NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
188 reportsClear category filterMileage unknown · Nov 22, 2023
Electrical System
At a major intersection of several lanes north/south & east/west silverado stalled while waiting for the red light to change. Engine cutoff, would not restart, and situation was high traffic time at a high traffic intersection. Car was towed, problem diagnosed as the electronic sensor would not allow electricty to the starter…
Read full complaint
At a major intersection of several lanes north/south & east/west silverado stalled while waiting for the red light to change. Engine cutoff, would not restart, and situation was high traffic time at a high traffic intersection. Car was towed, problem diagnosed as the electronic sensor would not allow electricty to the starter motor. required part is not available, it turns out that this is reportedly a common problem. The truck is a Silverado 2019 with 36,811 miles. Reportedly out of warranty but this appears to be a common problem and certainly is the kind of problem that would be many years down the road
NHTSA ODI #11556502
Mileage unknown · Nov 2, 2023
Electrical SystemFuel/propulsion SystemSteering
I've had continued issues with components that are electrical . The interior electrical items go wonky, radio touch screen will blink back and forth between two screens for several minutes. Sometimes the sir and radio will just turn on with no key, this is random. It will also turn on off then on again after removing key. The ac…
Read full complaint
I've had continued issues with components that are electrical . The interior electrical items go wonky, radio touch screen will blink back and forth between two screens for several minutes. Sometimes the sir and radio will just turn on with no key, this is random. It will also turn on off then on again after removing key. The ac has begun to randomly stop working(, blowing cold or at sufficient correct speed) all these occurrences are random, have been checked, unable to duplicate or correct. Bigger more serious issues . The steering and loss of power and hesitation in transmission. My steering went horribly bad. It was replaced and it's still bad and the power module in new unit is bad.. again waiting for s new tech and pinion. (It's been ridiculous with the strike) the steering for several months has been extremely sloppy causing the truck to wander and it's very unsafe. Over the last couple months there's a hesitation when stepping on the gas. As well as a loss in power while driving and far too much gas is required to get it going. The truck purrs when idling but it's losing power. I've stayed on top of the maintenance.. I've had everything checked. These electrical issues have become more than annoying. They are now unsafe, becoming very expensive and have resulted in my having to rent a vehicle. I see there have been many complaints over steering, transmission and electrical. It's time to do something about these unsafe issues
NHTSA ODI #11553139
20,000 miles · Oct 20, 2023
Back Over PreventionElectrical System
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at 55 MPH, the instrument panel became inoperable. Additionally, back-up camera was displaying a black screen. No warning light was illuminated. The vehicle was diagnosed; however, the mechanic was unable to determine the cause of the failure…
Read full complaint
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at 55 MPH, the instrument panel became inoperable. Additionally, back-up camera was displaying a black screen. No warning light was illuminated. The vehicle was diagnosed; however, the mechanic was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 20,000.
