NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
119 reports95,000 miles · Aug 19, 2026
Electrical System
The contact owns a 2022 Chevrolet Suburban. The contact stated that while attempting to start the vehicle, the instrument panel displayed a blank screen. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed, and it was determined that the instrument panel needed to be replaced. The vehicle was not repaired…
Read full complaint
The contact owns a 2022 Chevrolet Suburban. The contact stated that while attempting to start the vehicle, the instrument panel displayed a blank screen. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed, and it was determined that the instrument panel needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 95,000.
NHTSA ODI #11758091
Mileage unknown · Aug 19, 2026
Electrical System
The telematics control module in this vehicle failed. A dealer diagnostic scan on 03/09/2026 at 67,839 miles documented the following active and history codes: U0198 Lost Communication with Telematics Module, reported independently by the Radio, Body Control Module, and Instrument Panel Cluster Control Module; U0499 Invalid Data…
Read full complaint
The telematics control module in this vehicle failed. A dealer diagnostic scan on 03/09/2026 at 67,839 miles documented the following active and history codes: U0198 Lost Communication with Telematics Module, reported independently by the Radio, Body Control Module, and Instrument Panel Cluster Control Module; U0499 Invalid Data Received from Telematics Module, reported by the Engine Control Module; U1962 Unable to Authenticate Serial Data Message; B1A1F Ethernet Bus 4 (+) Circuit Open with a Low Voltage/High Temperature symptom; and P00FF Body Control Module Requested MIL Illumination, listed as Current. As a result, the check engine light is commanded on. All OnStar functions are inoperative, including Automatic Crash Response and Emergency SOS, which are safety systems. The OnStar button has no illumination at all. Remote functions and vehicle connectivity are dead. No warning message or notification of a module fault was ever displayed in the vehicle. The infotainment system reports “Your Software is Up-to-Date” and the Device Registration screen reports “Registered.” The last over-the-air software update this vehicle received was in August 2023
NHTSA ODI #11758065
Mileage unknown · Aug 18, 2026
Unknown Or Other
2022 chevy suburban diesel. Severe paint chipping and rust around windshield and top of truck. Midnight blue is the color and chevy is not covering the his defect of it destroying my truck right now complete rust and chunks of paint chipping away on the windshield it is so noticeable how bad this is chipping. And whole top of t…
Read full complaint
2022 chevy suburban diesel. Severe paint chipping and rust around windshield and top of truck. Midnight blue is the color and chevy is not covering the his defect of it destroying my truck right now complete rust and chunks of paint chipping away on the windshield it is so noticeable how bad this is chipping. And whole top of truck and front paneling show same signs everywhere of bubbling ready to chip away soon. The corrosion on truck that should not occur On a 4 year anniversary or truck from chevy a 2022! I’ve been asking for this for months as 9,500 for a paint job quote for something that it shouldn’t need to be done a paint job with rust. Chevy needs to step up and fix this. I’m a mother to 7 daughters and we need this vehicle.
NHTSA ODI #11757705
39,000 miles · Aug 3, 2026
Engine
The contact owns a 2022 Chevrolet Suburban. The contact stated that while attempting to start the vehicle with the Push-To-Start button, the engine failed to turn over. The check engine warning light was illuminated. The contact's husband was notified of DTC: P129F, which was diagnosed by the OnStar App. The vehicle was towed to…
Read full complaint
The contact owns a 2022 Chevrolet Suburban. The contact stated that while attempting to start the vehicle with the Push-To-Start button, the engine failed to turn over. The check engine warning light was illuminated. The contact's husband was notified of DTC: P129F, which was diagnosed by the OnStar App. The vehicle was towed to a local dealer where it was diagnosed with a defective fuel control module. The vehicle was scheduled to be repaired out-of-pocket. Upon further investigation, the contact associated the failure with General Motors Emissions Recall: N252516900; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 39,000.
