IllustrationPREMATURE FUEL LINE FAILURE DUE TO EXCESSIVE CORROSION CAUSING SPILLAGE OF FUEL AND RISK OF FIRE. ALL UNDERBODY FUEL LINES EXCESSIVELY CORRODED AND DEVELOPED LEAKS WITH FUEL SPILLING ON HOT EXHAUST SYSTEM PARTS. *TR
2005 Chevrolet Silverado 3500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chevrolet Silverado 3500 do not stand out strongly from the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 3500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
1125–50K
850–75K
875–100K
6100–150K
2150K+
44 reports with mileage · 2 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
Fuel System, Diesel complaints
5 reportsTL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD ABNORMALLY DECREASE IN SPEED WITHOUT WARRANT AND SPORADICALLY STALL. THE FAILURE WOULD OCCUR DESPITE THE CONTACTS ATTEMPTS TO DEPRESS THE ACCELERATOR PEDAL. THE DEALER REPLACED A PORTION OF THE FUEL LIN…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD ABNORMALLY DECREASE IN SPEED WITHOUT WARRANT AND SPORADICALLY STALL. THE FAILURE WOULD OCCUR DESPITE THE CONTACTS ATTEMPTS TO DEPRESS THE ACCELERATOR PEDAL. THE DEALER REPLACED A PORTION OF THE FUEL LINE WITH A HYDRAULIC HOSE YET THE FAILURE RECURRED. THE CONTACT STATED THE FUEL LINES WERE COLLAPSING AND HE WAS HESITANT TO DRIVE THE VEHICLE DUE TO THE INTERMITTENT STALLING WITHOUT WARNING. THERE WERE NO FURTHER REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 58,000 AND THE CURRENT MILEAGE WAS 59,000.
ENGINE MISFIRES AND IS DOWNGRADED TO 25 MPH ON HIGHWAY. ENGINE KNOCKS AND RATTLES. PROBLEM IS A KNOWN FAILURE ON A GOOD SHARE OF 2004.5 THROUGH 2005 DURAMAX DIESEL TRUCKS WHERE #2 AND #7 FUEL INJECTOR HARNESS FAILS. MFG KNOW THIS IS A PROBLEM AND WILL NOT FIX THE TRUCK UNTIL THE PROBLEM HAS SURFACED. THIS PROBLEM COULD RESULT IN…
Read full complaint
ENGINE MISFIRES AND IS DOWNGRADED TO 25 MPH ON HIGHWAY. ENGINE KNOCKS AND RATTLES. PROBLEM IS A KNOWN FAILURE ON A GOOD SHARE OF 2004.5 THROUGH 2005 DURAMAX DIESEL TRUCKS WHERE #2 AND #7 FUEL INJECTOR HARNESS FAILS. MFG KNOW THIS IS A PROBLEM AND WILL NOT FIX THE TRUCK UNTIL THE PROBLEM HAS SURFACED. THIS PROBLEM COULD RESULT IN REAR END COLLISION ON HIGHWAY. THEY DO NOT HONOR THE WARRANTY WHICH STATES 5YRS.,100,000 MILES. COST $504 MY COST. I HAVE A COMPLAINT LODGED WITH THE BETTER BUSINESS BUREAU OF CT. FUEL INJECTOR WIRING HARNESSSVC BULLETIN 05-06-04-047C. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE VEHICLE HAS BEEN TO THE DEALER FIFTEEN TIMES FOR A VARIETY OF FAILURES. THERE WERE DEFECTIVE FUEL INJECTORS AND FUEL PUMPS, THE R& R INTERMEDIATE STEERING SHAFT WAS REPLACED, AND THERE WAS AN OCCASIONAL TRANSMISSION LEAK. THE DEALER COULD NOT DUP…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE VEHICLE HAS BEEN TO THE DEALER FIFTEEN TIMES FOR A VARIETY OF FAILURES. THERE WERE DEFECTIVE FUEL INJECTORS AND FUEL PUMPS, THE R& R INTERMEDIATE STEERING SHAFT WAS REPLACED, AND THERE WAS AN OCCASIONAL TRANSMISSION LEAK. THE DEALER COULD NOT DUPLICATE THE LEAK. THE CONTACT ORDERED A SPARE TIRE, BUT IT WAS NEVER RECEIVED. HE CONSULTED THE MANUFACTURER, WHO ONLY INFORMED HIM THAT THERE WERE NO RECALLS OR ISSUES WITH HIS VEHICLE. THE CONTACT ALSO SPOKE WITH THE STATE ATTORNEY GENERAL. THE CURRENT MILEAGE WAS 22,000 AND FAILURE MILEAGE WAS APPROXIMATELY 500.
ENGINE MISFIRES AND IS DERATED TO 25 MPH ON HIGHWAY. ENGINE KNOCKS AND RATTLES. PROBLEM IS A KNOWN FAILURE ON A GOOD SHARE OF 2004.5 THROUGH 2005 DURAMAX DIESEL TRUCKS WHERE #2 AND #7 FUEL INJECTOR HARNESS FAILS. MFG KNOW THIS IS A PROBLEM AND WILL NOT FIX THE TRUCK UNTIL THE PROBLEM HAS SURFACED. THIS PROBLEM COULD RESULT I…
Read full complaint
ENGINE MISFIRES AND IS DERATED TO 25 MPH ON HIGHWAY. ENGINE KNOCKS AND RATTLES. PROBLEM IS A KNOWN FAILURE ON A GOOD SHARE OF 2004.5 THROUGH 2005 DURAMAX DIESEL TRUCKS WHERE #2 AND #7 FUEL INJECTOR HARNESS FAILS. MFG KNOW THIS IS A PROBLEM AND WILL NOT FIX THE TRUCK UNTIL THE PROBLEM HAS SURFACED. THIS PROBLEM COULD RESULT IN REAR END COLLISION ON HIGHWAY. *NM
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.