NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
55 reportsClear category filterMileage unknown · Jun 10, 2025
Engine
Vehicle enters into catalyst monitor too early. Monitor Fales indicating that the catalyst is below efficiency threshold. A vehicle is run for a significant amount of time before being allowed to enter the driving conditions for the catalyst monitor, monitor will pass. This indicates that there is a programming failure, not an a…
Read full complaint
Vehicle enters into catalyst monitor too early. Monitor Fales indicating that the catalyst is below efficiency threshold. A vehicle is run for a significant amount of time before being allowed to enter the driving conditions for the catalyst monitor, monitor will pass. This indicates that there is a programming failure, not an actual component failure. Theory has been tested multiple times. Catalyst had also been tested by temperature sensor as well as by taking readings with a gas analyzer before and after the catalyst. Everything indicates the catalyst is well within operating parameters. Theories, test, and confirmations have been conducted by a certified technician and mechanical engineer.
NHTSA ODI #11666137
Mileage unknown · Jul 22, 2024
Electrical SystemEngineFuel/propulsion System
Was driving in heavy rain when car suddenly cut power and decelerated showed code 84 and the CEL came back with P2138. It is a known issue that rain gets up into the connector and causes a malfunction.
NHTSA ODI #11603878
Mileage unknown · Apr 24, 2024
EngineEngine And Engine Cooling
The contact owns a 2013 Chevrolet Sonic. The contact stated that there was fluid leaking from underneath the hood. The check engine warning light was illuminated. The contact stated that while driving at undisclosed speeds, there was an abnormal sound coming from the vehicle. The vehicle was taken to the independent mechanic whe…
Read full complaint
The contact owns a 2013 Chevrolet Sonic. The contact stated that there was fluid leaking from underneath the hood. The check engine warning light was illuminated. The contact stated that while driving at undisclosed speeds, there was an abnormal sound coming from the vehicle. The vehicle was taken to the independent mechanic where it was diagnosed with a water pump and the thermostat housing failure. The contact discovered Technical Service Bulletin: 14371B; however, the vehicle was not included. The manufacturer was made aware of the failure and a case was opened. The failure mileage was unknown.
NHTSA ODI #11585004
Mileage unknown · Oct 9, 2023
EngineFuel/propulsion SystemPower Train
2013 Chevrolet Sonic 1.8 L , fuel system lean ,mass airflow sensor, in limp mode preventing acceleration, gas tank when added gas....shuts down after start up-fuel system/gasoline; may cause possible fuel leak and could combust, alarm system and locks don't properly function - electric system equipment, insufficient welds...aro…
Read full complaint
2013 Chevrolet Sonic 1.8 L , fuel system lean ,mass airflow sensor, in limp mode preventing acceleration, gas tank when added gas....shuts down after start up-fuel system/gasoline; may cause possible fuel leak and could combust, alarm system and locks don't properly function - electric system equipment, insufficient welds...around fuel tank and front of vehicle on bottom by driver's side could also cause combustion, bcm codes that came up were communication, electrical, fuel, windows, and airbags! AutoZone codes were po171 and co561-77,I looked up recalls , several came up for my make and model but weren't specific to my vin# however my vehicle is doing everything pertaining to them! And I looked up if there was any special coverage on it and said there is...before 120k miles or ten years time. And I was never notified of it & never received anything in the mail ...
NHTSA ODI #11549029
150,000 miles · Sep 29, 2022
EngineWheels
The contact owns a 2013 Chevrolet Sonic. The contact stated while driving 35 MPH, she heard abnormal knocking sounds coming from the rear wheels of the vehicle. Additionally, the contact stated that she heard clicking sounds while making turns. The check engine warning light was illuminated. The contact drove to her residence an…
Read full complaint
The contact owns a 2013 Chevrolet Sonic. The contact stated while driving 35 MPH, she heard abnormal knocking sounds coming from the rear wheels of the vehicle. Additionally, the contact stated that she heard clicking sounds while making turns. The check engine warning light was illuminated. The contact drove to her residence and parked the vehicle. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 150,000.
NHTSA ODI #11487116
Mileage unknown · Jun 16, 2022
Engine
Multiple parts in my engine have malfunctioned in the past year, the most recent being a tube bursting and getting coolant everywhere. Other problems have been with valves, temperature gauges and even the radiator. It’s like something new breaks every month. I have had every issue fixed and usually I don’t get a warning lamp unt…
Read full complaint
Multiple parts in my engine have malfunctioned in the past year, the most recent being a tube bursting and getting coolant everywhere. Other problems have been with valves, temperature gauges and even the radiator. It’s like something new breaks every month. I have had every issue fixed and usually I don’t get a warning lamp until I’m broken down on the side of the road.
NHTSA ODI #11469507
Mileage unknown · May 8, 2022
Engine
Boniface hiers Chevrolet dealer in Melbourne Florida said they did a full inspection before selling this vehicle. 2 days later after purchase the Radiator fan stop working even tho they put a new one, missing thermostat, code 3rd gear malfunction.
NHTSA ODI #11463776
80,000 miles · Dec 20, 2020
EngineFuel/propulsion SystemPower Train
MY 2013 CHEVY SONIC DEVELOPED TICKING SOUND SHORTLY AFTER I BOUGHT IT AT 60000 MILES. THE TICKING GOT WORSE OVER TIME AND THEN CHECK ENGINE LIGHT CAME ON. I SCANNED THE CODES AND MULTIPLE FOUR CODES WERE FOUND. P0171, P0496, P1101, AND P2270. AFTER DOING SOME RESEARCH IT SEEMED TO BE THAT MOST CRUZE, SONIC, AND TRAX VEHICLES ALL…
Read full complaint
MY 2013 CHEVY SONIC DEVELOPED TICKING SOUND SHORTLY AFTER I BOUGHT IT AT 60000 MILES. THE TICKING GOT WORSE OVER TIME AND THEN CHECK ENGINE LIGHT CAME ON. I SCANNED THE CODES AND MULTIPLE FOUR CODES WERE FOUND. P0171, P0496, P1101, AND P2270. AFTER DOING SOME RESEARCH IT SEEMED TO BE THAT MOST CRUZE, SONIC, AND TRAX VEHICLES ALL HAD THE SAME ISSUES. I TOOK IT TO THE DEALER FOR DIAGNOSTICS AND WAS INFORMED THE VEHICLE NEEDED A NEW INTAKE MANIFOLD, PURGE VALVE, PCV HOSE, AND VALVE COVER. THEY CALLED THE DEALERSHIP TO SEE IF THERE WERE ANY RECALLS AND THE ONLY ONE WAS THE VALVE COVER BUT WOULD HAVE TO PAY FOR DIAGNOSTICS TO SEE IF THEY WOULD COVER IT OR NOT. THE BREATHER DIAPHRAGM IN THE VALVE COVER GOES BAD DUE TO A FAULT INTAKE MANIFOLD ON THESE VEHICLE MODELS. THERE IS A LITTLE ORANGE GASKET IN THE MANIFOLD THAT GOES BAD AND CAUSES THE DIAPHRAGM TO GO OUT RESULTING IN HAVING TO REPLACE THE ENTIRE SYSTEM. THE INTAKE MANIFOLD NOT ONLY CAUSES GHAT ISSUE BUT CAUSES THE CAR TO GET JUMPY AT STOPS AND STALLING OUT. HAVE ALMOST HAD A FEW PEOPLE REAR END ME DUE TO THIS. THE PURGE VALVE GOES OUT AS WELL AND WHEN AT THE FUEL PUMP THE CAR WILL HESITATE TO CRANK OR RUN AT VERY LOW IDLE SHUTTING OFF MULTIPLE TIMES BEFORE IT STARTS UP AND THEN RUNS ROUGH UNTIL A DECENT AMOUNT OF FUEL HAS RAN THROUGH THE ENGINE. THE CAR WOULD NOT GET ENOUGH FUEL WHEN AT STOPS OR ON HIGHWAYS AND WOULD ALSO JUST LOSE FUEL AND CUT THE ENGINE OFF. THOSE COMPONENTS HAVE SINCE BEEN REPLACED BY MYSELF AND NO MORE ISSUES. CHEVY WILL NOT RECALL THE PARTS THAT ARE CAUSING THE ISSUES AND THEREFORE THERE IS A SAFETY ISSUE WHEN OUT ON THE HIGHWAYS.
NHTSA ODI #11384224
Mileage unknown · Dec 5, 2020
EngineFuel/propulsion SystemPower Train
THE FUEL SYSTEM IS RUNNING WEAK, FOR A CAR WITH ONLY 30000 MILES, ONE OWNER AND FULL MAINTENANCE, THE ENGINE LIGHT CAME AND GO ALL THE TIME AND EVERYTHING WAS CHECKING
NHTSA ODI #11377989
125,961 miles · Dec 1, 2020
Engine
THE PCV PRESSURE REG VALVE FAILS AND CAUSES DAMAGE TO THE ENGINE. GM SENT A LETTER TO CUSTOMERS BUT ONLY COVERS THE WORK UP TO 120K MILES. MINE FAILED AT 125K MILES AND COST OVER $1000 TO FIX. GM IS REFUSING TO PAY FOR THE REPAIRS.10/15/2020
NHTSA ODI #11377375
Official recalls
6Jul 27, 2023
General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1-800-521-7300 and Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232413120.
Apr 28, 2016
General Motors LLC (GM) is recalling certain model year 2013-2016 Chevrolet Sonic and Trax vehicles and 2013-2015 Chevrolet Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver, after turning off the ignition and leaving the key in the cylinder, waits 10 minutes or longer to open the door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114 "Theft Protection."
Consequence & remedy
Consequence: Without audible indicators, the driver may leave the key in the ignition, increasing the risk of theft.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17130.
Additional source detail variants (2)
Electrical System:software
General Motors LLC (GM) is recalling certain model year 2013-2016 Chevrolet Sonic and Trax vehicles and 2013-2015 Chevrolet Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver, after turning off the ignition and leaving the key in the cylinder, waits 10 minutes or longer to open the door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114 "Theft Protection."
Consequence: Without audible indicators, the driver may leave the key in the ignition, increasing the risk of theft.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17130.
Equipment:electrical:radio/tape Deck/cd Etc.
General Motors LLC (GM) is recalling certain model year 2013-2016 Chevrolet Sonic and Trax vehicles and 2013-2015 Chevrolet Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver, after turning off the ignition and leaving the key in the cylinder, waits 10 minutes or longer to open the door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114 "Theft Protection."
Consequence: Without audible indicators, the driver may leave the key in the ignition, increasing the risk of theft.
Remedy: GM will notify owners, and dealers will update the radio software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17130.
Jul 2, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Buick Encore all-wheel-drive vehicles manufactured August 23, 2012, to September 9, 2013; Verano vehicles manufactured August 8, 2012, to June 20, 2013; Chevrolet Cruze vehicles manufactured August 7, 2012, to August 16, 2013, and 2012-2014 Chevrolet Sonic vehicles manufactured May 10, 2011, to August 16, 2012 equipped with a Calix oil pan/block heater. In cold temperatures, the insulation on the engine block heater cord can become damaged, allowing the wires to be exposed.
Consequence & remedy
Consequence: Exposed wires increase the risk of electrical shock and personal injury if the cord is handled while it is plugged in.
Remedy: GM will notify owners, and dealers will replace the engine oil pan/block heater cord with a new cord that is rated for temperatures of minus 40 degree Celsius. The recall began in August 2014. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14257.
Sep 26, 2013
General Motors (GM) is recalling certain model year 2013 and 2014 Chevrolet Sonic vehicles manufactured August 2, 2013, through August 12, 2013. Due to insufficient welds, the front fuel tank strap bracket may separate from the vehicle.
Consequence & remedy
Consequence: If the front fuel tank strap bracket separates, the increased load may lead to the failure of the other tank support. As a result, the fuel tank may come loose from the vehicle causing a fuel leak. A fuel leak, in the presence of an ignition source, may result in a fire.
Remedy: GM will notify owners, and dealers will inspect the front fuel tank strap bracket, and repair it as necessary, free of charge. The recall began on November 7, 2013. Owners may contact GM at 1-800-521-7300. GM's recall campaign number is 13296.
May 24, 2013
General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.
Additional source detail variants (2)
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."
Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.
Electrical System
General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."
Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.
Sep 17, 2012
General Motors LLC (GM) is recalling certain model year 2013 Chevrolet Sonic vehicles manufactured from May 29, 2012, through August 29, 2012. When a turn signal lamp fails to operate, the Body Control Module (BCM) in these vehicles does not detect this condition and will not indicate the condition to the driver. Thus, These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the driver is not aware that the turn signal is not functioning and does not have the light repaired, other drivers may not be alerted that the vehicle is turning, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the BCM and the vehicle's key fobs, free of charge. The safety recall began on October 3, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.
Additional source detail variants (2)
Exterior Lighting:turn Signal
General Motors LLC (GM) is recalling certain model year 2013 Chevrolet Sonic vehicles manufactured from May 29, 2012, through August 29, 2012. When a turn signal lamp fails to operate, the Body Control Module (BCM) in these vehicles does not detect this condition and will not indicate the condition to the driver. Thus, These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the driver is not aware that the turn signal is not functioning and does not have the light repaired, other drivers may not be alerted that the vehicle is turning, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the BCM and the vehicle's key fobs, free of charge. The safety recall began on October 3, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.
Electrical System
General Motors LLC (GM) is recalling certain model year 2013 Chevrolet Sonic vehicles manufactured from May 29, 2012, through August 29, 2012. When a turn signal lamp fails to operate, the Body Control Module (BCM) in these vehicles does not detect this condition and will not indicate the condition to the driver. Thus, These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the driver is not aware that the turn signal is not functioning and does not have the light repaired, other drivers may not be alerted that the vehicle is turning, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the BCM and the vehicle's key fobs, free of charge. The safety recall began on October 3, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.