NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
149 reportsClear category filter62,000 miles · Oct 28, 2017
Service Brakes
WHILE DRIVING, THE DASH MESSAGE ALERTED ME THAT I NEEDED TO "SERVICE BRAKE ASSIST." I WAS NOT USING THE BRAKES, SO I STARTED TO SLOW DOWN AND THE BRAKES WORKED, BUT WHEN I CAME TO THE LIGHT, IT WAS LIKE PRESSING A ROCK AND THE PEDAL WOULD NOT PUSH DOWN. I HAD COMPLETE BRAKE FAILURE, BUT THANKFULLY HAD SLOWED ENOUGH BEFORE COMING…
Read full complaint
WHILE DRIVING, THE DASH MESSAGE ALERTED ME THAT I NEEDED TO "SERVICE BRAKE ASSIST." I WAS NOT USING THE BRAKES, SO I STARTED TO SLOW DOWN AND THE BRAKES WORKED, BUT WHEN I CAME TO THE LIGHT, IT WAS LIKE PRESSING A ROCK AND THE PEDAL WOULD NOT PUSH DOWN. I HAD COMPLETE BRAKE FAILURE, BUT THANKFULLY HAD SLOWED ENOUGH BEFORE COMING TO THE LIGHT, THAT I COULD THROW THE CAR INTO PARK. I PULLED INTO A PARKING LOT AND TAPPED THE BRAKES SEVERAL TIMES, TURNED MY CAR OFF, TURNED IT BACK ON, PUT THE PARKING BRAKE ON AND OFF. THE BRAKES WORKED SO I BEGAN DRIVING VERY CAUTIOUSLY AND STUCK TO BACK ROADS AND STAYED UNDER 35 MPH. THE BRAKES FAILED TWICE MORE AT A STOP SIGN AND A RED LIGHT, WHILE I WAS DRIVING AT LOW SPEEDS. I DROVE THE CAR ONE MORE TIME A FEW HOURS LATER AND HAD COMPLETE BRAKE FAILURE EVERY TIME I TRIED TO STOP. I HAD TO EITHER THROW THE CAR INTO PARK, OR DRIVE INTO A PARKING LOT TO SLOW DOWN. I HAD IT TOWED TO A SERVICE CENTER AT THE CHEVY DEALERSHIP. THE VEHICLE IS UNDER 3 YEARS OLD, HAS ABOUT 60,000 MILES ON IT, HAS BEEN KEPT IN GREAT CONDITION, HAS ON TIME OIL CHANGES, NEVER BEEN IN AN ACCIDENT, AND HAS NEW TIRES. THE CAR HAD NO SQUEALING OR GRINDING TO SHOW WEAR AND TEAR, OR ANY OTHER INDICATOR THE BRAKES WOULD FAIL. THE DEALERSHIP MAINTAINS THAT THIS IS NOT COVERED BECAUSE WE ARE OUT OF WARRANTY, HOWEVER, WE HAVE AN EXTENDED WARRANTY THAT WE ARE USING TO FIX THIS ISSUE. IT IS UNKOWN THE EXACT CAUSE, BECAUSE IT IS AT THE SHOP AWAITING DIAGNOSTICS.
NHTSA ODI #11040665
75,000 miles · Oct 1, 2017
Service BrakesCrashInjury
WHILE DRIVING ON I90 IN STOP AND GO TRAFFIC, THE CAR IN FRONT OF ME STOPPED. I APPLIED MY BRAKES AND THE PEDAL WAS HARD AND WOULD NOT DEPRESS. AS A RESULT MY CAR WOULD NOT STOP AND I HIT THE CAR IN FRONT OF ME IN THE REAR END. MY AIR BAGS WENT OFF. I RECEIVED AN AIR BAG BURN. THE CAR IN FRONT OF ME STRUCK THE CAR IN FRONT OF HI…
Read full complaint
WHILE DRIVING ON I90 IN STOP AND GO TRAFFIC, THE CAR IN FRONT OF ME STOPPED. I APPLIED MY BRAKES AND THE PEDAL WAS HARD AND WOULD NOT DEPRESS. AS A RESULT MY CAR WOULD NOT STOP AND I HIT THE CAR IN FRONT OF ME IN THE REAR END. MY AIR BAGS WENT OFF. I RECEIVED AN AIR BAG BURN. THE CAR IN FRONT OF ME STRUCK THE CAR IN FRONT OF HIM. BOTH OTHER DRIVERS CLAIM THEY WERE INJURED. MY CAR COST $15,300 TO REPAIR. CHEVROLET IS AWARE OF THIS PROBLEM, ISSUING PRELIMINARY SERVICE BULLETIN PIT5361 IN 2015, ADDENDUM B IN 2016 AND ADDENDUM B IN 2017. THE PROBLEM IS A FAULTY VACUUM PUMP, MASTER CYLINDER, BRAKE BOOSTER, VACUUM LINE, AND VACUUM PUMP BELT. I WAS NEVER INFORMED OF THIS PROBLEM. I HAVE BEEN DRIVING 50 YEARS AND THIS IS MY FIRST CHARGEABLE ACCIDENT.
NHTSA ODI #11030722
51,800 miles · Sep 26, 2017
Service Brakes
TL* THE CONTACT OWNS A 2015 CHEVROLET SUBURBAN. WHILE EXITING THE PARKING LOT AT 5 MPH, THE BRAKES FAILED TO WORK WITHOUT WARNING. THE CONTACT HAD TO CHANGE THE GEAR TO PARK IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER (BOB PRICE CHEVROLET BUICK GMC, 1225 S STATE HWY 16, FREDERICKSBURG, TX 78624) WHERE IT WA…
Read full complaint
TL* THE CONTACT OWNS A 2015 CHEVROLET SUBURBAN. WHILE EXITING THE PARKING LOT AT 5 MPH, THE BRAKES FAILED TO WORK WITHOUT WARNING. THE CONTACT HAD TO CHANGE THE GEAR TO PARK IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER (BOB PRICE CHEVROLET BUICK GMC, 1225 S STATE HWY 16, FREDERICKSBURG, TX 78624) WHERE IT WAS DIAGNOSED THAT THE BRAKE BOOSTER AND THE BRAKE PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 51,800.
NHTSA ODI #11030016
51,000 miles · Aug 28, 2017
Service Brakes
THE BRAKES ON MY 2015 CHEVY SUBURBAN ARE LOCKING WHEN DRIVING A LOW SPEED. THE PROBLEM STARTED ALL OF THE SUDDEN WHILE DRIVING UNDER DRY ROAD CONDITIONS ON A CITY STREET. IF YOU PRESS ON THE BRAKE PEDAL , IT DOES NOT MOVE AND THE CAR DOES NOT STOPPED. I ALMOST HIT A FAMILY OF 4 THAT WAS CROSSING IN FRONT OF ME. THE CAR HAS BE…
Read full complaint
THE BRAKES ON MY 2015 CHEVY SUBURBAN ARE LOCKING WHEN DRIVING A LOW SPEED. THE PROBLEM STARTED ALL OF THE SUDDEN WHILE DRIVING UNDER DRY ROAD CONDITIONS ON A CITY STREET. IF YOU PRESS ON THE BRAKE PEDAL , IT DOES NOT MOVE AND THE CAR DOES NOT STOPPED. I ALMOST HIT A FAMILY OF 4 THAT WAS CROSSING IN FRONT OF ME. THE CAR HAS BEEN AT DICK BEARD CHEVROLET IN HYANNIS, MA AND THEY ARE SAYING THAT THERE IS NO ISSUE WITH THE BRAKES AND AVOIDING SOLVING THE PROBLEM. I'VE CALLED CHEVROLET 4 TIMES AND THEY ARE NOT CALLING ME BACK. THE CAR IS NOT SAFE TO DRIVE AT ALL.
