IllustrationWHILE DRIVING AT A SPEED OF 55MPH AND APPLYING THE BRAKES BRAKE PEDAL WENT ALLTHE WAYTO THE FLOOR.CONSUMER HAD TO PUMP THE BRAKES TO GET THE VEHICLE TO STOP. VEHICLE HAD TO BE TOWED TO DEALER, AND DEALER REPLACED MASTER CYLINDER IN THAT RESERVOIRS WERE EMPTY. *AK
1999 Chevrolet Tahoe
Owner reports · Recalls · Investigations
More warning signs than most Tahoe years
Owner complaints for the 1999 Chevrolet Tahoe are substantially higher than the model-year median of 246.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tahoe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
2325–50K
5150–75K
6475–100K
82100–150K
36150K+
266 reports with mileage · 286 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 231 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports12 fire reports27 injury reports
Service Brakes, Hydraulic complaints
231 reportsTHE EXHAUST MANIFOLD WAS FALLING OUT CAUSING VEHICLE TO LOSE GAS MILEAGE. VEHICLE EXPERIENCED PULSATED BRAKES WHEN DRIVING ON THE HWY AT 55 MPH. DEALER REPLACED BRAKES AND SURFACED ROTORS TO CORRECT THE PROBLEM. BRAKES FAILED AFTER SERVICED. HOWEVER, THE CALIBERS GOT VERY HOT WHICH BOILDED THE OIL IN THE BRAKES SYSTEM WHICH CA…
Read full complaint
THE EXHAUST MANIFOLD WAS FALLING OUT CAUSING VEHICLE TO LOSE GAS MILEAGE. VEHICLE EXPERIENCED PULSATED BRAKES WHEN DRIVING ON THE HWY AT 55 MPH. DEALER REPLACED BRAKES AND SURFACED ROTORS TO CORRECT THE PROBLEM. BRAKES FAILED AFTER SERVICED. HOWEVER, THE CALIBERS GOT VERY HOT WHICH BOILDED THE OIL IN THE BRAKES SYSTEM WHICH CAUSED THE FAILURE. *YC
BRAKES FAILED BECAUSE OF MASTER CYLINDER LEAKAGE. YH
ABS BRAKE PROBLEMS: WHEN APPLYING THE BRAKES UNDER NORMAL BRAKING CONDITIONS, VEHICLE IS SLOW IN STOPPING. THIS HAPPENS WHILE TRAVELING ON SMOOTH ROAD SURFACES AND NO INCLEMENT WEATHER. IT SEEMS AS THOUGH THE BRAKING SYSTEM IS INADEQUATE FOR THE TRUCK. DEALERSHIP STATED THAT THE BRAKE SYSTEM IS WORKING AS IT WAS DESIGNED. PLEAS…
Read full complaint
ABS BRAKE PROBLEMS: WHEN APPLYING THE BRAKES UNDER NORMAL BRAKING CONDITIONS, VEHICLE IS SLOW IN STOPPING. THIS HAPPENS WHILE TRAVELING ON SMOOTH ROAD SURFACES AND NO INCLEMENT WEATHER. IT SEEMS AS THOUGH THE BRAKING SYSTEM IS INADEQUATE FOR THE TRUCK. DEALERSHIP STATED THAT THE BRAKE SYSTEM IS WORKING AS IT WAS DESIGNED. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
REAR AND FRONT BRAKES WORN OUT. YH
I HAD ONLY THE VEHICLE A COUPLE TWO OR THREE MONTHS WHEN ONE DAY I FOUND MYSELF IN A SITUATION TO HAVE TO MAKE AN EMERGENCY STOP WHILE GOING ABOUT 35 MPH, WHEN I STOMPED ON THE BRAKES THE REAR BRAKES LOCKED UP AND THE TIRES SKID AND SCREECHED. THE FRONT END WENT TO THE RIGHT AND THE REAR END WENT TO THE LEFT ON THE INSIDE LANE …
Read full complaint
