IllustrationThe contact owns a 2016 Chevrolet Silverado 2500. The contact stated that upon starting the vehicle, the air bag warning light illuminated. The local dealer was not contacted, and the vehicle was not diagnosed or repaired due to the cost. The manufacturer was notified of the failure. The failure mileage was 100,000.
2016 Chevrolet Silverado 2500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2016 Chevrolet Silverado 2500 do not stand out strongly from the model-year median of 81.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 2500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
280–25K
2725–50K
950–75K
575–100K
7100–150K
3150K+
79 reports with mileage · 44 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports2 fire reports3 injury reports
What owners actually said
123 reportsthe vehicle developed a extremely hard down shift and then a check engine light came on. the vehicle went into limp mode, took the vehicle to local diesel mechanic and i was informed that the transmission was bad and had to be replaced, while replacing the transmission i was also told the transfer case was making noise and neede…
Read full complaint
the vehicle developed a extremely hard down shift and then a check engine light came on. the vehicle went into limp mode, took the vehicle to local diesel mechanic and i was informed that the transmission was bad and had to be replaced, while replacing the transmission i was also told the transfer case was making noise and needed to be replaced. this happened in November of 2025 and the parts are not available. This happened while i was towing our trailer across a bridge when the traffic came to a sudden stop, once traffic started moving we could not get up to speed thus causing a traffic hazard. yes the repair shop was able to recreate the issue there were no warnings prior to the failure. I know GM has had issues with transmissions in newer models, i did not know that there was a process like this prior to getting my vehicle repaired and i needed it repaired as soon as possible. that is why i went to and independant repair facility.
While driving down the road at 60 mph the roof and side airbags deployed on both sides of the Truck with no collision only driving down the road. The vehicle was inspected by GM and they claiming no defect on their side. However Recall N202324251 Roof Rail Air Bag Inflator May Rupture, for other 2016 Chevy Silverado's 2500 exi…
Read full complaint
While driving down the road at 60 mph the roof and side airbags deployed on both sides of the Truck with no collision only driving down the road. The vehicle was inspected by GM and they claiming no defect on their side. However Recall N202324251 Roof Rail Air Bag Inflator May Rupture, for other 2016 Chevy Silverado's 2500 exists. This is large safety issue and wondering if the VIN was missed given this happened for the same recall. GM Allegations department has said they will not pay to fix, but didn't provide the reason for the cause of the airbag deployment.
Had new Western Wideout snowplow (recommended by Western) installed by Western dealership on a 2016 Chevrolet Silverado 2500hd with the factory snow plow prep package (RPO VYU). Vehicles instrument cluster, HVAC, Radio and other electrical systems cut out while operating snowplow. GM is well aware of this issue per GM Service Bu…
Read full complaint
Had new Western Wideout snowplow (recommended by Western) installed by Western dealership on a 2016 Chevrolet Silverado 2500hd with the factory snow plow prep package (RPO VYU). Vehicles instrument cluster, HVAC, Radio and other electrical systems cut out while operating snowplow. GM is well aware of this issue per GM Service Bulleting NO.: PIT5387C (Feb 2016) through PIT5387P (10/17/2024), as well as GM Upfitter Integration UI Bulletin #124K (11/7/2019). All list this specific vehicle. This issue effects snowplows by all manufactures and is not confined to Western. Per the above bulletins published by GM, GM is to supply and install a wiring harness under a unique one time warranty procedure that does not expire with the vehicles base warranty. GM dealerships as well as GM's consumer assistance hotline state that GM part number 84043394 (fitting 2014-2019 vehicles) referenced to in PIT5387C and other bulletins has been discontinued. UP Bulletin 124k refers to and instructs to install GM part number 84288774 VYU Snow Plow Jumper harness per the latest version of GM service Bulletin PIT5387. With a note stating "this jumper harness and installation will be provided (one time) without charge". GM dealerships and GM customer assistance (parts) state that PN 84288774 does not appear in their parts system as a valid GM part. The official GM parts store [XXX] lists this part but shows that it does not fit this vehicle. Therefore neither GM nor Western is able to provide any actionable solution to this known and documented issue. GM manufactured, sold, promoted, advertised and continues to state that snowplows can be installed on these vehicles with (or without) GM's factory snow plow prep option. Additionally GM continues to issue and publish Bulletins instructing GM dealerships how to fix this issue despite being fully aware of this impossibility. GM has also made it impossible for GM to honor GM's own warranty that is still in effect for A KNOWN SAFTY ISSUE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATI
Had new Western Wideout snowplow (recommended by western) installed by Western dealership on a 2016 Chevrolet Silverado 2500hd with snow plow prep package. Vehicle's Instrument cluster, HVAS, Radio and other electrical systems cut out while operating snowplow. GM is well aware of this issue which has been discussed and document…
Read full complaint
Had new Western Wideout snowplow (recommended by western) installed by Western dealership on a 2016 Chevrolet Silverado 2500hd with snow plow prep package. Vehicle's Instrument cluster, HVAS, Radio and other electrical systems cut out while operating snowplow. GM is well aware of this issue which has been discussed and documented per GM Service Bulletin No.: PIT5387C (Feb 2016)- PIT5387P (10/17/2024), as well as GM Upfitter Integration UI Bulletin #124k (11/7/2019). Western states the fix for this issue is for GM to supply and install a wiring harness (per the above GM bulletins) GM dealerships as well as GM consumer assistance hotline state that GM part number 84043394 (fitting 2014-2019 vehicles) referenced to in PIT5387 and other bulletins has been discontinued. Therefore GM can not nor will ever be able to obtain or install this wiring harness in the future. GM Upfitter Integration Bulletin #124K instructs to install a different part number 84288774 VYU Snow Low Jumper harness per the latest Version of GM Service Bulletin PIT5387. "Note: that this jumper harness and installation will be provided (one time) without charge." GM dealerships state PN 84288774 does not appear in their system as a valid GM part. Parts. The official GM parts store at [XXX] , list this part but shows it does not fit this vehicle. Therefore neither GM nor Western is able to provide any actionable solution to this KNOWN safety issue. Western (and other manufactures) still manufacturing, recommending and installing snowplows for this specific vehicle. GM, manufactured, sold, promoted, advertises and continues to recommend snowplows to be installed on these vehicles (with the GM factory snow plow prep option), and continues to issue bulletins instructing GM dealerships how to fix this issue despite being fully aware GM cannot supply these parts. Therefor GM has made it impossible for GM to honor their own warranty that still currently in effect, for a KNOWN SAFTEY ISSUE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
The contact owns a 2016 Chevrolet Silverado 2500. The contact stated while driving 45-55 MPH and hauling a trailer, there was an abnormal clunking sound coming from the vehicle. The vehicle was shuddering abnormally, and the wheels locked up for approximately 4-seconds. The contact stated that the transmission was shifting hard.…
Read full complaint
The contact owns a 2016 Chevrolet Silverado 2500. The contact stated while driving 45-55 MPH and hauling a trailer, there was an abnormal clunking sound coming from the vehicle. The vehicle was shuddering abnormally, and the wheels locked up for approximately 4-seconds. The contact stated that the transmission was shifting hard. The thermostat light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was no under recall. The failure mileage was approximately 190,000.
Tranmission isn't running right and gas and brakes are not working properly. Also fuel pump or relay gets hot shuts off while driving.
Transmission was acting funny. Check engine light came on. Took it to a reputable transmission shop who stated it needs a full rebuild due to bad torque converter. $5500. The truck only has 65k mi.
Truck is under 105000 miles and needs a transmission due to a failed torque converter. First starts with erratic speeds in cruise control mode that is unsafe then will not shift into overdrive causing overheating issues.
The contact owns a 2016 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. …
Read full complaint
The contact owns a 2016 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 146,000.
Official recalls
521V504000 · Air Bags:side/window:curtain:inflator
Jul 1, 2021
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.
18V578000 · Service Brakes, Hydraulic:pedals And Linkages
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.
17V437000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
16V651000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
16V069000 · Service Brakes, Hydraulic:pedals And Linkages
Feb 5, 2016
General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 20760.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.