2022 Chevrolet Suburban

Just for information purposes, I have been an ASE certified Master automotive technician for 30 years. As I was accelerating onto the highway, my transmission downshifted hard, throwing everything forward. It then went into limp mode with “ses” light on. I was able to drive it home stuck in one gear. The next morning I tried to drive the truck. It had reverse but when trying to go forward, the transmission was stuck in between gears and fighting itself. I manually shifted into low gear and it seemed to clear up the binding. I drove the truck up and down my driveway which is about a half mile long. No more “ses” light but when I went to park it, there was no movement in reverse. As I researched the problem I found the recall information on the valve body. I called several dealerships to find a service writer that had experience with these transmission issues. The truck was towed to a dealership that knew about this recall. Their technician checked for codes but there were none. It seems these trucks reset or “lose” codes when the ignition is turned off. He checked the fluid and decided that the reverse clutch must be burned up. They quoted a transmission replacement at $6500. I asked if they had driven the truck forward at all to reset any trouble codes. The truck was “unsafe” to drive due to the random harsh downshift and erratic behavior. I went there(putting myself in danger) to drive the truck to reset any trouble codes. Within a mile the truck did the same thing. It stored a code P2732. I was informed that GM would not do anything for me unless there was a P747. After reasoning with the service manager and also GM, it was obvious I was out of luck. I had the truck towed home and removed the transmission pan. The fluid was clean and there was no debris. The problem is in the defective valve body from GM but since it didn’t have the code P0747 I’m stuck having to repair it myself. The truck has 126k miles still well within the extended service range.

I own a 2022 Chevrolet Suburban with approximately 115,000 miles. While driving, the check engine light illuminated and the vehicle suddenly entered limp mode. The transmission lost normal operation, including reverse gear, significantly limiting the vehicle’s ability to operate. The failure occurred without warning and created a potential safety concern because the vehicle could no longer respond normally to driving conditions. The vehicle was inspected by a Chevrolet dealership, where technicians diagnosed a failed transmission control valve body and confirmed the valve body required replacement. I paid to have the repair completed. After the repair, I learned that GM issued Special Coverage N242454441 for certain 2021-2022 Chevrolet Suburban vehicles equipped with the same transmission. The bulletin describes premature transmission control valve wear that can cause a service engine light, reduced engine performance, harsh shifting, and requires replacement of the transmission control valve body. My vehicle experienced the same failure and required the same repair, but my VIN was not included in the covered population. I contacted GM before authorizing the repair and requested assistance, but my request was denied because my VIN was not included in the special coverage. I am submitting this complaint because my vehicle experienced the same transmission valve body failure identified by GM despite not being included. I request that NHTSA document this failure and determine whether additional vehicles equipped with the same transmission should be included in any current or future safety investigation.

UNKNOWN TRANSMISSION ISSUES MENTIONED IN OTHER RECALLS FOR SAME PERIOD/MAKE MODEL AS LISTED YET MY VIN was not, as a mother 4 little ones I need my vehicle to perform as it was design to, the cost for this repair is over 6,000.00 I have already invested over 40,000 since I brought it. I feel they ought have included my car on this recent recall they had to have known this problem was of their why else would there recalls. I still must pay monthly for a vehicle that does perform as it should. This impacts my ability to provide for the needs of my children. I hope relief is on the way.

While driving down the high way with the check engine light on, a message appeared on the screen and said “unable to shift soon. Service transmission immediately.” After driving a few more miles the vehicle shifted to neutral, and then as soon as I got on the shoulder of the highway and slowed to approximately 5 mph, the vehicles wheels locked up and the car jerked aggressively into park. This exact issue has occurred multiple times while driving. It is unsafe to drive the vehicle.

Having reviewed online your safety recall number N252536750, I am experiencing the same issue (right rear wheel occasionally locks when starting from a standstill and turning right). It only lasts about 1 or 2 seconds while accelerating. However, when I discussed this with my Chevrolet Dealer, I was told that according to the VIN for my 2022 Suburban 3.0L Diesel, I am not part of that recall. I plan to take it to the Chevrolet Dealer very soon for more analysis. However, I wanted to bring this to your attention, as it could be hazardous. I have not gotten any dash warning messages. Thank you.

The contact owns a 2022 Chevrolet Suburban. The contact stated that while driving 50 MPH, the transmission unexpectedly shifted to neutral(N) and the vehicle shut off. The driver was able to coast safely to the side of the road. The vehicle failed to restart. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was determined that the engine needed to be rebuilt or replaced. The vehicle was not repaired. The vehicle was previously taken to the same dealer for a prior recall repair. The dealer had provided a loaner vehicle. The manufacturer was not notified of the failure. The failure mileage was approximately 58,166.

In several separate unreplicable instances, the vehicle has turned off while driving, once on the highway, once on my street, once turning across heavy traffic, and others. I've almost died a couple times and I've taken it to the dealership several times, they have Not been able to find anything wrong with it and have been unable to replicate the issue. The engine has been replaced, and it was happening before and since. My 2023 is also doing the same thing.

The contact owns a 2022 Chevrolet Suburban. The contact stated that while his wife was driving at an undisclosed speed, the rear wheels seized. There were several unknown warning lights illuminated. The message "Reduced Acceleration, Drive with Caution" was displayed. The contact's wife pulled into a parking lot, but the transmission failed to shift into reverse(R). The vehicle was towed to the dealer, where it was determined that the transmission control valve needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 26V085000 (Power Train); however, the VIN was not included in the recall. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 86,000.

My vehicle was subject to a GM recall involving inspection of the 6.2L engine. The recall inspection was completed by an authorized GM dealership at 58,581 miles. The vehicle was cleared as passing the recall criteria and returned to me. Within fewer than 10 miles after leaving the dealership following the recall inspection, at approximately 58,590 miles, the vehicle experienced a sudden loss of propulsion while traveling at highway speed (approximately 65 mph) on a divided U.S. highway while ascending an incline. The vehicle shifted into neutral and lost engine power without warning. Steering and braking remained functional, but the vehicle lost forward motive power in the left lane of traffic. Attempts to restart the engine resulted in a loud mechanical thud, and the engine would not restart. The vehicle was towed to the dealership. The engine is now being replaced. Prior to this incident, the vehicle had previously undergone an oil consumption test related to engine concerns before the recall campaign. This failure occurred shortly after the vehicle was inspected and cleared under the recall procedure. I am reporting this due to the sudden loss of propulsion at highway speed following recall inspection and the subsequent need for complete engine replacement.