I HAD ONLY THE VEHICLE A COUPLE TWO OR THREE MONTHS WHEN ONE DAY I FOUND MYSELF IN A SITUATION TO HAVE TO MAKE AN EMERGENCY STOP WHILE GOING ABOUT 35 MPH, WHEN I STOMPED ON THE BRAKES THE REAR BRAKES LOCKED UP AND THE TIRES SKID AND SCREECHED. THE FRONT END WENT TO THE RIGHT AND THE REAR END WENT TO THE LEFT ON THE INSIDE LANE OF A FOUR LANE STREET WHICH PUT THE FRONT END IN THE RIGHT SAME DIRECTION LANE AND THE REAR END IN THE INSIDE ON-COMING LANE. IT REALLY SCARED ME AS I EXPECTED A TRUE STRAIGHT FORWARD STOP WITHOUT ANY SKIDDING. ALSO AT TIMES WHEN THE BRAKES ARE APPLIED NORMALLY THEY AT ANY SPEED THE BRAKES WILL PULL HARD ON THE STEERING WHEEL EITHER LEFT OR RIGHT. ONE NEVER KNOWS UNTIL THE BRAKES ARE APPLIED. I HAVE THIS VEHICLE INTO THREE DIFFERENT DEALERSHIP SERVICE DEPARTMENTS SEVERAL TIMES FOR REPAIR OF THIS AND MANY OTHER THINGS OVER THE PAST YEAR WHILE WORKING WITH THE CHEVROLET CUSTOMER ASSISTANCE OFFICE. FINALLY I WAS ALLOWED TO MEET WITH THE SOUTH CENTRAL REGION AREA SERVICE MANAGER FOR GENERAL MOTORS. HE DROVE THE VEHICLE AND ABOUT LOST CONTROL OF THE VEHICLE WHILE MAKING A SIMULATED EMERGENCY STOP. HE HAS ADVISED ME THAT IT WAS NORMAL. I DO NOT AGREE WITH HIM AS I HAVE AND HAVE HAD OTHER VEHICLES WITH ANTI-LOCK BRAKES THAT HAVE RESPONDED LIKE THAT. I FEEL LIKE THE VEHICLE IS DEFECTIVE AND DANGEROUS. I REQUESTED GM TO PURCHASE THE VEHICLE BACK FROM ME FOR THAT REASON AND THEY HAVE REFUSED.
WHEN APPLYING THE BRAKES PEDAL WENT ALL THE WAY DOWN TO THE FLOOR, THERE WAS A POPPING NOISE AND THERE WERE NO BRAKES. DRIVER LOST CONTROL OF THE VEHICLE AND FLIPPED OVER INTO MEDIAN. THE VEHICLE HAS NOT BEEN TOTALLED. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
BRAKES FAIL TO OPERATE PROPERLY. *AK
AT 11,000 MILES FRONT ROTORS ARE PREMATURELY WARPED, CAUSE UNKNOWN. ALSO WHEN APPLYING BRAKES THE FRONT END OF VEHICLE VIBRATES/SHAKES. PLEASE GIVE ANY FURTHER DETAILS. *AK
AFTER SEVERAL TRIPS TO THE DEALERSHIP TO HAVE THE PROBLEM CONNECTED TO THE TRANSMISSION FIXED, THE DEALERSHIP FINALLY REPLACED THE ENTIRE TRANSMISSION. THE PROBLEM PRESENTED ITSELF WHEN AFTER THE TRUCK WAS GOING, WHEN I HAD TO STOP FOR A LIGHT, STOP SIGN OR WHATEVER, I WOULD THEN ENGAGE THE GAS PEDAL. THE TRUCK WOULD ONLY INCH A…
Read full complaint
AFTER SEVERAL TRIPS TO THE DEALERSHIP TO HAVE THE PROBLEM CONNECTED TO THE TRANSMISSION FIXED, THE DEALERSHIP FINALLY REPLACED THE ENTIRE TRANSMISSION. THE PROBLEM PRESENTED ITSELF WHEN AFTER THE TRUCK WAS GOING, WHEN I HAD TO STOP FOR A LIGHT, STOP SIGN OR WHATEVER, I WOULD THEN ENGAGE THE GAS PEDAL. THE TRUCK WOULD ONLY INCH AWAY, WHEN MY FOOT WAS COMPLETELY DOWN ON THE GAS. THE SIDEVIEW MIRROR ON THE PASSENGER SIDE SHATTERED FOR NO APPARENT REASON, WHILE DRIVING ON AN OPEN ROAD. WHEN I TOOK THE TRUCK IN TO HAVE IT FIXED, I WAS TOLD THE ENTIRE BRAKE SYSTEM WOULD HAVE TO BE REPLACED. THE MASTER CYLINDER WAS LEAKING AND THE SHOES AND PADS WERE GONE. NOW MY TRUCK IS CURRENTLY GOING BACK TO THE DEALERSHIP BECAUSE THERE IS A KNOCKING NOISE IN THE STEERING WHEEL COLUMN AND A BUZZING NOISE WHEN THE FAN IS TURNED ON FOR HEAT.
Official recalls
100V122000 · Seat Belts:front:webbing
Apr 27, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE RIGHT FRONT PASSENGER RESTRAINT SYSTEMS MAY NOT MEET THE NECK EXTENSION REQUIREMENTS.
Remedy: DEALERS WILL INSTALL A TRAY INSERT ON THE TOP OF THE PASSENGER SIDE OF THE INSTRUMENT PANEL. THE TRAY INSERT CORRECTS THE NONCOMPLIANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE05020 · Unwanted LOW-SPEED Abs Activation
Opened Apr 28, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02015 · Throttle Sticking Closed
Opened Aug 1, 2002 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND 2) ACCUMULATION OF DEPOSITS (A PCV SYSTEM BY-PRODUCT) ON OR AROUND THE TB THROTTLE VALVE AND BORE.ODI CONCLUDES THAT THE TB PERFORMS IN A DEFECTIVE MANNER AFTER ANALYZING GM?S DATA SUBMISSIONS, AND TEST DATA COLLECTED BY THE VEHICLE RESEARCH AND TEST CENTER (VRTC).FIFTY-NINE CRASHES ARE ALLEGED TO HAVE OCCURRED AS A RESULT OF GM?S TB DEFECT.THE MAJORITY OF THE CRASHES INVOLVE A SINGLE VEHICLE, ENGAGING IN A CLOSE QUARTER VEHICLE MANEUVER (OR LOW SPEED), AND CAUSING ONLY MINOR PROPERTY DAMAGE.FOUR OUT OF THE FIFTY-NINE CRASHES INVOLVE INJURY, AND THOSE INJURIES WERE MINOR.ALTHOUGH GM?S TB IS DEFECTIVE, BASED ON THE EVIDENCE GATHERED, ODI HAS FOUND THAT THE ACCELERATOR PEDAL FORCE REQUIRED TO OPEN A STUCK THROTTLE VALVE IS NEGLIGIBLE, AND THE THROTTLE VALVE DOES NOT STICK IN THE OPEN POSITION.THEREFORE THIS ENGINEERING ANALYSIS (EA02-015) WILL BE CLOSED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FOR A DETAILED DISCUSSION OF THE TB COMPONENT AND TESTING, PLEASE SEE THE ATTACHED REPORT.
PE01023 · Seat Belt Anchorage Separation
Opened Jul 17, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER WINDOW OF THE VEHICLE.OCCUPANT SUSTAINED INJURY.GM HAS SUBSEQUENTLY CHANGED SEAT BELT ANCHORING DESIGN IN MY 2000. ODI HAS COMPLETED A PRELIMINARY INVESTIGATION AND HAS DETERMINED THAT FURTHER INFORMATION IS NEEDED TO DETERMINE WHETHER A SAFETY DEFECT EXISTS.
EA99011 · Erratic Power Steering Assist While Driv
Opened May 12, 1999 · Closed Feb 27, 2001
Status: closed (inferred from source dates) · Steering
THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND IN THE SUBJECT VEHICLE POPULATION.FUTHER EXPENDITURE OF AGENCY RESOURCES ON THIS SUBJECT DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ENGINEERING IS CLOSED.