VEHICLE STALLED COMPLETELY. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE ON-BOARD COMPUTER WAS REPLACED.*AK UPDATED 9/11/2006 - WHEN THE VEHICLE STALLED POWER BRAKES AND POWER STEERING FUNCTION WAS LOST. THE VEHICLE HAD TO BE TOWED TO THE …
Read full complaint
DT: THE CONTACT STATED WHILE DRIVING 40 MPH THERE WAS A CLUNKING NOISE AND THE VEHICLE STALLED COMPLETELY. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE ON-BOARD COMPUTER WAS REPLACED.*AK UPDATED 9/11/2006 - WHEN THE VEHICLE STALLED POWER BRAKES AND POWER STEERING FUNCTION WAS LOST. THE VEHICLE HAD TO BE TOWED TO THE DEALER. *NM
Monroe Truck Equipment (Monroe) is recalling certain model year 2006, 2008 and 2009 Chevrolet C7500 vehicles, 2005-2006 Chevrolet Tahoe vehicles, and 2009 Ford F-350, and F-450 vehicles, equipped with Sure Power-brand battery equalizers or DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
Consequence & remedy
Consequence: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
Remedy: Monroe will notify owners, and Sure Power will replace the equalizers or converters, free of charge. The recall began on March 24, 2014. Owners may contact Monroe at 1-608-328-8127.
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF BRAKES WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR THE BRAKE PEDAL PUSHROD RETAINER AND INSTALL ONE IF IT IS MISSING FREE OF CHARGE. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON MARCH 10, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Chevrolet Tahoe Problems, Complaints & Recalls | Skip That Year
Illustration