NHTSA ODI #11020065
38,805 miles · Jun 17, 2017
Service Brakes
BRAKE BOOSTER WENT OUT WHILE DRIVING WITH MY CHILDREN IN THE CAR!
NHTSA ODI #10995718
Mileage unknown · Jun 14, 2017
Service Brakes
BRAKES STOPPED WORKING . FIRST TIME IT HAPPENED I THOUGHT IT WAS MY IMAGINATION AS I WAS IN A PARKING LOT GOING EXTREMELY SLOW. NEXT DAY IT HAPPENED WHEN BACKING OUT OF MY DRIVEWAY. HAD TO PRESS BRAKES EXTREMELY HARD AND IT ROLLED TO A STOP AS IT HIT CURB ON OTHER SIDE OF ROAD. TOOK IT TO DEALER AND THEY REPLACE THE VACUUM BOO…
Read full complaint
BRAKES STOPPED WORKING . FIRST TIME IT HAPPENED I THOUGHT IT WAS MY IMAGINATION AS I WAS IN A PARKING LOT GOING EXTREMELY SLOW. NEXT DAY IT HAPPENED WHEN BACKING OUT OF MY DRIVEWAY. HAD TO PRESS BRAKES EXTREMELY HARD AND IT ROLLED TO A STOP AS IT HIT CURB ON OTHER SIDE OF ROAD. TOOK IT TO DEALER AND THEY REPLACE THE VACUUM BOOSTER WHICH HAD FAILED AT APROX. 50,000 MILES. NOT COVERED UNDER WARRANTY. EVERY OTHER PART OF BRAKES BESIDES NORMAL WEAR AND TEAR IS COVERED. I WAS LUCKY IT HAPPENED IN MY DRIVEWAY AND NOT WHILE DRIVING AT HIGHER SPEEDS IN TRAFFIC. I HAVE ADDITIONAL COMPLAINTS ABOUT THIS VEHICHLE. THE CLIPS HOLDING DRIVERS SEAT HAD TO BE REPLACED AT 40,000 MILES BECAUSE SEAT WAS SLIDING FROM SIDE TO SIDE. THEY ARE ALL READY LOOSE AGAIN AT 60,000 MILES ALTHOUGH NOT AS BAD AS FIRST TIME. MY AC CONDENSER WENT OUT AT 62,000 MILES. IT HAS BEEN ON NATIONAL BACKORDER FOR 7 WEEKS AND I AM STILL WAITING. THE CAR SHAKES ON THE INTERSTATE AT APROX 70 -75 MILES PER HOUR. THE DEALERSHIP HAS BALANCED THE TIRES AND THIS HAS NOT FIXED PROBLEM. AFTER DRIVING ON INTERSTATE AT HIGH SPEEDS FOR EXTENDED PERIOD OF TIME, WHEN STOPPING THE CAR IDLES VERY ROUGH AND HAS EVEN CUT OFF. THE DEALERSHIP RAN A FUEL INDUCTION SERVICE. WILL SEE IF IT WORKS WHEN I GET IT BACK AFTER THEY REPLACE AC CONDENSER. THE CAR SHIFTS HORRIBLY, ESPECIALLY WHEN GOING SLOW. WAS TOLD THAT IS A PROBLEM WITH THE FUEL EFFICIENT SHIFTING AND THERE IS NO REPAIR...JUST TO MANUALLY SHIFT. ALSO, THE HOOD OF THE CAR HAS TINY RUST SPOTS COMING THROUGH THE PAINT ALL OVER IT.
NHTSA ODI #10995134
95,961 miles · Apr 10, 2017
EngineService BrakesVehicle Speed Control
I WAS ON SLOPE HILL. MY BRAKES ARE NOT RESPONDING. I PUT IN NEW BRAKES 2 MONTHS AGO AND BRAKES NOT RESPONDING? MY CAR ALMOST WENT DOWN THE HILL. I CALLED ROADSIDE ASSISTANCE AND HAD THEM TOWED MY CAR TO DEALERSHIP. THEY FOUND THE ISSUE VACUUM PUMP BROKE. ALSO MY TRANSMISSION HAVING ISSUE SINCE 2 MONTHS. THEY STILL HAVEN'T FOUND …
Read full complaint
I WAS ON SLOPE HILL. MY BRAKES ARE NOT RESPONDING. I PUT IN NEW BRAKES 2 MONTHS AGO AND BRAKES NOT RESPONDING? MY CAR ALMOST WENT DOWN THE HILL. I CALLED ROADSIDE ASSISTANCE AND HAD THEM TOWED MY CAR TO DEALERSHIP. THEY FOUND THE ISSUE VACUUM PUMP BROKE. ALSO MY TRANSMISSION HAVING ISSUE SINCE 2 MONTHS. THEY STILL HAVEN'T FOUND ISSUES. I CAN'T CONTROL MY SPEED AND ENGINE GIVES A KICK WHEN ENTERING HIGHWAY. THEY WON'T REPAIR THIS ISSUE BECAUSE THEIR "MECHANICS" CANNOT FIND THE ISSUE. THIS IS THIS WORST VEHICLE TO DRIVE ANDUNSAFE FOR DRIVERS AND PASSENGERS.
NHTSA ODI #10971549
51,000 miles · Feb 28, 2017
Service BrakesCrashInjury
WHILE DRIVING HER VEHICLE TODAY MY WIFE DEPRESSED HER BRAKE TO STOP AND SHE SAID THE BRAKE FELT LIKE PUSHING ON A RUBBER TIRE. THE CAR WOULD NOT STOP CAUSING HER TO RUN A STOP SIGN AND HIT ANOTHER VEHICLE. WE HAD THE SAME PROBLEM LAST MONTH AND THE VEHICLE WAS TAKEN TO THE CHEVROLET DEALERSHIP AND "REPAIRED" ACCORDING TO THE C…
Read full complaint
WHILE DRIVING HER VEHICLE TODAY MY WIFE DEPRESSED HER BRAKE TO STOP AND SHE SAID THE BRAKE FELT LIKE PUSHING ON A RUBBER TIRE. THE CAR WOULD NOT STOP CAUSING HER TO RUN A STOP SIGN AND HIT ANOTHER VEHICLE. WE HAD THE SAME PROBLEM LAST MONTH AND THE VEHICLE WAS TAKEN TO THE CHEVROLET DEALERSHIP AND "REPAIRED" ACCORDING TO THE CURRENT SAFETY BULLETIN ISSUED BY CHEVROLET. THIS COLLISION CAUSED THE OTHER PERSON TO GO TO THE HOSPITAL VIA EMS AND MY WIFE WAS TAKEN BY POV TO ER FOR EVALUATION. OBVIOUSLY WHATEVER "FIX" WAS DONE BY THE DEALERSHIP WAS NOT THE CAUSE OF THE PROBLEM. I WAS TOLD THE VACUUM ASSIST PUMP AND HOSES WERE REPLACED, BUT THE VEHICLE STILL HAD THE SAME ISSUE.
NHTSA ODI #10957711
59,000 miles · Feb 23, 2017
Electronic Stability Control (esc)Service BrakesSuspension
CAR ONLY HAS 60,000 MILES BRAKE BOOSTER IS GOING OUT AND CHEVY KNOWS THERE IS A PROBLEM BUT HAVE NOT RECALLED. ALSO FRONT SHOCKS ARE GOING OUT DUE TO MAGNETIC RIDE SYSTEM LOTS OF PEOPLE HAVE THE SAME PROBLEM CHEVY ONCE AGAIN HAS NOT RECALLED!
NHTSA ODI #10956664
1 miles · Nov 28, 2016
Service Brakes
I HAVE A 2015 CHEVY. SUBURBAN LT THE BRAKE PEDAL IS HARD TO PRESS AND THE CAR CONTINUE TO ROLL EVEN AFTER I APPLY THE BRAKE DESPITE THE ROTOR AND ALL THE PADS HAVE BEEN REPLACED.....THIS IS VERY DANGEROUS.
