IllustrationI WAS CLEANING THE INSIDE OUT AND NOTICED A HOLE IN THE PASSENGER SIDE SEAT IN THE BOTTOM AREA AND THE LEATHER WAS THIN WHERE IT WAS TORN AND I WENT TO MY DEALER AND THEY SAID IT WOULD TAKE MOST OF THE DAY TO TAKE IT OFF TO SEE IF IT WAS TORN OR A PUNCTURE SO I JUST WANTED TO ADD MY TRUCK TO THIS LIST FOR DEFECTS. *TR
2014 Chevrolet Silverado 1500
Owner reports · Recalls · Investigations
More warning signs than most Silverado 1500 years
Owner complaints for the 2014 Chevrolet Silverado 1500 are substantially higher than the model-year median of 525.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1690–25K
20525–50K
27650–75K
19375–100K
144100–150K
42150K+
1,029 reports with mileage · 405 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 406 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 341 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 269 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
61 crash reports18 fire reports30 injury reports
Seats complaints
29 reportsWHILE DRIVING IN 4WD 'AUTO', OFF PAVEMENT IN WATERFRONT AREA, I DID NOT THINK 4WD WAS ENGAGING. WHEN I SHIFTED TO 4H, THE SEAT IMMEDIATELY CLAM SHELLED IN AND DOWN ON ME. I RESET SEAT, AND NOTICED MIRRORS ALSO HAD MOVED. A FEW MINUTES LATTER I TRIED THE SAME MANEUVER WHILE MOVING <5 MPH, WITH THE SAME RESULTS. I DROVE THE 20+ M…
Read full complaint
WHILE DRIVING IN 4WD 'AUTO', OFF PAVEMENT IN WATERFRONT AREA, I DID NOT THINK 4WD WAS ENGAGING. WHEN I SHIFTED TO 4H, THE SEAT IMMEDIATELY CLAM SHELLED IN AND DOWN ON ME. I RESET SEAT, AND NOTICED MIRRORS ALSO HAD MOVED. A FEW MINUTES LATTER I TRIED THE SAME MANEUVER WHILE MOVING <5 MPH, WITH THE SAME RESULTS. I DROVE THE 20+ MILES BACK HOME IN 4AUTO, BUT READY FOR A SURPRISE SHIFT INTO 4WD, WITH THE ACCOMPANYING, DANGEROUS SEAT POSITION CHANGE. IT OCCURRED 1 MORE TIME, WHILE DRIVING SLOWLY APPROACHING MY DRIVEWAY. I TRIED TO DUPLICATED IT A FEW MORE TIMES DURING A 2 WEEK PERIOD; NO OCCURRENCES. THE SALES PEOPLE TOLD ME TO USE 4AUTO AS MY REGUALR MODE. I DECIDED TO TRY 2H. NOW WHEN I GO FROM 2H TO 4AUTO, THE SEAT MOVES BACKWARD IN SHORT JOLTS. GOING TO 4H OR 4L, AS DIRECTED IN THE MANUAL, A CLAM SHELL EFFECT OCCURS. I HAVE DONE IT WITH OTHERS IN MY TRUCK, SO THEY CAN WITNESS THE SEAT TRY TO DEVOUR ME. THE LAST TIME IT HAPPENED, I LEFT IT IN THE DRIVEWAY WITH THE SEAT & MIRRORS IN THEIR FINAL POSITION, SO OTHERS COULD GET IN AND SEE IF THEY THOUGHT THEY COULD DRIVE IN THAT POSITION. I HAVE NOT SET THE SET MEMORY, AND WAS VERY CAREFUL TO NOT TOUCH ANYTHING BUT THE 4WD CONTROL WHILE CHANGING DRIVE MODES. AS AN ASIDE, I NOTICED OTHERS OWNERS HAD COMPLAINTS ABOUT THE SEATS. MY 'SAFETY ALERT' SEAT, 'HEATED AND COOLED (PERFORATED)', 'FRONT FULL FEATURE', 'LEATHER APPOINTED BUCKETS' DEVELOPED A SMALL TEAR IN THE LOWER, MIDDLE PORTION OF THE SEAT. I WANTED IT REPLACED, AND OF COURSE, THE FRIENDLY DEALERSHIP STAFF TRIED TO SAY THIS WAS 'NORMAL WEAR AND TEAR'. THIS WAS AT LESS THAN 500 MILES, 350 OF WHICH THE DEALERSHIP PUT ON WHILE DRIVING IT FROM ANOTHER DEALER. THIS TRUCK IS USED FOR PLEASURE ONLY, NOT WORK, NO TOOL POUCHES OR IN POCKETS... IF IT WASN'T SUCH A BAD EXAMPLE OF HOW CUSTOMERS ARE TREATED BY SOME DEALERSHIPS, IT WOULD BE LAUGHABLE. CURRENT MILLAGE: 1,711 MI. *TR
