Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1690–25K
20525–50K
27650–75K
19375–100K
144100–150K
42150K+
1,029 reports with mileage · 405 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 406 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 341 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 269 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
61 crash reports18 fire reports30 injury reports
What owners actually said
1,434 reports
4,577 miles · Jan 19, 2015
Engine And Engine CoolingFuel/propulsion System
I WAS TRAVELING UP AN INCLINE WHEN VEHICLE STARTED JUMPING. ENGINE LIGHT CAME ON, AS WELL AS STABILITY OR SKID CONTROL AND WHEN TURNING ON TURN SIGNAL THE WIPERS CAME ON. DID NOT FEEL SAFE BUT DROVE TO NEAREST DEALERSHIP WITH VEHICLE JUMPING AND MISSING OUT, ABOUT 4 BLOCKS. DIAGNOSES WAS FAULTY FUEL INJECTOR AT 4577 MILES ON VEH…
Read full complaint
I WAS TRAVELING UP AN INCLINE WHEN VEHICLE STARTED JUMPING. ENGINE LIGHT CAME ON, AS WELL AS STABILITY OR SKID CONTROL AND WHEN TURNING ON TURN SIGNAL THE WIPERS CAME ON. DID NOT FEEL SAFE BUT DROVE TO NEAREST DEALERSHIP WITH VEHICLE JUMPING AND MISSING OUT, ABOUT 4 BLOCKS. DIAGNOSES WAS FAULTY FUEL INJECTOR AT 4577 MILES ON VEHICLE. AFTER PICKING UP VEHICLE WHEN REPAIR WAS DONE IT MISSED OUT AGAIN BUT NO ENGINE LIGHT. DEALERSHIP COULD NOT DUPLICATE THE PROBLEM. HOPE THIS ISN'T GOING TO BE ONGOING ISSUE. *TR
NHTSA ODI #10676543
17,900 miles · Jan 14, 2015
Electrical SystemTiresWheels
THE DRIVERS SIDE FRONT TIRE ALERTED IT WAS LOW ON AIR. STOPPED AND CHECKED AIR PRESSURE BUT IT WAS OK. I RETURNED HOME AND THE NEXT MORNING THE DRIVERS SIDE REAR TIRE WAS FLAT. SWAPPED THE TIRE WITH THE SPARE AND TOOK IT TO THE DEALER. THE AIR PRESSURE DISPLAY ON THE TRUCK IS REVERSED. THE INDICATOR FOR THE FRONT TIRE IS SHOW…
Read full complaint
THE DRIVERS SIDE FRONT TIRE ALERTED IT WAS LOW ON AIR. STOPPED AND CHECKED AIR PRESSURE BUT IT WAS OK. I RETURNED HOME AND THE NEXT MORNING THE DRIVERS SIDE REAR TIRE WAS FLAT. SWAPPED THE TIRE WITH THE SPARE AND TOOK IT TO THE DEALER. THE AIR PRESSURE DISPLAY ON THE TRUCK IS REVERSED. THE INDICATOR FOR THE FRONT TIRE IS SHOWING THE REAR TIRE. THE REAR TIRE IS SHOWING THE PRESSURE FOR THE FRONT TIRE. THEY ARE FIXING IT NOW, NOT SURE OF THE TROUBLE YET. *TR
NHTSA ODI #10672478
10,405 miles · Jan 5, 2015
Steering
PRIOR TO THIS INCIDENT MY TRUCK HAD 6 RECALLS. ALMOST ALL OF THE RECALLS HAVE BEEN FOR ?SOFTWARE? ISSUES. THE LATEST PROBLEM IS WHAT I AM WRITING TO YOU ABOUT AND I BELIEVE IS AN EXTREMELY DANGEROUS SITUATION AND IF IT HAPPENS TO SOMEONE WHO IS NOT PHYSICALLY CAPABLE OF HANDLING IT, IT COULD EASILY BE FATAL TO ONE OR MORE INDIV…
Read full complaint
PRIOR TO THIS INCIDENT MY TRUCK HAD 6 RECALLS. ALMOST ALL OF THE RECALLS HAVE BEEN FOR ?SOFTWARE? ISSUES. THE LATEST PROBLEM IS WHAT I AM WRITING TO YOU ABOUT AND I BELIEVE IS AN EXTREMELY DANGEROUS SITUATION AND IF IT HAPPENS TO SOMEONE WHO IS NOT PHYSICALLY CAPABLE OF HANDLING IT, IT COULD EASILY BE FATAL TO ONE OR MORE INDIVIDUALS. WHAT HAPPENED TO ME IS AS FOLLOWS: THE DAY BEFORE CHRISTMAS EVE I DROVE TO THE LOCAL SUPERMARKET TO PICK UP SOME LAST MINUTE STUFF AND AFTER LEAVING THE STORE I PULLED OUT ONTO A BUSY 4 LANE HIGHWAY AND BEGAN TO TURN LEFT. PART WAY INTO THE TURN I HEARD A ?CLUNK? IN THE FRONT ENGINE COMPARTMENT AND IMMEDIATELY THE POWER STEERING STOPPED WORKING. THE STEERING WHEEL WAS WRENCHED OUT OF MY HANDS AND I WAS FORCED TO BRAKE SHARPLY. I WAS, OBVIOUSLY TAKEN BY SURPRISE BY THE INCIDENT AND GRABBED THE WHEEL WITH BOTH HANDS AND WRESTLED THE 6,000 LB TRUCK AROUND THE TURN, RUNNING OVER THE CURB ON THE FAR SIDE OF THE ROAD. I AM A REASONABLY FIT 6?4? 225 LB MALE AND I MUST TELL YOU THAT IT WAS ALL THAT I COULD DO TO TURN THE WHEEL AND PREVENT ME FROM RUNNING STRAIGHT THROUGH THE INTERSECTION. MY DEALERSHIP WAS 4 MILES FROM ME AND I WAS ABLE TO NEGOTIATE MY WAY THERE WITHOUT ANY ACCIDENTS OR INJURIES. I GOT THE TRUCK THERE AND TOLD THE SERVICE PEOPLE WHAT HAPPENED AND THEY SAID HAVE A SEAT IN THE WAITING ROOM AND THEY WOULD LOOK AT IT. 25 MINUTES LATER A REP CAME OUT AND SAID IT WAS FIXED. ANOTHER SOFTWARE ADJUSTMENT WAS MADE. YESTERDAY, JAN 5 THE SAME PROBLEM OCCURRED AND THIS TIME I ALMOST HAD A HEAD ON COLLISION WITH ANOTHER VEHICLE. ONCE AGAIN I WAS CLOSE TO MY DEALER AND WAS ABLE TO DROP THE TRUCK OFF IN THEIR LOT. THEY ARE CLOSED ON SUNDAY SO I CALLED THEM TODAY AND I AM WAITING FOR THEM TO ?FIX? IT AGAIN. I AM ALMOST AFRAID TO DRIVE THE VEHICLE AFTER THIS LATEST INCIDENT. UPDATED 03/04/15*LJ UPDATED 10/8/2015*JS
NHTSA ODI #10670075
433 miles · Dec 3, 2014
Suspension
BOUGHT A NEW 2014 CHEVY PICKUP WITH FOUR (4) MILES ON IT AND IT HAS A VIBRATION THAT THE DEALER CAN NOT REPAIR (3) TIMES IT NOW HAS 736 MILES MOSTLY PUT ON BY THE DEALER. THE MORE I DRIVE IT THE WORSE IT GETS, GM & CHEVROLET MOTOR DIVISION HAVE BEEN NO HELP! *JS
WAS TOWING A TRAILER, STOPPED AND FILLED UP WITH GAS. AS LEAVING THE GAS STATION, DASH LIGHTS DIMMED AND BRIGHTENED ON THEIR OWN, THEN WASHER PUMP STARTED SQUIRTING FLUID WITHOUT WIPER BLADES MOVING. WASHER PUMP CONTINUED SQUIRTING TILL THE RESERVOIR WAS EMPTY AND BURNED THE PUMP. AFTERWARDS, ALL INTERIOR LIGHTS STOPPED WORKING,…
Read full complaint
WAS TOWING A TRAILER, STOPPED AND FILLED UP WITH GAS. AS LEAVING THE GAS STATION, DASH LIGHTS DIMMED AND BRIGHTENED ON THEIR OWN, THEN WASHER PUMP STARTED SQUIRTING FLUID WITHOUT WIPER BLADES MOVING. WASHER PUMP CONTINUED SQUIRTING TILL THE RESERVOIR WAS EMPTY AND BURNED THE PUMP. AFTERWARDS, ALL INTERIOR LIGHTS STOPPED WORKING, EXCEPT FOR THE DASH LIGHTS. ALSO, LOST ALL PARKING, HEAD LAMPS, TURN SIGNAL AND BRAKE LIGHTS ON THE 2014 SILVERADO 1500, EXCEPT FOR HIGH MOUNT STOP LAMP, WHICH WAS STUCK ON BRIGHT, AS IF BRAKE PEDAL WAS DEPRESSED. UPON READING OWNERS MANUAL, THERE IS A REFERENCE TO LOOSING LIGHTS UNDER "ELECTRICAL OVERLOAD". ALL ELECTRONICS BEING USED WAS FACTORY INSTALLED, OTHER THAN THE TRAILER THAT WAS BEING PULLED. UPON TAKING IT TO THE DEALERSHIP FOR REPAIR, THEY COULD NOT DETERMINE WHAT CAUSED THE ISSUE. THEY REPLACED A BODY CONTROL MODULE. ONE WEEK AFTER GETTING THE TRUCK BACK FROM THE DEALERSHIP, THE DASH LIGHTS HAVE DIMMED AND BRIGHTENED ON THEIR OWN AGAIN, THEREFORE, I AM AFRAID TO HOOK MY TRAILER BACK UP IN FEAR OF LOOSING ALL MY LIGHTS AGAIN, OR WORSE, DRIVING AND ALL OF THE SUDDEN, WASHER PUMP STARTS SQUIRTING FLUID AND GETTING INTO AN ACCIDENT. AFTER TALKING TO GM DIRECTLY, THEY CANNOT PROVIDE AN ANSWER TO WHAT HAPPENED OR WHY THEY WOULD REFERENCE THE "LOOSING LIGHTS UNDER ELECTRICAL OVERLOAD" IN THE OWNERS MANUAL, BECAUSE OF A KNOWN DEFECT OR ISSUE THAT WOULD HINDER THEIR PROFITS. *JS
NHTSA ODI #10661495
1,600 miles · Nov 26, 2014
Seats
THE REAR SEAT HEAD RESTS ON THE 2014 CHEVY SILVERADO Z71 DOUBLE CAB 1500 TRUCKS DO NOT PROVIDE PROTECTION. THEY DO EXTEND UP SOME BUT NOT ONLY DO THEY NOT STAY IN PLACE WHEN EXTENDED UP, THEY ALSO DO NOT EXTEND UP HIGH ENOUGH FOR EVEN A 5' 8" PERSONS HEAD. THE REST STILL ALLOWS THE PASSENGERS HEAD TO HIT THE REAR WINDOW. WHEN…
Read full complaint
THE REAR SEAT HEAD RESTS ON THE 2014 CHEVY SILVERADO Z71 DOUBLE CAB 1500 TRUCKS DO NOT PROVIDE PROTECTION. THEY DO EXTEND UP SOME BUT NOT ONLY DO THEY NOT STAY IN PLACE WHEN EXTENDED UP, THEY ALSO DO NOT EXTEND UP HIGH ENOUGH FOR EVEN A 5' 8" PERSONS HEAD. THE REST STILL ALLOWS THE PASSENGERS HEAD TO HIT THE REAR WINDOW. WHEN ONE RESTS THEIR HEAD BACK THE REST EASILY GOES DOWN AND DOES NOT LOCK IN PLACE. REAR IMPACTS WOULD DEFINITELY RESULT IN A HEAD INJURY. OTHERS ON VARIOUS CHEVROLET ONLINE FORUMS HAVE NOTICED THE PROBLEM AND WILL NOT LET ADULTS RIDE IN THE REAR DOUBLE CAB AREA OF THE TRUCK. I CAN SEND YOU A VIDEO OF THIS PROBLEM IF YOU LIKE. EMAIL: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10661037
950 miles · Nov 25, 2014
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT GASOLINE FUEL FUMES EMITTED INTO THE VEHICLE. THE CONTACT MENTIONED THAT SMOKE WAS ALSO EMITTING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL INJECTOR SEALS HAD FAILED AND WOULD NEED TO BE REPLACED. …
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT GASOLINE FUEL FUMES EMITTED INTO THE VEHICLE. THE CONTACT MENTIONED THAT SMOKE WAS ALSO EMITTING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL INJECTOR SEALS HAD FAILED AND WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 950.
NHTSA ODI #10660962
7,000 miles · Nov 20, 2014
Electrical SystemService Brakes
I OWN A 2014 CHEVY Z71 THAT HAD A SHERROD LIFT PACKAGE INSTALLED AT THERE FACTORY AND I HAVE BROUGHT IT INTO THE DEALER FOR EXCESSIVE TIRE WEAR AND THE SECOND TIME IT WAS IN THE DEALER DISCOVERED THAT ALL 4 BRAKE LINES WERE ABOUT TO BURST DUE TO EXCESSIVE WEAR AND INCORRECT INSTALLATION OF THE LIFT. MY CONCERN IS THERE ARE ALOT…
Read full complaint
I OWN A 2014 CHEVY Z71 THAT HAD A SHERROD LIFT PACKAGE INSTALLED AT THERE FACTORY AND I HAVE BROUGHT IT INTO THE DEALER FOR EXCESSIVE TIRE WEAR AND THE SECOND TIME IT WAS IN THE DEALER DISCOVERED THAT ALL 4 BRAKE LINES WERE ABOUT TO BURST DUE TO EXCESSIVE WEAR AND INCORRECT INSTALLATION OF THE LIFT. MY CONCERN IS THERE ARE ALOT OF THESE TRUCKS ON THE MARKET AND HAD I DROVE IT ANOTHER WEEK IT WOULD HAVE BEEN FATAL FOR ME OR SOMEONE I HIT DUE TO BRAKE FAILURE. I FEEL THIS ISSUE NEEDS TO ADDRESSED DUE TO THE SEVERITY OF THE ISSUE. THE DEALER DEADLINED MY VEHICLE DUE TO A MAJOR SAFETY FACTOR AND CONTACTED SHERROD. AS OF YET I HAVE NOT HEARD FROM SHERROD ABOUT THE REPAIR. ITS THE THOUSANDS OF OTHER DRIVERS OF THESE VEHICLES I AM CONCERNED ABOUT. IF THE ONE I OWNED WAS DONE INCORRECTLY BUT TO SPECS ACCORDING TO SHERROD THAN IN 7000 MILES IF MINE WERE WITHIN DAYS OF BURSTING THAN SO ARE THERES. I HAVE PICTURES OF THE LINES IF SOMEONE NEEDS THEM. SOMETHING HAS TO BE DONE OR LIVES WILL AND ARE AT STEAK. *TR
NHTSA ODI #10659651
18,316 miles · Nov 14, 2014
Engine
THE VEHICLE WAS SERVICED AT LANDERS CHEVROLET, BENTON, AR 72015, ON 10/30/14. THE DEALERSHIP CHANGED THE OIL. ON NOVEMBER 6, 2014, THE ENGINE STOPPED WHILE BEING DRIVEN DOWN THE STREET AT A RATE OF 35 MPH. THE VEHICLE WAS TOWED TO THE DEALERSHIP. THE DEALERSHIP REFUSED TO REPLACE THE VEHICLE UNDER WARRANTY. THE SERVICE MANAG…
Read full complaint
THE VEHICLE WAS SERVICED AT LANDERS CHEVROLET, BENTON, AR 72015, ON 10/30/14. THE DEALERSHIP CHANGED THE OIL. ON NOVEMBER 6, 2014, THE ENGINE STOPPED WHILE BEING DRIVEN DOWN THE STREET AT A RATE OF 35 MPH. THE VEHICLE WAS TOWED TO THE DEALERSHIP. THE DEALERSHIP REFUSED TO REPLACE THE VEHICLE UNDER WARRANTY. THE SERVICE MANAGER STATES THAT THE BACK TIRES ARE WORN WHICH INDICATES ABUSE. GM WAS CONTACTED SEVERAL TIMES AND EVERY TIME WE HAVE CONTACTED THEM, THE REPRESENTATIVES HAVE STATED THAT THE TIRES HAVE NOTHING TO DO WITH THE ENGINE AND THE ENGINE IS UNDER WARRANTY AND HAS TO BE REPLACED. GM THEN CONTACTED THE DEALERSHIP, AND THE DEALERSHIP CONTACTED ME AND TOLD ME THAT THEIR GM REP. STATED THAT HE DID NOT HAVE TO REPLACE THE ENGINE DUE TO THE TIRES. WE CONTACTED GM AGAIN AND WHEN THE REPRESENTATIVE CALLED US BACK, THEY STATED THAT THEY ARE NOT GOING TO REPLACE THE ENGINE UNDER WARRANTY BASED ON THE DEALERSHIP. *TR
NHTSA ODI #10654994
23 miles · Nov 10, 2014
Unknown Or Other
AFTER SEVERAL TRIES, STILL WON'T PASS SMOG CERTIFICATION IN CALIFORNIA. PURCHASED IN OREGON, LESS THEN 30 MILES FROM CALIFORNIA. *TR
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
General Motors LLC (GM) is recalling certain 2014 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The vehicles may have a temporary loss of electric power steering (EPS) assist, especially during low-speed turning maneuvers.
Consequence & remedy
Consequence: If EPS assist is lost and then returns, the driver might lose temporary control of the steering wheel, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began on August 10, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-432-8782. GM's number for this recall is 17276.
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration