Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 124 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports3 injury reports
What owners actually said
124 reports
Mileage unknown · Nov 27, 2025
Seat BeltsInjury
While driving a 2023 Chevrolet Suburban (VIN: [XXX] ), my [XXX] son was seated in the second-row center seat and was properly buckled in with the factory shoulder/lap belt. He turned around briefly to grab something from the back of the vehicle, and during that movement the seatbelt fully extended and then locked in the automat…
Read full complaint
While driving a 2023 Chevrolet Suburban (VIN: [XXX] ), my [XXX] son was seated in the second-row center seat and was properly buckled in with the factory shoulder/lap belt. He turned around briefly to grab something from the back of the vehicle, and during that movement the seatbelt fully extended and then locked in the automatic locking mode. The retractor would not release tension afterward. The belt continued tightening around his torso, and no amount of slack could be pulled back out. The belt became so tight that he was unable to breathe comfortably or free himself, and the locking mechanism would not disengage even after the vehicle was stopped and turned off. The seatbelt remained fully cinched and would not retract or loosen under any circumstances. Because the belt created a serious entrapment hazard and my child could not safely be removed, I was forced to cut the seatbelt to free him. This appears to be a dangerous malfunction of the seatbelt retractor/locking system and presents a significant safety risk, especially for children who may shift or turn in their seats during normal use. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11701833
Mileage unknown · Nov 17, 2025
Engine
My 2023 Chevrolet Suburban High Country (VIN: [XXX] ) suffered a sudden and dangerous engine failure while my wife was driving 70 mph on the interstate returning from our child’s sled hockey tournament in Ohio. The vehicle gave no warning lights, alerts, or diagnostic messages before the failure. While driving in the right lane…
Read full complaint
My 2023 Chevrolet Suburban High Country (VIN: [XXX] ) suffered a sudden and dangerous engine failure while my wife was driving 70 mph on the interstate returning from our child’s sled hockey tournament in Ohio. The vehicle gave no warning lights, alerts, or diagnostic messages before the failure. While driving in the right lane, the vehicle began losing power and making a loud noise. My wife exited the highway and contacted OnStar, who told her the tow would take over an hour and only cover three miles to closest dealer, leaving her stranded in an unsafe area. She attempted to carefully reach a nearby dealership. During this attempt, the vehicle completely shut off and she lost all engine power. The vehicle lost all power making the final turn into the dealership coming to rest in the middle of oncoming traffic of a four lane road. The Suburban would not restart. A tow truck arrived and transported the vehicle to a dealership. When they arrived, the tow driver noticed smoke and a strong burning odor coming from the engine compartment and told her to move away from the vehicle because it could potentially catch fire. The vehicle was left in the lot with the hood open and positioned away from the building for safety. The dealership has determined the engine suffered a catastrophic failure and requires complete replacement. Multiple related components may also be affected. This occurred on a vehicle with only 54,000 miles that was purchased three months earlier. This incident created a serious safety risk for my wife, who was nearly stranded on an interstate and had to maneuver a powerless vehicle across several lanes of traffic. I am reporting this to NHTSA due to the sudden failure at highway speed, lack of warning, and potential fire hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11699730
Mileage unknown · Nov 7, 2025
EnginePower Train
I was driving the vehicle and without warning it just stopped shut off and immediately shot an error code that there was a critical issue with the engine and that the oil pressure was low, and the vehicle would not start and was not drivable. It had to be towed to a dealership.
NHTSA ODI #11698254
Mileage unknown · Nov 6, 2025
EngineFuel/propulsion System
My 2023 Chevrolet Suburban with the 5.3L V8 engine has experienced lifter failure twice within less than [20,000 miles]. Both times the vehicle developed a misfire, engine belt like noise and was diagnosed by the Chevrolet dealership as having collapsed AFM/DFM lifters. All oil changes have been done at the dealership using GM-…
Read full complaint
My 2023 Chevrolet Suburban with the 5.3L V8 engine has experienced lifter failure twice within less than [20,000 miles]. Both times the vehicle developed a misfire, engine belt like noise and was diagnosed by the Chevrolet dealership as having collapsed AFM/DFM lifters. All oil changes have been done at the dealership using GM-approved oil. The issue appears to be a known problem on 2021–2023 GM vehicles with the 5.3L L84 engine. GM has a technical service bulletin (PIP5776H) regarding lifter collapse, but no permanent fix has been provided. I am concerned this could lead to engine failure or stalling while driving, creating a safety hazard.
NHTSA ODI #11697887
Mileage unknown · Oct 30, 2025
Service Brakes
I went to get in my 2023 suburban this morning to travel to the gym. It started but it would not shift out of park. I looked down and noticed the check engine light was on, the ABS light was on, and the park brake light was on with a lock and wrench. I had no issues since I purchased it used in March 2025 and yesterday it was dr…
Read full complaint
I went to get in my 2023 suburban this morning to travel to the gym. It started but it would not shift out of park. I looked down and noticed the check engine light was on, the ABS light was on, and the park brake light was on with a lock and wrench. I had no issues since I purchased it used in March 2025 and yesterday it was driving fine.
NHTSA ODI #11696501
52,000 miles · Oct 22, 2025
Engine
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at 10 MPH, there was an abnormal rumbling sound coming from the engine, with the check engine and traction control warning lights illuminated. Due to the failure, the contact restarted the vehicle and drove to an independent mechanic. The mechanic …
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at 10 MPH, there was an abnormal rumbling sound coming from the engine, with the check engine and traction control warning lights illuminated. Due to the failure, the contact restarted the vehicle and drove to an independent mechanic. The mechanic performed a diagnostic test on the vehicle and discovered a misfire in cylinder #3. The mechanic replaced the cylinder #3 ignition coil; however, the failure persisted. The contact then had another independent mechanic at the same shop inspect the vehicle, and the mechanic diagnosed the vehicle with engine failure. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 52,000.
NHTSA ODI #11694924
Mileage unknown · Oct 19, 2025
Fuel/propulsion System
car jerks with initial acceleration
NHTSA ODI #11694418
Mileage unknown · Oct 8, 2025
Unknown Or Other
When driving making a left or right hand turn my 2023 Suburban loose power and turns off and it is thrown in N and state to press start to restart my SUV. No codes are given to determine the issue. This has happen a handful of times. It has been taken into Chevy and they are unable to diagnose the problem. During the one visit t…
Read full complaint
When driving making a left or right hand turn my 2023 Suburban loose power and turns off and it is thrown in N and state to press start to restart my SUV. No codes are given to determine the issue. This has happen a handful of times. It has been taken into Chevy and they are unable to diagnose the problem. During the one visit they stated it was the battery and replace it and it has done it again. This is a very unsafe to drive the SUV as I'm afraid someone will rear end me and hurt me or someone else.
NHTSA ODI #11692132
Mileage unknown · Oct 7, 2025
Power Train
2023 Chevy Suburban transmission control valve failures causing wheel lockup or deceleration causing the vehicle to be unsafe to operate. Chevrolet refuses to acknowledge.
NHTSA ODI #11691800
20,000 miles · Sep 16, 2025
Engine
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving approximately 30 MPH, the vehicle suddenly shut off without warning. After restarting the vehicle, the vehicle operated normally. The contact stated that the failure had occurred on several occasions. The vehicle was taken to the local dealer, who…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving approximately 30 MPH, the vehicle suddenly shut off without warning. After restarting the vehicle, the vehicle operated normally. The contact stated that the failure had occurred on several occasions. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not yet contacted. The failure mileage was approximately 20,000.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 Chevrolet Suburban Problems, Complaints & Recalls | Skip That Year
Illustration