THE REAR SEAT HEAD RESTS ON THE 2014 CHEVY SILVERADO Z71 DOUBLE CAB 1500 TRUCKS DO NOT PROVIDE PROTECTION. THEY DO EXTEND UP SOME BUT NOT ONLY DO THEY NOT STAY IN PLACE WHEN EXTENDED UP, THEY ALSO DO NOT EXTEND UP HIGH ENOUGH FOR EVEN A 5' 8" PERSONS HEAD. THE REST STILL ALLOWS THE PASSENGERS HEAD TO HIT THE REAR WINDOW. WHEN…
Read full complaint
THE REAR SEAT HEAD RESTS ON THE 2014 CHEVY SILVERADO Z71 DOUBLE CAB 1500 TRUCKS DO NOT PROVIDE PROTECTION. THEY DO EXTEND UP SOME BUT NOT ONLY DO THEY NOT STAY IN PLACE WHEN EXTENDED UP, THEY ALSO DO NOT EXTEND UP HIGH ENOUGH FOR EVEN A 5' 8" PERSONS HEAD. THE REST STILL ALLOWS THE PASSENGERS HEAD TO HIT THE REAR WINDOW. WHEN ONE RESTS THEIR HEAD BACK THE REST EASILY GOES DOWN AND DOES NOT LOCK IN PLACE. REAR IMPACTS WOULD DEFINITELY RESULT IN A HEAD INJURY. OTHERS ON VARIOUS CHEVROLET ONLINE FORUMS HAVE NOTICED THE PROBLEM AND WILL NOT LET ADULTS RIDE IN THE REAR DOUBLE CAB AREA OF THE TRUCK. I CAN SEND YOU A VIDEO OF THIS PROBLEM IF YOU LIKE. EMAIL: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
PURCHASED A NEW 2014 CHEVY SILVERADO IN JUNE AND AFTER DRIVING A FEW HUNDRED MILES, I NOTICED THE DRIVERS SEAT WAS NOT VERY COMFORTABLE ON LONG TRIPS. SOON AFTER A NOISE WAS COMING FROM UNDER SEAT. DEALER REPLACED SEAT TRACK BUT WAS NOT INSTALLED PROPERLY AND MY SEAT CUSHION CAME UNATTACHED. DEALER ATTEMPTED TO FIX THE PROBLEM B…
Read full complaint
PURCHASED A NEW 2014 CHEVY SILVERADO IN JUNE AND AFTER DRIVING A FEW HUNDRED MILES, I NOTICED THE DRIVERS SEAT WAS NOT VERY COMFORTABLE ON LONG TRIPS. SOON AFTER A NOISE WAS COMING FROM UNDER SEAT. DEALER REPLACED SEAT TRACK BUT WAS NOT INSTALLED PROPERLY AND MY SEAT CUSHION CAME UNATTACHED. DEALER ATTEMPTED TO FIX THE PROBLEM BUT NOISE IS STILL APPARENT. I HAVE READ OTHER COMPLAINTS ABOUT SEATS BEING UNCOMFORTABLE AND I CAN CONFIRM. WHY IS CHEVROLET PUTTING OUT THIS TYPE OF VEHICLES AND EXPECT PEOPLE TO BUY. IF YOU ARE READING THIS DO NOT BUY A CHEVROLET/GMC TRUCK. SAVE YOUR MONEY!!!!! *TR
PURCHASED MY 2014 CHEVY SILVERADO AT THE END OF JUNE 2014 AND BY JULY 2014 WHILE TRAVELING TO WORK MY TRUCK EXPERIENCE A SEVERE VIBRATION THAT SHOOKED MY ENTIRE INTERIOR AND ESPECIALLY MY CENTER CONSOLE. TOOK MY TRUCK TO TWO LOCAL DEALERSHIPS AND THEY SAY MY TRUCK DRIVES AND HANDLES NORMALLY. AFTER READING OTHER COMPLAINTS BY O…
Read full complaint
PURCHASED MY 2014 CHEVY SILVERADO AT THE END OF JUNE 2014 AND BY JULY 2014 WHILE TRAVELING TO WORK MY TRUCK EXPERIENCE A SEVERE VIBRATION THAT SHOOKED MY ENTIRE INTERIOR AND ESPECIALLY MY CENTER CONSOLE. TOOK MY TRUCK TO TWO LOCAL DEALERSHIPS AND THEY SAY MY TRUCK DRIVES AND HANDLES NORMALLY. AFTER READING OTHER COMPLAINTS BY OTHER OWNERS, I DECIDED TO WRITE MY OWN COMPLAINT. CHEVY CORPORATION NEEDS TO INVESTIGATE THIS MATTER BEFORE ANY TRAGIC INCIDENT HAPPE NS LIKE THE IGNITION SWITCH RECALL THAT INNOCENT PEOPLE DIED AND NOW THEY ARE PAYING MEGA BUCKS. ALSO REQUESTING OTHER OWNERS TO FILE A COMPLAINT SO OTHER TRUCK BUYERS WILL STAY AWAY FROM CHEVROLET AUTOMOBILES ENTIRELY. MY NEXT PURCHASE WILL PROBABLY A FOREIGN BECAUSE I AM HAVING TO MANY PROBLEMS AND NOTHING IS GETTING DONE. THANKS ALOT CHEVY, FROM SOON TO BE EX-CHEVROLET OWNER. *TR
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE DRIVER SEAT WAS NOT STATIONARY AND MOVED AROUND WHILE THE CONTACT OPERATED THE VEHICLE. THE VEHICLE WAS TAKEN TO TWO DIFFERENT AUTHORIZED DEALERS WHO STATED THAT THE SHIMS, CLIPS, AND HOOKS WERE NOT AVAILABLE TO REPAIR THE VEHICLE. THE DEALER AND M…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE DRIVER SEAT WAS NOT STATIONARY AND MOVED AROUND WHILE THE CONTACT OPERATED THE VEHICLE. THE VEHICLE WAS TAKEN TO TWO DIFFERENT AUTHORIZED DEALERS WHO STATED THAT THE SHIMS, CLIPS, AND HOOKS WERE NOT AVAILABLE TO REPAIR THE VEHICLE. THE DEALER AND MANUFACTURER WERE UNABLE TO TELL THE CONTACT, WHEN THE PARTS WOULD BECOME AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 1,000. UPDATED 09/11/14 UPDATED 10/8/14*CN THE CONSUMER STATED AS OF 9/20/2014 THE VEHICLE HAD NOT BEEN REPAIRED. UPDATED 3/23/2015 *JS
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. THE CONTACT STATED THE DRIVER SEAT WAS EXTREMELY UNCOMFORTABLE AND THE PADDING WAS VERY THIN. AS RESULT OF THE PROBLEM, THE CONTACT HAD TO CONSTANTLY MAKE ADJUSTMENTS WHILE TRAVELING. THE VEHICLE WAS NEITHER REPAIRED NOR DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE SAFETY …
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. THE CONTACT STATED THE DRIVER SEAT WAS EXTREMELY UNCOMFORTABLE AND THE PADDING WAS VERY THIN. AS RESULT OF THE PROBLEM, THE CONTACT HAD TO CONSTANTLY MAKE ADJUSTMENTS WHILE TRAVELING. THE VEHICLE WAS NEITHER REPAIRED NOR DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE SAFETY CONCERN AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 6.
MY 2014 CHEVY SILVERADO 1500, LTZ, Z71 STARTED TO HAVE NUMEROUS ISSUES SINCE THIS PAST APRIL. THE TRUCK HAS BEEN IN THE UNETHICAL LANDERS MCCLARTY CHEVROLET IN HUNTSVILLE, ALABAMA SEVEN TIMES WITH ONLY THE SMALLEST OF THE ISSUES BEING FIXED. 1ST ISSUE WAS THE DRIVER SIDE SEAT MOVED WHEN TURNING LEFT OR RIGHT. THE DEALER'S SERVI…
Read full complaint
MY 2014 CHEVY SILVERADO 1500, LTZ, Z71 STARTED TO HAVE NUMEROUS ISSUES SINCE THIS PAST APRIL. THE TRUCK HAS BEEN IN THE UNETHICAL LANDERS MCCLARTY CHEVROLET IN HUNTSVILLE, ALABAMA SEVEN TIMES WITH ONLY THE SMALLEST OF THE ISSUES BEING FIXED. 1ST ISSUE WAS THE DRIVER SIDE SEAT MOVED WHEN TURNING LEFT OR RIGHT. THE DEALER'S SERVICE DEPARTMENT INFORMED ME THERE WAS NO FIX AND THAT THE SEAT WAS WITHIN MANUFACTURES SPECS. THE SEAT MOVED TO THE POINT THAT THE VENTILATED SEAT COOLER PLUG DISCONNECTED. THE SERVICE DEPT EVENTUALLY "FIXED" THE SEAT AND RECONNECTED THE PLUG. LASTLY THE ISSUE I CANNOT GET RESOLVED THROUGH GM CORPORATE, DEALER SERVICE DEPARTMENT OR THE REGIONAL GM MANAGER. MY TRUCK "SHAKES" FROM SPEEDS OF 65 MPH AND GREATER. THE SERVICE DEPT FIRST TOLD ME I NEEDED AN ALIGNMENT AND HAVE THE TIRE ROTATED AND BALANCED. THE SHAKE STILL CONTINUED, SO I COMPLAINED AGAIN TO THE SERVICE DEPT. THIS TIME I WAS TOLD THAT TWO TIRES WHERE "BAD" DO TO ROAD FORCE AND REPLACED THEM. THE TRUCK STILL SHAKES LIKE A STRIPPER SO I EMAILED THE CEO OF GM ON 11 JULY AND ASSIGNED AN EXECUTIVE LIAISON TO WORK THE ISSUE. SINCE THEN MY TRUCK HAS BEEN IN THE SERVICE DEPARTMENT TWICE. EACH TIME I WAS CALLED A LIAR INDIRECTLY BY THE SERVICE DEPARTMENT MANAGER "[XXX]" AND THE DISTRICT MANAGER "[XXX]" AFTER THEY TEST DROVE THE TRUCK AND COULDN'T REPLICATE THE COMPLAINT. I HAD THE SERVICE DEPT FOREMAN "[XXX]" RIDE ALONG WITH ME AS I DROVE THE TRUCK AND POINTED OUT THE "VERY" NOTICEABLE SHAKE AT HIGH WAY SPEEDS. AFTER NUMEROUS PHONE CALLS TO THE SERVICE DEPT, GM CORPORATE, I FOUND OUT THAT THE SERVICE DEPT CAN UTILIZE A VIBRATION ANALYZER ON THE TRUCK. THIS HAS NOT TAKEN PLACE OR EVEN CONSIDERED. I CONTINUE TO DRIVE THE TRUCK WITH THE SHAKING BECOMING WORSE WITH EACH MILE. JUST LIKE THE IGNITION SWITCH PROBLEM, GM DOWN PLAYS THE ISSUE AND LETS THE PROBLEM COMPOUND. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
I PURCHASED THE 2014 SILVERADO 1500 WHILE IT WAS RAINING. TEST DRIVE WAS FINE, BUT THE SALES PERSON ALREADY HAD THE VEHICLE RUNNING WITH THE DEFROSTER AND WIPERS ON. DROVE HOME (2 MILES) AND PARKED. TURNED ON THE FAN KNOB ( STANDARD WITH A/C MODEL) AND THE A/C TURNED ON, THIS OCCURRED NEARLY EVERY TIME I TURNED IT ON AND ASKED T…
Read full complaint
I PURCHASED THE 2014 SILVERADO 1500 WHILE IT WAS RAINING. TEST DRIVE WAS FINE, BUT THE SALES PERSON ALREADY HAD THE VEHICLE RUNNING WITH THE DEFROSTER AND WIPERS ON. DROVE HOME (2 MILES) AND PARKED. TURNED ON THE FAN KNOB ( STANDARD WITH A/C MODEL) AND THE A/C TURNED ON, THIS OCCURRED NEARLY EVERY TIME I TURNED IT ON AND ASKED THE DEALER SERVICE CENTER ABOUT IT. I WAS TOLD I AM PROBABLY HITTING IT WITH MY KNUCKLES. I SINCE TRIED ONLY WHILE PINCHING THE KNOB TO AVOID THIS AND THE A/C STILL NEARLY TURNS ON EVERY TIME. ALSO WHEN THE TRUCK SITS A WHILE THE FIRST START IS A HARD ONE BUT AFTER RUNNING AND WARMED UP IT WILL BE FINE TO START. NOT SURE IF THE TRUCK BATTERY NEEDS A CHARGE AFTER SITTING ON THE LOT, I COULD ALSO SMELL A RUBBER BURNING ODOR OUTSIDE AND THROUGH THE VENTS, THOUGHT IT WAS BECAUSE IT WAS NEW BUT THEN I SEEN THERE WAS A RECALL 3 DAYS PRIOR. WHEN I TRIED ANCHORING MY SONS CHILD SEAT I FOUND NO SEAT ANCHORS IN THE CENTER REAR SEAT AND ONLY THE ENDS. I WORRY ABOUT HIS SEAT NEAR THE DOOR IF THERE IS A SIDE CRASH. LASTLY, WHY ISN'T THERE REAR SENSORS AT A MINIMUM A MANDATORY ON TRUCKS YET. CAMERAS CAN STILL BE OFFERED AS A OPTION BUT SENSORS SHOULD BE MANDATORY! *TR
Official recalls
621V245000 · Seat Belts:front
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
19V761000 · Electronic Stability Control (esc); Service Brakes; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
19V645000 · Service Brakes, Hydraulic:power Assist:vacuum
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
17V437000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
17V414000 · Steering:electric Power Assist System
Jun 29, 2017
General Motors LLC (GM) is recalling certain 2014 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The vehicles may have a temporary loss of electric power steering (EPS) assist, especially during low-speed turning maneuvers.
Consequence & remedy
Consequence: If EPS assist is lost and then returns, the driver might lose temporary control of the steering wheel, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began on August 10, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-432-8782. GM's number for this recall is 17276.
16V651000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.