IllustrationTL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE GEAR POSITION INDICATOR LIGHTING FAILED TO ILLUMINATE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.
2005 Chevrolet Silverado 3500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chevrolet Silverado 3500 do not stand out strongly from the model-year median of 35.
Counts are not adjusted for sales, age, mileage exposure or reporting. A lower count does not establish that a car is problem-free.
About this comparison →46Owner complaints
Model-year median: 35
0Recall campaignsView recall details →
0InvestigationsView investigation details →
Check a VIN with NHTSA ↗ Model-level counts do not show whether a particular VIN is affected or repaired.
Inspection summary
2005 Chevrolet Silverado 3500
NHTSA snapshot: September 18, 2026. 46 owner complaints · 0 recall campaigns · 0 investigations.
Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
Top reported categories (up to 5)
- Electrical System: 9 reports
- Service Brakes, Hydraulic: 9 reports
- Service Brakes: 8 reports
- Steering: 6 reports
- Fuel System, Diesel: 5 reports
Full reported-category list and vehicle report
Recall links
No recall campaigns in this snapshot.
Check a VIN with NHTSA. Model-level history does not establish whether a particular VIN is affected or repaired.
Print the top reported categories, recall links, snapshot date and comparison limits.
How this year compares
Owner complaints by model year
Compare all Silverado 3500 years →Counts vary with age, sales, mileage exposure and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
1125–50K
850–75K
875–100K
6100–150K
2150K+
44 reports with mileage · 2 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
Power Train complaints
4 reportsTL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT OIL WAS LEAKING FROM THE REAR HALF OF TRANSFER CASE HOUSING. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC FOR INSPECTION AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT OIL WAS LEAKING FROM THE REAR HALF OF TRANSFER CASE HOUSING. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC FOR INSPECTION AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 78,637.
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE VEHICLE HAS BEEN TO THE DEALER FIFTEEN TIMES FOR A VARIETY OF FAILURES. THERE WERE DEFECTIVE FUEL INJECTORS AND FUEL PUMPS, THE R& R INTERMEDIATE STEERING SHAFT WAS REPLACED, AND THERE WAS AN OCCASIONAL TRANSMISSION LEAK. THE DEALER COULD NOT DUP…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE VEHICLE HAS BEEN TO THE DEALER FIFTEEN TIMES FOR A VARIETY OF FAILURES. THERE WERE DEFECTIVE FUEL INJECTORS AND FUEL PUMPS, THE R& R INTERMEDIATE STEERING SHAFT WAS REPLACED, AND THERE WAS AN OCCASIONAL TRANSMISSION LEAK. THE DEALER COULD NOT DUPLICATE THE LEAK. THE CONTACT ORDERED A SPARE TIRE, BUT IT WAS NEVER RECEIVED. HE CONSULTED THE MANUFACTURER, WHO ONLY INFORMED HIM THAT THERE WERE NO RECALLS OR ISSUES WITH HIS VEHICLE. THE CONTACT ALSO SPOKE WITH THE STATE ATTORNEY GENERAL. THE CURRENT MILEAGE WAS 22,000 AND FAILURE MILEAGE WAS APPROXIMATELY 500.
I BELIEVE MY 2005 CHEVROLET SILVERADO 3500, DURAMAX/ALLISON WAS EQUIPED WITH UNDER DESIGNED COOLING SYSTEMS; BOTH TRANSMISSION AND ENGINE. ON SLOW MOUNTAIN TYPE ROADS I CAN RUN MY UNLOADED TRUCK INTO NEAR OVERHEAT CONDITIONS. I BELIEVE THESE ISSUES MAY BE COMMON TO OTHER '04.5 AND '05 LLY GM AND CHEVROLET TRUCKS LIKE MINE AND …
Read full complaint
I BELIEVE MY 2005 CHEVROLET SILVERADO 3500, DURAMAX/ALLISON WAS EQUIPED WITH UNDER DESIGNED COOLING SYSTEMS; BOTH TRANSMISSION AND ENGINE. ON SLOW MOUNTAIN TYPE ROADS I CAN RUN MY UNLOADED TRUCK INTO NEAR OVERHEAT CONDITIONS. I BELIEVE THESE ISSUES MAY BE COMMON TO OTHER '04.5 AND '05 LLY GM AND CHEVROLET TRUCKS LIKE MINE AND GM HAS NOT PROVIDED IT'S DEALER NETWORK WITH SOLUTIONS TO REMEDY THE PROBLEM (MOST OF THEM ARE SIMPLE, THAT THE OTHER 2 MAJORS SEEM TO UNDERSTAND: AIR FLOW CONTROL THROUGHT THE COOLING STACK AND COLD AIR TO THE INTAKE)
Recall campaigns
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
0No exact-year investigations in this snapshot.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.