While towing a travel trailer from Texas to New Mexico I began to receive DEF 298 miles range remaining after about 3 hours of driving. About 30 minutes after range warning I got another warning that now the tank fluid is low and needs to be refilled. I stopped at the next gas station to fill the DEF tank with fluid but it only …
Read full complaint
While towing a travel trailer from Texas to New Mexico I began to receive DEF 298 miles range remaining after about 3 hours of driving. About 30 minutes after range warning I got another warning that now the tank fluid is low and needs to be refilled. I stopped at the next gas station to fill the DEF tank with fluid but it only took about 1.5 gallons to top it off. I believe it holds 7.7 gallons. Back on the road the DEF level did not reset and it gave me a warning that in 500 miles I would be speed limited to 65 MPH. While this warning is displayed it is not possible to view tire pressure, transmission temperature or any other vital information about the vehicle. The countdown continued and when I reached my destination I had 298 miles remaining. I topped the DEF tank off once again and it took 1.5 gallons again. This only brought the level back to "low add fluid'. After 2 days of driving without the trailer the DEF level returned to full. When I began the return trip with a full DEF tank I made it about an hour before I received the 300 mile range warning. I refilled it at every fuel stop with about 1 gallon. It remained at the 300 mile range warning throughout the trip and after. My issue with this system is that it could render the vehicle undrivable in the middle of nowhere hundreds of miles away from a Chevrolet Service Center. The DEF system especially when it is verified that the tank has fluid and is actually using it normally should be able to be bypassed to make it to a repair center. I forgot to mention that this is a new vehicle 4 months old with about 4000 miles on it. It has been in the Chevrolet Service for 3 weeks and has not even been looked at.
NHTSA ODI #11616051
Mileage unknown · Sep 5, 2024
Air BagsElectrical SystemEngine
After picking up my car from Autonation Chevrolet for the same issue I am reporting, I was driving, and the car dashboard lights all came on. The AC stopped working, too.
NHTSA ODI #11612914
Mileage unknown · Sep 1, 2024
Electrical SystemEngineService Brakes
I am writing to request urgent assistance with my Chevrolet truck, which has experienced several serious issues recently. On September 25, 2024, while driving, the steering wheel became stiff, and the engine's power stopped. The dashboard lights remained on, and I was unable to start or turn off the vehicle. The Chevrolet app i…
Read full complaint
I am writing to request urgent assistance with my Chevrolet truck, which has experienced several serious issues recently. On September 25, 2024, while driving, the steering wheel became stiff, and the engine's power stopped. The dashboard lights remained on, and I was unable to start or turn off the vehicle. The Chevrolet app initially indicated an airbag system issue. However, the next day, it reported problems with the engine and transmission system. I scheduled an appointment with the Bomnin dealership for September 28. When I arrived, the service advisor informed me that due to a backlog, the truck could not be inspected immediately and advised me to return in a month. Consequently, the vehicle has not yet been seen by a Chevrolet mechanic. On September 29, the Chevrolet app also indicated an issue with the anti-lock braking system. To date, I have not received a clear explanation or resolution for these problems. I would greatly appreciate any assistance or guidance you can provide to expedite the repair process and address these issues as soon as possible. Thank you for your attention to this matter.
NHTSA ODI #11611990
Mileage unknown · Aug 5, 2024
EngineStructureSuspensionCrash
I had a car accident in Mexico while I was driving inside the beach
NHTSA ODI #11606510
Mileage unknown · Jul 10, 2024
Engine
Bought my truck new in March, after just 1 week i took my truck in after i noticed a loud rattling sound. Dealership replaced the rear section of the exhaust. After just a few days the noise came back. Now GM wont do anything about it. Truck has 11k miles on it now and the noise continues to get louder. Truck is available to be …
Read full complaint
Bought my truck new in March, after just 1 week i took my truck in after i noticed a loud rattling sound. Dealership replaced the rear section of the exhaust. After just a few days the noise came back. Now GM wont do anything about it. Truck has 11k miles on it now and the noise continues to get louder. Truck is available to be inspected. I dont feel the truck is dependable. Dealership has heard the sound again but wont do anything because GM wont pay for another exhaust system. No warning lights.
NHTSA ODI #11600799
Mileage unknown · Jul 5, 2024
Electrical SystemEngineUnknown Or Other
As I stopped at a red light, I received a message on my instrument panel to “push state”. I noticed my RPMs were at 0 and my vehicle was in neutral. I attempted to shift into drive, but received the same message again. I already had my foot on the brake as I was stopped, so I pushed the start button. The vehicle began its normal…
Read full complaint
As I stopped at a red light, I received a message on my instrument panel to “push state”. I noticed my RPMs were at 0 and my vehicle was in neutral. I attempted to shift into drive, but received the same message again. I already had my foot on the brake as I was stopped, so I pushed the start button. The vehicle began its normal startup sequent and my RPMs return to normal. I shifted into drive and was able to continue to where I was headed. At no time did I ever shift the vehicle into neutral or turn it off.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
OEM Systems, LLC (OEM) is recalling certain 2024 Chevrolet Silverado vehicles. The rear bumper mounting bracket may not be sufficient for towing, which can allow the towed trailer to detach from the vehicle.
Consequence & remedy
Consequence: A trailer that detaches from a vehicle while driving increases the risk of a crash.
Remedy: OEM will replace the rear bumper mounting bracket and hitch, free of charge. Owner notification letters are expected to be mailed in August 2024. Owners may contact OEM customer service at 1-800-810-7252.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2024 Chevrolet Silverado 1500 Problems, Complaints & Recalls | Skip That Year
Illustration