NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
80 reports1,923 miles · Dec 6, 2005
Service Brakes, Hydraulic
THIS INFORMATION PERTAINS TO A CHEVY CK 3500 CREW CAB 4X4 DULLY PURCHASED NEW IN 2000. AT 1,923 MILES THE ORIGINAL FACTORY FRONT BRAKE PADS WERE WORN OUT AND REPLACED UNDER WARRANTY. AT 3,108 MILES THE ROTOR ASSEMBLY WAS REPLACED. AGAIN, AT 7,709 MILES THE FRONT DISC PADS HAD TO BE REPLACED. AT 11,596 MILES FRONT DISC PADS, …
Read full complaint
THIS INFORMATION PERTAINS TO A CHEVY CK 3500 CREW CAB 4X4 DULLY PURCHASED NEW IN 2000. AT 1,923 MILES THE ORIGINAL FACTORY FRONT BRAKE PADS WERE WORN OUT AND REPLACED UNDER WARRANTY. AT 3,108 MILES THE ROTOR ASSEMBLY WAS REPLACED. AGAIN, AT 7,709 MILES THE FRONT DISC PADS HAD TO BE REPLACED. AT 11,596 MILES FRONT DISC PADS, REAR SHOES AND LININGS. AT 20,317 MILES FRONT PADS AGAIN ALONG WITH REPLACEMENT OF H1320 BOOSTER ASSEMBLY. AT 24,977 MILES FRONT PADS AND H0780 BRAKE VALVE REPLACED. AT 35,000 MILES ONE MORE SET OF FRONT DISC BRAKE PADS BEFORE THE WARRANTY RAN OUT AND THE GENERAL CUT ME LOOSE. SINCE THE WARRANTY EXPIRED, IT HAS CONTINUED TO BE A FRONT BRAKE JOB BETWEEN EVERY 6,000-10,000 MILES. *NM
NHTSA ODI #10144618
75,500 miles · Nov 18, 2005
Service Brakes, Hydraulic
ANTILOCK BRAKES ALWAYS ACTIVATE WHEN BRAKING AT SLOW SPEEDS, WAS TOLD BY CHEVY DEALER THERE IS A RECALL BUT NOT ON MY VEHICLE. *NM
NHTSA ODI #10143082
18,064 miles · Nov 15, 2005
Fuel System, Other
DT: THE CONTACT STATES THE FUEL INJECTION PUMP STOPS WORKING WITHOUT WARNING. THIS CAUSES THE BRAKES AND STEERING NOT TO WORK. THE PUMP HAS BEEN REPLACED TWICE AND HE FEELS THIS HAPPENS EVERY 18,000 MILES. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP FOR THE REPAIRS. THE MANUFACTURER OFFERED HIM $800 TOWARD A NEWER VEHICLE.…
Read full complaint
DT: THE CONTACT STATES THE FUEL INJECTION PUMP STOPS WORKING WITHOUT WARNING. THIS CAUSES THE BRAKES AND STEERING NOT TO WORK. THE PUMP HAS BEEN REPLACED TWICE AND HE FEELS THIS HAPPENS EVERY 18,000 MILES. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP FOR THE REPAIRS. THE MANUFACTURER OFFERED HIM $800 TOWARD A NEWER VEHICLE. *NM
NHTSA ODI #10142769
67,700 miles · Jun 1, 2005
Service Brakes, Hydraulic
DT: PROBLEMS BEGAN ABOUT MARCH 2005, WITH ANTI LOCK BRAKE SYSTEM. FRONT BRAKES ARE GRABBING, AND CALIPERS STAY SHUT. WHEN DRIVER HITS THE BRAKES HARD CALIPERS LOCK. AND WHEN MAKING TURNS A NOISE IS HEARD, A GRINDING NOISE. IN LAST 4 MONTHS BRAKES WERE REPLACED TWICE. EXTENDED STOPPING DISTANCE IS CAUSED WHEN THIS OCCURS. NO W…
Read full complaint
DT: PROBLEMS BEGAN ABOUT MARCH 2005, WITH ANTI LOCK BRAKE SYSTEM. FRONT BRAKES ARE GRABBING, AND CALIPERS STAY SHUT. WHEN DRIVER HITS THE BRAKES HARD CALIPERS LOCK. AND WHEN MAKING TURNS A NOISE IS HEARD, A GRINDING NOISE. IN LAST 4 MONTHS BRAKES WERE REPLACED TWICE. EXTENDED STOPPING DISTANCE IS CAUSED WHEN THIS OCCURS. NO WARNING LIGHTS COME ON, AFTER REMOVAL,THE PADS WERE CHEWED UP. NOT WORN, BUT DAMAGED. OWNER REPLACED BRAKES. *AK
NHTSA ODI #10123752
5,300 miles · May 3, 2005
Service Brakes, Hydraulic
SAME SYMTOMS AS DESCRIBED IN ACTION # PE05020 ABS SYSTEM ENGAGES WHEN APPLYING BRAKES AT SLOW SPEED, SUDDENLY THEIR IS MINIMUM BRAKING, AND STOPPING DISTANCE IS INCREASED GREATLY! VEHICLE IS OUT OF WARRANTY AND DEALER SAYS SYSTEM NEEDS TO BE "FIXED".
NHTSA ODI #10119535
63,000 miles · Feb 9, 2005
Exterior Lighting
4 WAYS (FLASHER SWITCH) BREAKS LEAVING YOU WITHOUT EMERGENCY FLASHERS. *JB
NHTSA ODI #10110164
Mileage unknown · Dec 27, 2004
Service Brakes, Hydraulic
THE ABS CHECK LIGHT MAINTAINS ON WHILE THE VEHICLE IS HAVING A DIFFICULT TIME STOPPING AT INCLINES AND INTERSECTIONS. CONSUMER WILL CONTACT DEALER FOR CHECK UP.*AK VEHICLE ROCKS THROUGH STOPS IN WET CONDITIONS WITH ABS NOISES, BUT VEHICLE DOES NOT STOP. *AK
NHTSA ODI #10105307
Mileage unknown · Nov 8, 2004
Service Brakes, Hydraulic
CHEVROLET 3500 VAN 2000, CALIPERS AND ROTORS DEFECTIVE. *BF THE BRAKES FAIL EVERY 600 TO 1000 MILES. *JB
NHTSA ODI #10117150
93,000 miles · Aug 31, 2004
Tires
WHILE DRIVING 70 MPH, THE REAR DRIVER SIDE TIRE TREAD SEPARATED. AS A RESULT, THE VEHICLE SWERVED. HOWEVER, THE CONSUMER MAINTAINED CONTROL. *AK THIS WAS THE FOURTH TIRE. THE BELTS SLIPPED AND THERE WERE SEPARATIONS. *SC *JB
NHTSA ODI #10087125
26,667 miles · Aug 24, 2004
Tires
TIRE TREAD SEPARATION BLOW OUT WITH BODY DAMAGE.*AK
NHTSA ODI #10088475
NHTSA investigations
2EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
PE04004 · Hydraulic Pump Shaft Failures
Opened Jan 8, 2004 · Closed Apr 30, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Additional source detail variants (5)
Service Brakes, Hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist:hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist System
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Illustration