NHTSA ODI #10928435
Official recalls
11May 7, 2026
General Motors, LLC (GM) is recalling certain 2026 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, and GMC Sierra 1500, Yukon, and Yukon XL vehicles with four-wheel (4WD) or all-wheel drive (AWD), and certain 2015-2020 Suburban, Escalade, Escalade ESV, Yukon, Yukon XL, and Tahoe vehicles. A component missing from the drivetrain transfer case may cause the front and/or rear wheels to lock up without warning to the driver.
Consequence & remedy
Consequence: Front or rear wheel lockup increases the risk of a crash.
Remedy: Owners are advised not to drive their vehicle until the remedy is completed. Dealers will inspect and, if necessary, replace the transfer case assembly, free of charge. Owner notification letters were mailed May 18, 2026. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-333-4223. GM's number for this recall is N262557620. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 7, 2026.
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Sep 7, 2018
General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.
Consequence & remedy
Consequence: If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began October 12, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is 18289.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Oct 9, 2015
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra trucks manufactured January 24, 2014, to February 26, 2014, 2015 Chevrolet Suburban vehicles manufactured February 12, 2014 and Chevrolet Tahoe vehicles manufactured February 6, 2014, to February 13, 2014. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.
Consequence & remedy
Consequence: If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.
Remedy: GM will notify owners, and dealers will replace the ignition lock housing, free of charge. The recall began on November 20, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 15573.
Nov 10, 2014
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado, Suburban, Tahoe, GMC Sierra, and Yukon XL vehicles, equipped with electric power steering (EPS). Due to a problem with the EPS module, the affected vehicles may experience a sudden loss of power steering assist during vehicle operation.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the power steering assist motor kit, free of charge. The recall began on November 17, 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14743.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Suburban, Suburban LTZ, Tahoe, Tahoe LTZ, GMC Yukon, and Yukon XL Denali vehicles manufactured on May 13, 2014. The affected vehicles were assembled with a roof rail air bags (RRAB) that were not reinforced at the points were the bags contact the hardware used to attach the roof carrier.
Consequence & remedy
Consequence: During deployment, the RRAB may be punctured or torn by the roof carrier hardware, reducing its performance and increasing the risk of occupant injury in the event of a crash.
Remedy: GM will notify owners, and dealers will replace the roof carrier attaching hardware, free of charge. The recall is expected to begin in early September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14359.
Jun 27, 2014
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra vehicles, and model year 2015 GMC Yukon and Chevrolet Suburban and Tahoe vehicles. In the affected vehicles, an electrical signal short may cause the transfer case to shift to neutral without the driver's input.
Consequence & remedy
Consequence: If the transfer case switches to neutral while the vehicle is parked and the parking brake is not in use, the vehicle may roll away increasing the risk of injury to bystanders. If the transfer case switches to neutral while the vehicle is being driven, the vehicle would lose drive power, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will re-program the software in the transfer case control module, free of charge. The recall began in early August 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14192.
Mar 31, 2014
General Motors LLC (GM ) is recalling certain model year 2014 Chevrolet Silverado Light Duty Regular Cab, Double Cab, and Crew Cab 1500 series and model year 2015 Suburban and Tahoe; GMC model year 2014 Sierra Regular Cab, Double Cab, and Crew Cab 1500 Series and model year 2015 Yukon and Yukon XL vehicles equipped with a 6-Speed Automatic Transmission (feature code MYC). The subject vehicles may have a transmission oil cooler line that is not securely seated in the fitting.
Consequence & remedy
Consequence: If the line is not securely seated and transmission oil leaks from the fitting, the oil could contact a hot surface and cause a vehicle fire.
Remedy: GM will notify owners, and dealers will inspect the transmission oil cooler line connection and repair the vehicles, as needed, free of charge. The recall began on May 19, 2014. Owners may contact Chevrolet at 1-866-694-6546 or GMC owners may contact GMC at 1-866-996-9463. GM's number for this recall is 14121.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration