Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
THE BRAKES HAVE ALWAYS BEEN MUSHY. I UNDERSTSAND THAT ABS WILL RESPOND DIFFERENTLY TO EMERGENCY BRAKEING THAN "NORMAL" BRAKES BUT THIS THING IS A REAL ADVENTURE TO DRIVE WHEN YOU'VE GOT TO MAKE PANIC STOPS.IT SEEMS TO RESIST YOUR FOOT THE HARDER YOU PUSH THE LESS BRAKING YOU FEEL.THE FRONT LEFT WHEEL BEARING MODULE WENT OUT WHIC…
Read full complaint
THE BRAKES HAVE ALWAYS BEEN MUSHY. I UNDERSTSAND THAT ABS WILL RESPOND DIFFERENTLY TO EMERGENCY BRAKEING THAN "NORMAL" BRAKES BUT THIS THING IS A REAL ADVENTURE TO DRIVE WHEN YOU'VE GOT TO MAKE PANIC STOPS.IT SEEMS TO RESIST YOUR FOOT THE HARDER YOU PUSH THE LESS BRAKING YOU FEEL.THE FRONT LEFT WHEEL BEARING MODULE WENT OUT WHICH CAUSED THE DISK BRAKE TO GRAB AND BOTH FRONT TIRES TO WEAR VERY BADLY. THE ELECTRIC WIPER CONTROL WENT OUT BECAUSET THE CONTROL BOX IS IN THE ENGINE COMPARTMENT AND GOT WET. DAH! THE DRAG LINK BUSHING RUSTED OUT BECAUSE THE GREASE FITTING WAS APPARENTLY INACCESSABLE TO SERVICE AND NEVER GOT ANY GREASE. THE RADIATOR BEGAN LEAKING AT 90000 MLS. AT WHICH TIME I RAN A STOP LEAK PRODUCT IN IT WHICH STOPPED IT SO FAR. THE WATERPUMP WENT OUT AT 110,000 MLS AND THE ALTERNATOR AT 95000 MLS. BRAKES ARE BIGGEST CONCERN!!!!!
NHTSA ODI #712669
Mileage unknown · May 4, 1998
Engine And Engine Cooling
FIVE RADIATORS WERE REPLACED IN 6 YEARS.
NHTSA ODI #535178
Mileage unknown · Feb 18, 1998
Engine And Engine CoolingService Brakes, Hydraulic
ANTI LOCK BRAKES LOCK UP.
NHTSA ODI #530665
Mileage unknown · Sep 17, 1997
Engine And Engine Cooling
ENGINE CYLINDER HEAD LEAKED COOLANT OUTSIDE ENGINE. ALSO, RADIATOR LEAKS DUE TO POOR ORIGINAL CONSTRUCTION BY GENERAL MOTORS. *AK
NHTSA ODI #520311
Mileage unknown · May 16, 1997
Engine And Engine Cooling
ENGINE RUNS ROUGHC/PERFORMS SLUGGISHLY.
NHTSA ODI #517254
Mileage unknown · Sep 4, 1996
Engine And Engine CoolingFire
VEHICLE FIRE.
NHTSA ODI #508286
Mileage unknown · Mar 22, 1995
Electrical SystemEngine And Engine CoolingPower Train
ENGINE IS RATTLING, EXCESSIVE NOISE, REPLACED ENGINE THREE TIMES. TT
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence & remedy
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
THE PIVOT BOLT HOLDING THE BRAKE PEDAL TO ITS SUPPORT BRACKET MAY BE IMPROPERLY TIGHTENED AND MAY NOT HAVE ENGAGED THE LOCKING MATERIAL ON THE BOLT. THE BOLT CAN DISENGAGE FROM THE NUT.
Consequence & remedy
Consequence: IF THE PIVOT BOLT DISENGAGES FROM THE NUT WHILE THEVEHICLE IS IN MOTION, THERE WILL BE A LOSS OF BRAKE CONTROL AND COULD RESULT INA VEHICLE ACCIDENT.
Remedy: DEALERS SHOULD INSPECT THE HAND STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO SPECIFICATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA95026 · Poor Brake Performance
Opened Sep 20, 1995 · Closed Sep 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
POOR PERFORMANCE OF ABS BRAKES
EA94029 · Engine Compartment Fires
Opened Jul 29, 1994 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.
1992 Chevrolet Suburban Problems, Complaints & Recalls | Skip That Year
Illustration