IllustrationVEHICLE ONLY HAS 43,000 MILES, GARAGE KEPT AND THE DASHBOARD IS CRACKING AND I AM CONCERNED ABOUT MY SAFETY IF THE AIRBAGS GO OFF. JUST NOTICED THE CRACK AND IT IS GROWING. VEHICLE HAS NEVER BEEN IN AN ACCIDENT.
2013 Chevrolet Suburban
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2013 Chevrolet Suburban do not stand out strongly from the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1725–50K
2350–75K
1275–100K
12100–150K
4150K+
80 reports with mileage · 38 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports2 injury reports
What owners actually said
118 reportsCRACKING DASH AROUND AIR BAG LOCATION. WILL CAUSE PIECES OF PLASTIC TO EXPLODE IN THE AIR IF AIR BAG IS DEPLOYED.
WITHIN THE LAST TWO MONTHS, TWO CRACKS HAVE APPEARED IN THE DASH NEAR THE PASSENGER SIDE AIRBAG.
THE DASHBOARD HAS CRACKED IN MULTIPLE PLACES
TL* THE CONTACT OWNS A 2013 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE PASSENGER SIDE OF THE DASHBOARD FRACTURED. THE CONTACT WAS CONCERNED THAT THE FRONT PASSENGER SIDE AIR BAG WOULD DEPLOY VIOLENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPA…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE PASSENGER SIDE OF THE DASHBOARD FRACTURED. THE CONTACT WAS CONCERNED THAT THE FRONT PASSENGER SIDE AIR BAG WOULD DEPLOY VIOLENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 38,000.
VEHICLE DASH CRACHED WHILE DRIVING, MAKING QUITE A LOUD NOISE LIKE A POP. THEN THE DASH CRACKED ACROSS THE RIGHT SIDE. PREVIOUSLY OWNED 2008 SUBURBAN WITH A LOT MORE CRACKING THAN THIS ONE BUT THIS ONE JUST STARTED. THE 2008 SUBURBAN ACTUALLY BROKE INTO CHIPS AND WOULD BLOW ACROSS A PERSONS FACE WHILE DRIVING. I REPAIRED IT THRO…
Read full complaint
VEHICLE DASH CRACHED WHILE DRIVING, MAKING QUITE A LOUD NOISE LIKE A POP. THEN THE DASH CRACKED ACROSS THE RIGHT SIDE. PREVIOUSLY OWNED 2008 SUBURBAN WITH A LOT MORE CRACKING THAN THIS ONE BUT THIS ONE JUST STARTED. THE 2008 SUBURBAN ACTUALLY BROKE INTO CHIPS AND WOULD BLOW ACROSS A PERSONS FACE WHILE DRIVING. I REPAIRED IT THROUGH A PAINT AND BODY SHOP AT COST OF NEARLY $1,350.00 DOLLARS. THESE DASH PROBLEMS ARE IN MOST OF SUBURBANS AND TAHOES AND A VERY SERIOUS DANGER TO PEOPLE DRIVING THESE VEHICLES AND G.M. HAS NOT STEPPED UP AND RECALLED/REPAIRED THEM. WHEN SOMEONE GETS A SERIOUS INJURY OR LOSE AN EYE THEN MAYBE THEY WILL REPAIR THEM BUT THIS WILL NOT RETURN AN EYE, ARM, LEG OR LIFE DUE TO THIS NOT REPAIRING THEM.
DASHBOARD CRACK APPEARED AT AROUND 68,000 MILES. NO COLLISIONS OR ANY OTHER OBVIOUS CAUSE. I BELIEVE GM HAS NOT FIXED THIS ISSUE THAT HAS PLAGUED OTHER GM VEHICLES AND I BELIEVE GM KNOWS IT IS FAULTY BECAUSE THEY OFFERED TO FIX IT AT HALF PRICE. I FULLY EXPECT TO SEE MORE CRACKS SHOW UP AND I'M CONCERNED THAT AN AIRBAG DEPLOYMEN…
Read full complaint
DASHBOARD CRACK APPEARED AT AROUND 68,000 MILES. NO COLLISIONS OR ANY OTHER OBVIOUS CAUSE. I BELIEVE GM HAS NOT FIXED THIS ISSUE THAT HAS PLAGUED OTHER GM VEHICLES AND I BELIEVE GM KNOWS IT IS FAULTY BECAUSE THEY OFFERED TO FIX IT AT HALF PRICE. I FULLY EXPECT TO SEE MORE CRACKS SHOW UP AND I'M CONCERNED THAT AN AIRBAG DEPLOYMENT MAY CAUSE THE BRITTLE DASH TO EXOLODE.I REFUSED THE REPAIR BECAUSE THIS IS AN ONGOING PROBLEM AND THERE IS NO EVIDENCE GM REPAIRS FIX THE PROBLEM LONG TERM. THIS VEHICLE WAS CERTIFIED PRE OWNED BY A GM DEALER WHEN I PURCHASED IT.
MY VEHICLE IS LESS THAN THREE YEARS OLD FROM DATE OF PURCHASE (OCT 2013) AND CURRENT MILEAGE IS JUST SHY OF 58K. MY DASHBOARD AROUND THE AIRBAGS IS CRACKED ON THE PASSENGER SIDE. IT IS ALSO CRACKED JUST ABOVE THE DRIVER SIDE INSTRUMENT CLUSTER. MY VEHICLE WAS NOT MOVING, IT WAS PARKED IN MY DRIVEWAY. MY CONCERN IS IN THE EVE…
Read full complaint
MY VEHICLE IS LESS THAN THREE YEARS OLD FROM DATE OF PURCHASE (OCT 2013) AND CURRENT MILEAGE IS JUST SHY OF 58K. MY DASHBOARD AROUND THE AIRBAGS IS CRACKED ON THE PASSENGER SIDE. IT IS ALSO CRACKED JUST ABOVE THE DRIVER SIDE INSTRUMENT CLUSTER. MY VEHICLE WAS NOT MOVING, IT WAS PARKED IN MY DRIVEWAY. MY CONCERN IS IN THE EVENT OF A VEHICLE ACCIDENT SHOULD THE AIRBAGS DEPLOY THAT THE BROKEN DASHBOARD PIECES WILL BECOME PROJECTILES. UPON FURTHER RESEARCH VIA SOCIAL MEDIA AND VARIOUS NEWS SOURCES, I HAVE LEARNED THAT THIS IS AN ISSUE WITH GM PRODUCTS (AVALANCHE, ESCALADE, SIERRA, SILVERADO, SUBURBAN, TAHOE, YUKON) FROM 2007 TO 2014. THESE VEHICLES SHOULD BE RECALLED TO HAVE THE DASHBOARDS REPLACED WITH A MORE SUITABLE MATERIAL THAT WILL NOT CRACK IN LESS THAN THREE YEARS.
THIS IS THE THIRD SUBURBAN I HAVE OWNED IN THE LAST 7 YEARS. I HAVE OWNED A 2008, 2011 AND NOW A 2013. THEY HAVE ALL HAD THE SAME PROBLEM. THE DASH BOARD CRACKS AT THE LEFT TOP CORNER OF THE PASSENGER AIRBAG. I AM AFRAID THAT IF THE AIR BAG GOES OFF THE DASH MAY SEPARATE INTO PIECES BECOMING FLYING OBJECTS. IN MY CURRENT 2013…
Read full complaint
THIS IS THE THIRD SUBURBAN I HAVE OWNED IN THE LAST 7 YEARS. I HAVE OWNED A 2008, 2011 AND NOW A 2013. THEY HAVE ALL HAD THE SAME PROBLEM. THE DASH BOARD CRACKS AT THE LEFT TOP CORNER OF THE PASSENGER AIRBAG. I AM AFRAID THAT IF THE AIR BAG GOES OFF THE DASH MAY SEPARATE INTO PIECES BECOMING FLYING OBJECTS. IN MY CURRENT 2013 VEHICLE THE DASH HAS ALSO STARTED TO CRACK ON THE DASH PANEL ON THE DRIVERS SIDE.
DASHBOARD: LARGE CRACKS DEVELOPING ABOVE INSTRUMENT CLUSTER AND AT THE RIGHT SIDE DASHBOARD AIRBAG LOCATION.
Official recalls
421V053000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.
21V054000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.
14V614000 · Electrical System
Oct 1, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.
Consequence & remedy
Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GMs number for this recall is 14515.
13V001000 · Power Train:automatic Transmission; Steering:column LOCKING:ANTI-THEFT Device
Jan 2, 2013
General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.
Consequence & remedy
Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.
Additional source detail variants (2)
Power Train:automatic Transmission
General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.
Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.
Steering:column LOCKING:ANTI-THEFT Device
General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.
Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.