NHTSA ODI #11550999
Mileage unknown · Sep 1, 2023
Electrical SystemSteering
I first noticed jerking in my steering two days later the power assist failed. It was almost impossible to steer the vehicle. Luckily I was just leaving my drive. Next time I was in the vehicle the power assist for the steering worked fine, went online and found a video that makes the repair was a body to frame ground strap. Thi…
Read full complaint
I first noticed jerking in my steering two days later the power assist failed. It was almost impossible to steer the vehicle. Luckily I was just leaving my drive. Next time I was in the vehicle the power assist for the steering worked fine, went online and found a video that makes the repair was a body to frame ground strap. This braided copper ground strap from frame to body is located right behind the passengers front wheel. It is subject to salt and corrosion. My vehicle only has 40,000 miles on it and I do have a picture of the failure cost me $10 to repair it shame on GM for putting this critical ground just behind the front tire exposed to salt and corrosion
NHTSA ODI #11542125
Mileage unknown · Aug 14, 2023
Electrical SystemPower TrainSteering
There is a vibration that is randomly felt. Over the last year I have replaced struts shocks control arm control arm bushings sway bar link sway bar link bushings tires twice and the vibration just keeps increasing to the point it's doing it now when I turn or take bends in the highway. There is now a flat spot in a tire feel wh…
Read full complaint
There is a vibration that is randomly felt. Over the last year I have replaced struts shocks control arm control arm bushings sway bar link sway bar link bushings tires twice and the vibration just keeps increasing to the point it's doing it now when I turn or take bends in the highway. There is now a flat spot in a tire feel when going it slower speeds to be added to the vibration that happens later on obviously related. This is either from my understanding going to be axle or driveshaft it's going to get looked at today since there's nothing left underneath to repair. This has ruined a pair tires I bought last year for $1,500 in September and probably well on its way to ruining the tires that I've just put on last week for $2,400. There is a hesitation a lack of response and a vibration. As far as the electrical goes it makes this very weird buzzing sound very randomly it's only happened about four times it's loud and it can't be explained. Also sometimes the radio and the AC just turns on and there's no key in the car and I've had the door open for a few minutes. Sometimes after turning it off he'll turn everything off but turn it all back on again no key in. Sometimes I can turn the stereo off and it makes a whistling buzzing sound and it's not even on. As far as any light indicators on the dash for any of this no never had a one. I have completely taken care of this vehicle with the transmission flush and will changes and everything that it's supposed to have and I put a lot of money in it since I've had it in a year but I shouldn't have to on 2019 and it's still experiencing the same problems and I have plenty of documentation. As far as date of occurrence it's been continual and random since I bought the truck in June of 2023 from a local dealership called Lokey
NHTSA ODI #11538289
Mileage unknown · Aug 7, 2023
Electrical SystemEnginePower Train
Loss of power/misfire on cylinder 6 Diagnosis is cam/lifters. 8/4/2023 120k miles. Shift to park warning at 60,000 miles. continues. Max speed held to 65mph due to abs system???? for 10 minutes at approximately 90k miles. Park assist failure (complete) at approximately 80k miles.
NHTSA ODI #11536912
Mileage unknown · Jul 7, 2023
Electrical SystemSteering
Service Trailer Brake warning flashed then suddenly lost power steering which nearly caused a crash. Vehicle was taken to dealership and a corroded Grounding Strap caused the complete loss of the electrical power steering system.
NHTSA ODI #11530908
Mileage unknown · Jun 30, 2023
Electrical SystemForward Collision AvoidancePower Train
The pickup shifts violently in and out of overdrive and than into second and than overdrive all while driving down the road at 55 mph and the rear end locks the tires up some times and the whole truck vibrates really and this power Tran problem is getting worse everyone I drive it and it's not safe to have any passengers or my k…
Read full complaint
The pickup shifts violently in and out of overdrive and than into second and than overdrive all while driving down the road at 55 mph and the rear end locks the tires up some times and the whole truck vibrates really and this power Tran problem is getting worse everyone I drive it and it's not safe to have any passengers or my kids in it anymore and it feels like the transmission is going to disintegrate at any moment because and if it does the transmission is going to lock up and than its going to cause a car accident ..PLEASE FIX THIS PROBLEM BEFORE THIS TRUCK CAUSES A ACCIDENT BECAUSE OF A MANUFACTURING PROBLEM ..IM JUST THINKING ABOUT MY KIDS SAFETY AND OTHER FAMILIES SAFETY ON THE ROAD ...FROM A CONCERN PARENT ..
NHTSA ODI #11529836
Mileage unknown · Jun 30, 2023
Electrical SystemEngine
The wiring harness of the vehicle was placed too close to the frame and began wearing the wires down until they broke. Once this happened, the vehicle turned off while driving and would not restart for a few minutes. The vehicle would turn off repeatedly every few minutes leaving me stranded in the middle of the street until I c…
Read full complaint
The wiring harness of the vehicle was placed too close to the frame and began wearing the wires down until they broke. Once this happened, the vehicle turned off while driving and would not restart for a few minutes. The vehicle would turn off repeatedly every few minutes leaving me stranded in the middle of the street until I could get the truck to turn off and restart. There was no warning on when the engine would shut off, it just happened randomly while driving and while in park.
NHTSA ODI #11529707
70,000 miles · May 15, 2023
Electrical SystemEngine
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at various speeds the vehicle had stalled. After restarting the vehicle the check engine light had illuminated and the vehicle would not operate in first gear. The vehicle was later taken to the local dealer who was unable to duplicate the fa…
Read full complaint
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at various speeds the vehicle had stalled. After restarting the vehicle the check engine light had illuminated and the vehicle would not operate in first gear. The vehicle was later taken to the local dealer who was unable to duplicate the failure and no service was performed. The vehicle was retrieved and the failures reoccurred. The vehicle was taken to a different dealer who diagnosed that the engine wire harness was damaged while robbing against the engine components and the harness needed to be replaced. The vehicle was not yet repaired. The failure mileage was 70,000.
NHTSA ODI #11522084
Official recalls
10Dec 16, 2021
General Motors (GM) is recalling certain 2019-2021 GMC Sierra 1500 and Silverado 1500 vehicles equipped with certain accessory road tires and a 17" spare tire. The 17" spare tire provided with the vehicle is not compatible for use with the accessory wheels, which can cause the anti-lock brake system (ABS) to not function properly under certain conditions.
Consequence & remedy
Consequence: An ABS system that does not function properly can increase the risk of a crash.
Remedy: Dealers will provide a new 17" spare tire and wheel assembly that is compatible with the accessory wheels, free of charge. Dealers will also apply a new spare tire information label, and provide owners with an owner's manual insert clarifying which spare tire to use with the accessory road tires and with the 17" original tires. Owner notification letters were mailed February 7, 2022. Owners may contact GM customer service at 1-800-462-8782 or GMC customer service at 1-800-462-8782. GM's number for this recall is N212346510.
Jun 3, 2021
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Additional source detail variants (2)
Tires:sidewall
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Tires
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Feb 25, 2021
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.
Dec 17, 2020
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence & remedy
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Additional source detail variants (2)
Seat Belts:critical Fasteners
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Seat Belts
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Oct 22, 2020
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 and 2020 Chevrolet Silverado 2500 trucks. One of the driveshaft joints may not have been properly welded, causing the driveshaft to separate while the vehicle is moving.
Consequence & remedy
Consequence: If the driveshaft separates, there may be a loss of propulsion, increasing the risk of crash.
Remedy: GM will notify owners, and dealers will replace the driveshaft, free of charge. The recall is expected to begin December 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202314870.
Jan 30, 2020
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. These vehicles received updated software for the Electronic Brake Control Module (EBCM). This software has an error, and as a result, the vehicle's electronic brake assist may be disabled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: A loss of electronic brake assist can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 24, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268091.
Dec 12, 2019
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 trucks. The battery positive (B+) cable rings may have been manufactured with excessive glue, potentially causing an intermittent electrical connection between the B+ cable and alternator.
Consequence & remedy
Consequence: An intermittent electrical connection between the B+ battery cable and the alternator could cause the vehicle to stall, increasing the risk of a crash. The intermittent connection could also lead to electrical arcing, which could generate sufficient heat to damage surrounding material, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will inspect for the presence of glue or other contamination at the B+ cable attachment to the alternator and clean the connection and reattach the B+ cable connection, as necessary. If arcing has damaged the cable, nut, or alternator, the dealer will replace the damaged components. All services will be performed free of charge. GM issued owners an interim notification on February 4, 2020. GM issued second notice and the recall began March 9, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192273510.
Dec 12, 2019
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:abs Warning Light
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Nov 14, 2019
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the pretensioner bracket, possibly igniting the carpet.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192270600.
Dec 6, 2018
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 Crew Cab and GMC Sierra 1500 Crew Cab vehicles. The passenger-side frontal air bag module may have been damaged during assembly, possibly resulting in the air bag not inflating properly in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash, an air bag that does not inflate properly can increase the risk of injury.
Remedy: GM will notify owners, and dealers will replace the passenger side air bag module, free of charge. The recall began on December 18, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N182198820.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration