Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 62 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Seats. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Tires. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seat Belts. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports5 fire reports8 injury reports
What owners actually said
62 reports
Mileage unknown · Sep 29, 2000
Tires
PE 00 020/TIRE TREAD SEPARATION: RIGHT REAR EXPERIENCED TREAD SEPARATION ON A 1989 CHEVROLET, SUBURBAN WHILE TRAVELING AT 65 MPH WITH DRIVER AND SEVEN PASSENGERS. AFTER MARKET EQUIPMENT INSTALLED AT 134,944 MILES, TIRE SIZE 31X10.50/R15, DOT# VD60AW3258. VEHICLE RECEIVED REAR END BODY DAMAGE, AND TIRE WAS AVAILABLE FOR ANAYLSI…
Read full complaint
PE 00 020/TIRE TREAD SEPARATION: RIGHT REAR EXPERIENCED TREAD SEPARATION ON A 1989 CHEVROLET, SUBURBAN WHILE TRAVELING AT 65 MPH WITH DRIVER AND SEVEN PASSENGERS. AFTER MARKET EQUIPMENT INSTALLED AT 134,944 MILES, TIRE SIZE 31X10.50/R15, DOT# VD60AW3258. VEHICLE RECEIVED REAR END BODY DAMAGE, AND TIRE WAS AVAILABLE FOR ANAYLSIS. *AK *SLC
NHTSA ODI #871816
Mileage unknown · Sep 19, 2000
Tires
COMPLETE TREAD LOSS, NO FLAT, ABLE TO CONTINUE DRIVE HOME ON STEEL BELTS( DOT NUMBER: TIRE SIZE: 235/15R75 )
NHTSA ODI #731932
Mileage unknown · Aug 29, 2000
SeatsInjury
SECOND FALIURE OF REPAIRED DRIVERS SEATBACK. DRIVERS SIDE (LEFT) RECLINER BOLT BROKE CAUSING DRIVER TO STIKE HEAD ON DOOR PILLAR AS HE WAS THROWN REARWARD DURING ACCELERATION ONTO FREEWAY. DRIVER WAS ABLE TO BRING VEHICLE TO A STOP WITH FURTHER INCIDENT. THIS SEAT WAS REPAIRED BY HUFFINES CHEVROLET IN LEWISVILLE TX FOR A SIMILAR…
Read full complaint
SECOND FALIURE OF REPAIRED DRIVERS SEATBACK. DRIVERS SIDE (LEFT) RECLINER BOLT BROKE CAUSING DRIVER TO STIKE HEAD ON DOOR PILLAR AS HE WAS THROWN REARWARD DURING ACCELERATION ONTO FREEWAY. DRIVER WAS ABLE TO BRING VEHICLE TO A STOP WITH FURTHER INCIDENT. THIS SEAT WAS REPAIRED BY HUFFINES CHEVROLET IN LEWISVILLE TX FOR A SIMILAR INCIDENT IN 1999 WHEN THE SEAT BACK COLLAPSED THROWING THE DRIVER ONTO THE REAR SEAT.
NHTSA ODI #729410
Mileage unknown · Aug 5, 2000
Seat Belts
I HAVE HAD ONE SEAT BELT RESTRAINT LOCKING SYSTEM REPLACED IN THE PAST. I WENT THROUGH THE VEHICLE TODAY AND I HAVE THREE THAT DO NOT LOCK AT HARD BREAKING. HARD TO BELIEVE THAT SUCH AN IMPORTANT SAFETY FEATURE WOULD FAIL WITHIN THE LIFE OF THE VEHICLE. *AK
NHTSA ODI #726754
Mileage unknown · Jul 28, 2000
SeatsInjury
THE FRONT DRIVER SEAT WAS SUBJECT TO A RECALL IN THE EARLY TO MID '90'S FOR FAILURE OF A BOLT WHICH WOULD CAUSE THE SEAT BACK TO COLLAPSE. WHEN I RECEIVED NOTICE OF THIS RECALL, I PROMPTLY HAD THE WORK DONE. BUT WHEN I LEFT THE DEALERSHIP, I FELT UNEASY BECAUSE I REALLY DIDN'T THINK THEY DID THE WORK. ABOUT A YEAR TO TWO YEARS A…
Read full complaint
THE FRONT DRIVER SEAT WAS SUBJECT TO A RECALL IN THE EARLY TO MID '90'S FOR FAILURE OF A BOLT WHICH WOULD CAUSE THE SEAT BACK TO COLLAPSE. WHEN I RECEIVED NOTICE OF THIS RECALL, I PROMPTLY HAD THE WORK DONE. BUT WHEN I LEFT THE DEALERSHIP, I FELT UNEASY BECAUSE I REALLY DIDN'T THINK THEY DID THE WORK. ABOUT A YEAR TO TWO YEARS AFTER THE BOLT WAS "REPLACED" THE SEAT COLLAPSED ON ME. I TOOK IT BACK TO THE DEALER AND THEY FIXED IT IMMEDIATELY. IN HINDSIGHT, I WAS UPSET I DIDN'T KEEP THE BOLT THAT BROKE TO DETERMINE BY TESTING IF IT HAD INDEED BEEN REPLACED AT THE TIME OF THE RECALL. ANYWAY, YESTERDAY, JULY 27, 2000, I WAS DRIVING ALONE AT 40 MPH WHEN THE BOLT AGAIN BROKE, CAUSING THE SEAT TO COLLAPSE AND ME TO FALL BACKWARDS, LOSING CONTROL OF THE VEHICLE. I WAS JUST LUCKY IT WAS A WIDE ROAD AND THERE WAS NOBODY NEAR ME WHEN THIS HAPPENED. I FOUND THE BOLT THAT SNAPPED AND WOULD LIKE TO HAVE IT TESTED. *AK
NHTSA ODI #726152
Mileage unknown · Feb 22, 2000
SteeringStructure
FRAME SECTION LOCATED NEAR STEERING GEAR BOX, IS CRACKED/ STEERING GEAR BOX IS LEAKING FLUID AND PULLEY ON POWER STEERING PUMP IS SHREDDING. STEERING GEAR BOX HAS BEEN REPLACED. T VEHICLE IS NOT CONTROLLABLE IF FLUID LEAKS OUT TOO FAST. *AK
NHTSA ODI #857355
Mileage unknown · Feb 8, 2000
Seats
FRONT PASSENGER'S SEAT ANCHOR ATTACHMENT BOLTS BROKE ,CAUSING THE SEAT TO FALL BACKWARDS. DEALER HAS BEEN CONTACTED. *AK
NHTSA ODI #856480
Mileage unknown · Feb 4, 2000
Engine And Engine Cooling
EXHAUST MANIFOLD HAS BEEN REPLACED FOUR TIMES FROM 1997 TO THE PRESENT ONCE IN 1997, ONCE IN 1998, & TWICE IN 199. ALL PARTS ARE GMC. DEALER NOTIFIED. *AK *ML
NHTSA ODI #856318
Mileage unknown · Dec 20, 1999
SeatsCrashInjury
THIS VEHICLE WAS IN A CHAIN REACTION REAR END COLLISION WHEN STRUCK IN THE REAR, DRIVER'S SEAT BACK BOLTS BROKE, CAUSINGTHE SEAT TO COLLAPSE. DEALER HAS BEEN CONTACTED. *AK CONSUMER WAS INJURED IN THE ACCIDENT, INJURIES TO BACK, NECK, LEFT KNEE, AND HIP. *SLC
NHTSA ODI #854146
Mileage unknown · Dec 15, 1999
Seats
RECALL COMPONENT REPAIR COMPLETED THEN FAILED AGAIN. (93V-187) *NLM
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence & remedy
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence & remedy
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Illustration