IllustrationWHEN THE WAS IN REVERSE ON AN INCLINE, THE FRONT TIRES LOCKED UP AND THE BACK TIRES FAILED TO FUNCTION, WHICH MADE IT DIFFICULT TO STEER. *JB THE BRAKES ONLY LASTED ABOUT 7-8 THOUSAND MILES. THE BRAKES DIDN'T PERFORM VERY WELL AND THEY LOCKED UP WHILE DRIVING DOWN DIRT ROADS. *NLM
2000 Chevrolet Silverado 3500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Chevrolet Silverado 3500 do not stand out strongly from the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 3500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
825–50K
750–75K
575–100K
6100–150K
1150K+
38 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports1 fire reports2 injury reports
What owners actually said
80 reportsTHERE WERE POWER STEERING PUMP PROBLEMS WHICH AFFECTED THE BRAKES. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY DID NOT KNOW WHY THIS OCCURRED. *AK THE POWER STEERING AND THE BRAKES KEPT GOING OUT. THE PROBLEM OCCURRED WHEN AN EMPLOYEE HAD DRIVEN THE VEHICLE. *SCC *JB
THE BRAKES OVERHEATED AND THEY SMOKED WHEN DRIVING ON LONG STEEP GRADES, ALSO WHEN DOWN SHIFTING, IT WAS DIFFICULT TO SLOW OR STOP. THE BRAKES WERE NOT ADEQUATE FOR THE WEIGHT OF THE VEHICLE. THE BRAKE PADS WERE REPLACED, THE ROTORS WERE RESURFACED, THE REAR BRAKE DRUMS WERE CLEANED, AND THE BRAKE SHOES WERE ADJUSTED. (THIS D…
Read full complaint
THE BRAKES OVERHEATED AND THEY SMOKED WHEN DRIVING ON LONG STEEP GRADES, ALSO WHEN DOWN SHIFTING, IT WAS DIFFICULT TO SLOW OR STOP. THE BRAKES WERE NOT ADEQUATE FOR THE WEIGHT OF THE VEHICLE. THE BRAKE PADS WERE REPLACED, THE ROTORS WERE RESURFACED, THE REAR BRAKE DRUMS WERE CLEANED, AND THE BRAKE SHOES WERE ADJUSTED. (THIS DID NOT FIX THE PROBLEM) THE VEHICLE CONTINUED TO EXPERIENCE THESE PROBLEMS. THE DEALER REPRESENTATIVE SUGGESTED THE CONSUMER PURCHASE A 2001 MODEL WHICH HAD THE REVISED BRAKING SYSTEM. *NLM *SCC *JB
WHILE DRIVING SMOKE BEGAN TO EMIT FROM THE WHEELS. *NLM
TIRE/TREAD SEPARATION ON A FIRESTONE LT245/75R16. RIGHT REAR WHEEL (THE TIRE DID NOT LOOSE AIR PRESSURE). THIS TIRE WAS ORIGINAL EQUIPMENT ON A 2000 CHEVROLET PASSENGER VAN - LESS THAN 25000 MILES. *NLM
AFTER TOWING A TRAILER, THE REAR TAIL LIGHT BULBS BLEW OUT, THEY WERE REPLACED AND BLEW AGAIN ALONG WITH A MAIN RELAY FUSE UNDER THE HOOD (NEVER SMALL FUSE FROM DASH FUSE BOX). AFTER REPLACING THAT TWICE WE CONTINUED TO HAVE A PROBLEM, THE VEHICLE WAS UNDER WARRANTY SO WE TOOK IT TO THE DEALER, THEY SAID IT WAS SHORTING OUT BECA…
Read full complaint