NHTSA ODI #11754534
Mileage unknown · Jul 9, 2026
Engine
Driving down XXX going back home was driving normal when suv shut off on freeway with no warning what so ever i was 12 hours away from home almost crashed into bridge side wall was stranded on side of freeway with my whole family n my new born baby in the heat motor locked up per dealer 74k miles had to pay tow truck n a ren…
Read full complaint
Driving down XXX going back home was driving normal when suv shut off on freeway with no warning what so ever i was 12 hours away from home almost crashed into bridge side wall was stranded on side of freeway with my whole family n my new born baby in the heat motor locked up per dealer 74k miles had to pay tow truck n a rental to get back home INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11749284
Mileage unknown · Jun 30, 2026
Power Train
I own a 2022 Chevrolet Suburban with approximately 115,000 miles. While driving, the check engine light illuminated and the vehicle suddenly entered limp mode. The transmission lost normal operation, including reverse gear, significantly limiting the vehicle’s ability to operate. The failure occurred without warning and created …
Read full complaint
I own a 2022 Chevrolet Suburban with approximately 115,000 miles. While driving, the check engine light illuminated and the vehicle suddenly entered limp mode. The transmission lost normal operation, including reverse gear, significantly limiting the vehicle’s ability to operate. The failure occurred without warning and created a potential safety concern because the vehicle could no longer respond normally to driving conditions. The vehicle was inspected by a Chevrolet dealership, where technicians diagnosed a failed transmission control valve body and confirmed the valve body required replacement. I paid to have the repair completed. After the repair, I learned that GM issued Special Coverage N242454441 for certain 2021-2022 Chevrolet Suburban vehicles equipped with the same transmission. The bulletin describes premature transmission control valve wear that can cause a service engine light, reduced engine performance, harsh shifting, and requires replacement of the transmission control valve body. My vehicle experienced the same failure and required the same repair, but my VIN was not included in the covered population. I contacted GM before authorizing the repair and requested assistance, but my request was denied because my VIN was not included in the special coverage. I am submitting this complaint because my vehicle experienced the same transmission valve body failure identified by GM despite not being included. I request that NHTSA document this failure and determine whether additional vehicles equipped with the same transmission should be included in any current or future safety investigation.
NHTSA ODI #11747576
Mileage unknown · Jun 28, 2026
Fuel/propulsion System
Vehicle was recalled for loss of propulsion.Pico test was done ,changed oil.6,000 miles later engine locked up on freeway.Engine is in for replacement.2022 suburban 6.2 liter 66,000 miles
NHTSA ODI #11747008
Mileage unknown · Jun 3, 2026
Power Train
UNKNOWN TRANSMISSION ISSUES MENTIONED IN OTHER RECALLS FOR SAME PERIOD/MAKE MODEL AS LISTED YET MY VIN was not, as a mother 4 little ones I need my vehicle to perform as it was design to, the cost for this repair is over 6,000.00 I have already invested over 40,000 since I brought it. I feel they ought have included my car on th…
Read full complaint
UNKNOWN TRANSMISSION ISSUES MENTIONED IN OTHER RECALLS FOR SAME PERIOD/MAKE MODEL AS LISTED YET MY VIN was not, as a mother 4 little ones I need my vehicle to perform as it was design to, the cost for this repair is over 6,000.00 I have already invested over 40,000 since I brought it. I feel they ought have included my car on this recent recall they had to have known this problem was of their why else would there recalls. I still must pay monthly for a vehicle that does perform as it should. This impacts my ability to provide for the needs of my children. I hope relief is on the way.
NHTSA ODI #11741887
Mileage unknown · May 22, 2026
Electrical System
The telecommunications module for vehicle GPS and OnStar emergency services failed after a factory software update. Now the vehicle has no GPS location, information emergency OnStar services or the ability to access vehicle Telematic via cell signal or an app. Dealer refused to cover the item under the 36 month bumper-to-bumper …
Read full complaint
The telecommunications module for vehicle GPS and OnStar emergency services failed after a factory software update. Now the vehicle has no GPS location, information emergency OnStar services or the ability to access vehicle Telematic via cell signal or an app. Dealer refused to cover the item under the 36 month bumper-to-bumper warranty leaving the consumer stuck with a $2000 cost just to have GPS in the vehicle and maintain contact with emergency services through OnStar.
NHTSA ODI #11739446
28,000 miles · May 18, 2026
Electrical SystemLatches/locks/linkages
The contact owns a 2022 Chevrolet Suburban. The contact stated that the vehicle was taken to the local dealer for painting services. Upon retrieval of the vehicle, the service drive assist message was displayed. The doors failed to lock. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance…
Read full complaint
The contact owns a 2022 Chevrolet Suburban. The contact stated that the vehicle was taken to the local dealer for painting services. Upon retrieval of the vehicle, the service drive assist message was displayed. The doors failed to lock. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. Additionally, the contact contacted a lawyer. The failure mileage was approximately 28,000.
NHTSA ODI #11738482
Official recalls
4Feb 13, 2026
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence & remedy
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Aug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
Consequence & remedy
Consequence: A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Remedy: Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration