1999 Chevrolet Silverado 2500

RUSTED BRAKE LINES ! DRIVING DOWN THE STREET, HIT BRAKES TO SLOW DOWN TO TURN INTO A DRIVE, BRAKE PEDDLE WENT TO THE FLOOR, NO BRAKES AT ALL, I FOUND THE BRAKE LINE GOING TO THE REAR HAD BROKEN BY THE GAS TANK, BRAKE LINES ARE VERY CORRODED AND RUSTY, TRUCK IS KEEP INDOORS, AND CAME FROM NEW MEXICO, NO RUST ON THE BODY AT ALL, TOW BILL WAS 200 BUCKS,AROUND 50 MILES FROM HOME. STAINLESS STEEL BREAK LINES ARE AROUND 200 TO 300 BUCKS, AROUND 200 TO 300 FOR LABOR, VERY EXPENSIVE SO FAR, AND THE TRUCK IS NOT FIXED YET. THE TRUCK ONLY HAS 90,000 MILES ON IT. WHEN THE REAR LINE BROKE, I SHOULD HAVE, STILL HAD FRONT BREAKS, IN A TWO PART BRAKE SYSTEM, BUT I HAD NO BRAKES AT ALL. I'M LUCKY, IT CAUSED, NO ACCIDENTS, OR INJURIES, OR ANY OTHER DAMAGE. IT COULD HAVE BEEN VERY WORSE, EVEN DEADLY UNDER DIFFERENT CIRCUMSTANCES. YOU THINK THEY WOULD HAVE PUT STAINLESS STEEL ON THE BRAKE LINES LIKE THEY DID ON THE EXHAUST. I MEAN, A RUSTY EXHAUST, PROBABLY WONT KILL ANYBODY, BUT RUSTY BRAKE LINES HAVE KILLED A LOT OF PEOPLE, I'M SURE.

I STARTED TO BACKUP OUT OF MY DRIVEWAY, WHEN I PRESSED ON THE BRAKE PEDAL THEY WENT ALL THE WAY TO THE FLOOR. PULLED BACK INTO DRIVEWAY AND SAW WHERE BRAKE FLUID WOULD SHOOT OUT WHEN THE BRAKE PEDAL WAS PUSHED UNDER THE DRIVER'S SIDE DOOR. FURTHER INVESTIGATION SHOWED THE BRAKE LINE HAD CORROSION IN FOR ABOUT 4 INCHES. REPLACED THE BRAKE LINE. YESTERDAY, SEPTEMBER 13, 2015 AGAIN WENT TO BACK UP AND PEDAL TO FLOOR. UPON EXAMINATION THE BRAKE FLUID SHOOTS OUT IN A STEADY STREAM WHEN PEDAL IS DEPRESSED.

TL* THE CONTACT OWNS A 1999 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE POWER STEERING AND BRAKES MALFUNCTIONED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE HYDROBOOST MALFUNCTIONED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 193,348.

BRAKE PEDAL WENT TO THE FLOOR, VEHICLE DID NOT WANT TO STOP, FOUND ALL BRAKE LINES TO BE SEVERELY CORRODED FROM THE MASTER BRAKE CYLINDER TO THE BRAKING HARDWARE AT EACH WHEEL, DOT3 BRAKE FLUILD LEAKING QUICKLY FROM BRAKE LINE RUNNING TOWARD THE REAR OF THE TRUCK. REF: HTTP://WWW-ODI.NHTSA.DOT.GOV/CARS/PROBLEMS/DEFECT/RESULTS.CFM?ACTION_NUMBER=EA11001&SEARCHTYPE=QUICKSEARCH&SUMMARY=TRUE *JS

COMPLETE REAR BRAKE FAILURE IN PARKING LOT JUST AS I WAS LEAVING WORK. HAD TO QUICKLY PUMP BRAKES TO KEEP TRUCK FROM MOVING. BRAKE PEDAL WENT TO FLOOR IN AN INSTANT. I PUT TRUCK IN PARK GOT OUT AND THERE WAS FLUID ALL OVER THE PLACE ON THE GROUND,AND ON THE DRIVERS SIDE UNDER CARRIAGE JUST BEHIND THE CAB DOOR. LOOKED UNDERNEATH WITH FLASHLIGHT AND COULD SEE THAT THE BRAKE LINE HAD SEVERE RUSTING WHERE EACH PLASTIC HOLD DOWN IS LOCATED AND ONE HAD RUSTED TO POINT OF FAILURE. GLAD I HADN'T PULLED OUT AND ONTO THE HIGHWAY AT THAT POINT. HAD TO HAVE MOST OF THE LINE REPLACED ALONG THE FRAME RAIL,( ABOUT 15'). *TR