AFTER TOWING A TRAILER, THE REAR TAIL LIGHT BULBS BLEW OUT, THEY WERE REPLACED AND BLEW AGAIN ALONG WITH A MAIN RELAY FUSE UNDER THE HOOD (NEVER SMALL FUSE FROM DASH FUSE BOX). AFTER REPLACING THAT TWICE WE CONTINUED TO HAVE A PROBLEM, THE VEHICLE WAS UNDER WARRANTY SO WE TOOK IT TO THE DEALER, THEY SAID IT WAS SHORTING OUT BECAUSE OF A BARE WIRE AND THEY FIXED WITH BLACK TAPE(STILL HAVE NOT LOCATED THAT WIRE) THE WARRANTY EXPIRED SHORTLY AFTER AND THE MECHANIC DID NOT DO AN INVOICE FOR ELECTRICAL TAPE...SINCE THEN WE HAVE CONTINUED TO HAVE NUMEROUS PROBLEMS WITH THE ELECTRICAL SYSTEM INCLUDING THE REAR TAIL LIGHTS, BRAKE LIGHTS, REAR TURN SIGNAL LIGHTS, PASSENGER POWER WINDOW CONTROL, PARENTAL WINDOW LOCK CONTROL, HAZARD LIGHTS. WE HAVE ALSO HAD TO REPLACE THE BATTERY 3 TIMES IN JUST OVER A YEAR. WE HAD AN ELECTRIC BRAKE SYSTEM INSTALLED AT THE TIME OF PURCHASE AND HAVE CHECKED THAT WIRING AND THE TRAILER WIRING FOR BARE WIRE SHORTS AND FOUND NOTHING. WE NO LONGER USE THE TRAILER LIGHTS SO IT IS NOT AN OVERLOAD?? ANY INFORMATION ON POSSIBLE DEFECTS WOULD BE APPRECIATED. *JB
THE VEHICLE HAS ALWAYS BEEN HARD TO SHIFT. WHILE SHIFTING FROM REVERSE TO DRIVE THE AUTOMATIC TRANSMISSION CONTROLLER( METAL PIECE INSIDE STEERING COLUMN ATTACHED TO LINKAGE) BROKE IN HALF, ALSO THE THREADED PIECE THAT IT WAS BOLTED TO BROKE, IT IS ALL MADE OF A SOFT TYPE METAL. *JB
THE RIGHT REAR TIRE TREAD SEPARATED WHILE DRIVING 70 MPH RESULTING IN LOSS OF CONTROL AND AN ACCIDENT. A PASSENGER DIED AND AN OTHER WAS IN CRITICAL CONDITION. *NLM
APPLIED ABS BRAKES AT 40 MPH .BRAKES STARTED TO CATCH THEN WENT TO FLOOR CAUSING INCREASED STOPPPING DISTANCE AND VEHICLE COLLISION.
CONSUMER STATES THE REAR BRAKE SHOES ARE WEARING PREMATURELY. TOOK TO DEALER AND THEY CANT FIND PROBLEM. CONSUMER HAS HAD SIX SETS OF BRAKES WITHIN A COUPLE OF YEARS. *JB *YH
Official recalls
100V054000 · Steering:linkages:drag:link:connection
Feb 28, 2000
VEHICLE DESCRIPTION: CHASSIS CABS. THE TAPERED HOLE IN THE DRAG LINK END THAT ATTACHES TO THE PITMAN ARM TAPERED BALL STUD MAY BE MACHINED TOO DEEP CAUSING THE HOLE TO BE OVERSIZED. A DRAG LINK WITH AN OVERSIZED HOLE MAY NOT "SEAT" THE PITMAN ARM TAPERED BALL WHEN ASSEMBLED. THIS COULD CAUSE HIGHER THAN NORMAL FRICTION BETWEEN COMPONENTS DURING OPERATION, AND POSSIBLY RESULT IN JOINT SEPARATION OR A BROKEN BALL STUD.
Consequence & remedy
Consequence: IF THE JOINT SEPARATED OR THE BALL STUD BRAKE WHILE THE VEHICLE WAS MOVING, STEERING CONTROL WOULD BE LOST.
Remedy: DEALERS WILL INSPECT THE STEERING LINKAGE ASSEMBLY AND, IF NECESSARY, REPLACE THE DRAG LINK AND THE PITMAN ARM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
PE04004 · Hydraulic Pump Shaft Failures
Opened Jan 8, 2004 · Closed Apr 30, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Additional source detail variants (5)
Service Brakes, Hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist:hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist System
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.