NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
191 reportsClear category filter72,950 miles · Apr 4, 2019
Electrical SystemEngineSteering
ON 4/2/2019 WHILE TRAVELING AT 45 MPH, SLOWED TO MAKE LEFT TURN. WHILE MIDWAY THROUGH INTERSECTION, ENGINE DIED, DASH LIGHTS WENT OUT, POWER STEERING AND BRAKES GONE. WITHIN SECONDS EVERYTHING POWERED BACK UP AND ENGINE RESUMED AS IF NOTHING HAPPENED. WARNING INDICATORS WORDS FLASHED BRIEFLY. I CAUGHT "STABILITRACK". I DROV…
Read full complaint
ON 4/2/2019 WHILE TRAVELING AT 45 MPH, SLOWED TO MAKE LEFT TURN. WHILE MIDWAY THROUGH INTERSECTION, ENGINE DIED, DASH LIGHTS WENT OUT, POWER STEERING AND BRAKES GONE. WITHIN SECONDS EVERYTHING POWERED BACK UP AND ENGINE RESUMED AS IF NOTHING HAPPENED. WARNING INDICATORS WORDS FLASHED BRIEFLY. I CAUGHT "STABILITRACK". I DROVE FOR ANOTHER MILE AND AS I WAS ENTERING DRIVEWAY ABOUT 5 MPH AND WHILE DRIVING STRAIGHT, ENGINE AND DASH LIGHTS WENT OFF AGAIN AND RESTARTED AGAIN. PRIOR TO ALL THIS HEADLIGHTS WERE FLICKERING AND THERE WAS A LITTLE DEADENING IN THE POWER STEERING. TRUCK HAD 72,950 MILES. I CHECKED THE GROUNDING POINTS AND CLEARED OUT THE DEADENING MATERIAL THAT SLIGHTLY IMPEDED IT. NOT SURE THIS WILL HELP. THIS IS ACTUALLY THE SECOND TIME THIS HAS HAPPENED. ON 6/22/18 AT 64,888 MILES, I HAD A SIMILAR PROBLEM. AT THAT TIME TOOK IT IN TO SHOP. THEY TIGHTENED THE GROUNDING BOLTS (G218) AND CLEANED THE BATTERY TERMINALS. I GUESS IT HELPED UNTIL RECENTLY. IT COST $180.
NHTSA ODI #11193966
51,670 miles · Mar 30, 2019
Engine
TRUCK UNDER 52,000 MILES, HAD ALL KNOWN RECALLS (6) PERFORMED AT CLIFF ANSCHUETZ. ALL MAINTENANCE PERFORMED WITHIN MANUFACTURE SPECIFIED GUIDE LINES HERE ALSO. TRUCK NEVER DISPLAYED ERROR CODE OR SERVICE ENGINE LIGHT SINCE PURCHASED NEW. DRIVING HOME FROM WORK 45 MILES AN HOUR MARCH 6, 2019, ENGINE MESSAGE DISPLAYED WITH BEEP TO…
Read full complaint
TRUCK UNDER 52,000 MILES, HAD ALL KNOWN RECALLS (6) PERFORMED AT CLIFF ANSCHUETZ. ALL MAINTENANCE PERFORMED WITHIN MANUFACTURE SPECIFIED GUIDE LINES HERE ALSO. TRUCK NEVER DISPLAYED ERROR CODE OR SERVICE ENGINE LIGHT SINCE PURCHASED NEW. DRIVING HOME FROM WORK 45 MILES AN HOUR MARCH 6, 2019, ENGINE MESSAGE DISPLAYED WITH BEEP TONE: OIL PRESSURE LOW TURN OFF ENGINE. I IMMEDIATELY PULLED OFF, LET TRUCK SIT FOR 5 MINUTES. NO OIL OR FLUIDS WHERE LEAKING. OIL APPEARED NORMAL AND AT PROPER LEVEL, DID NOT SMELL BURNED. STARTED ENGINE ERROR CODE WAS GONE, DROVE 1 MILES TO AUTO REPAIR SHOP. SAME ERROR MESSAGE APPEARED AFTER GOING 100'. AUTO REPAIR SHOP GAVE ME BAD NEWS 3 CODES: 1) P0324 KNOCK SENSOR, 2) P0521 ENGINE OIL PRESSURE PERFORMANCE, 3) P06DD ENGINE OIL PRESSURE CONTROL SOLENOID VALVE STUCK OFF. WENT TO FELDMAN CHEVROLET OF HIGHLAND, TECHNICIAN TOLD ME THIS SHOULD BE COVERED UNDER WARRANTY, LAKESIDE TOWING DELIVERED MY TRUCK THERE. FELDMAN WILL NOT COVER REPAIRS STATING OUT OF WARRANTY. WILL GIVE ME $2000 DOLLARS OFF ON CERTI REBUILT MOTOR, MY COST $7,200 W/12 MONTH WARRANTY. NOT ACCEPTABLE. SALESMAN THERE OFFERED ME $8000 AS TRADE IN. WORKING WITH GM COMPLAINT DEPARTMENT, THEY HAVE BEEN GIVEN ALL INFORMATION. BEEN NICE BUT SEEMS LIKE I AM CAUGHT IN MIDDLE BETWEEN HER AND SERVICE MANAGER AT FELDMAN. AS OF, 4/30/2019, I AM AWAITING A CALL BACK FROM GM. THIS IS A KNOWN DEFECT IN THIS ENGINE DESCRIBED IN SO MANY BLOGS! GOOGLE 2014 CHEVY SILVERADO 1500 ENGINE FAILURE. VACUUM PUMP ONLY WARRANTIED TO 36K, 2016-17 TRUCKS ONLY HAVE A 60K POWERTRAIN WARRANTY. TELLS YOU SOMETHING, GM DROPPED POWERTRAIN WARRANTY DOWN TO 60K FOR 2016-17. THIS IS NOT COMMON PROBLEM, ONLY A MATTER OF WHEN THE VACUUM PUMP FAILS. PUMP FAILS, STARTS PUMPING METAL DEBRIS BACK INTO OIL/LUBRICATION SYSTEM TAKING OUT THE OIL PUMP THEN THE ENGINE. I OWE FELDMAN $970 FOR TEAR DOWN AND FOR REMOVING OIL PAN!
NHTSA ODI #11192635
30,000 miles · Mar 7, 2019
EnginePower Train
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE DRIVING AND MAKING A RIGHT TURN, THE VEHICLE STALLED AND RESTARTED IMMEDIATELY. ALSO, WHILE DRIVING 10 MPH, THE VEHICLE TURNED OFF AND DID NOT RESTART FOR AT LEAST THIRTY MINUTES. RYAN CHEVROLET (1101 OLIVER RD, MONROE, LA 71201) WAS CONTACTED AND STATED THAT THE CONTAC…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE DRIVING AND MAKING A RIGHT TURN, THE VEHICLE STALLED AND RESTARTED IMMEDIATELY. ALSO, WHILE DRIVING 10 MPH, THE VEHICLE TURNED OFF AND DID NOT RESTART FOR AT LEAST THIRTY MINUTES. RYAN CHEVROLET (1101 OLIVER RD, MONROE, LA 71201) WAS CONTACTED AND STATED THAT THE CONTACT COULD BRING IN THE VEHICLE TO BE DIAGNOSED FOR A FEE. THE MANUFACTURER WAS ALSO CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 30,000.*BF . CONSUMER STATED VEHICLE HAS ISSUE WITH ENGINE. VEHICLE HAS SHUT DOWN SEVERAL TIMES WHILE IN HEAVY TRAFFIC AND TOOK TWENTY TO THIRTY MINUTES FOR THE ENGINE TO START BACK UP.*JB
NHTSA ODI #11184833
58,473 miles · Jan 28, 2019
Electrical SystemElectronic Stability Control (esc)Engine
VEHICLE SHUTS DOWN WHILE DRIVING IT HAS DONE THIS 4 TIMES TO WHICH I LOSE ABILITY TO CONTROL STEERING AND I HAVE TO BRAKE AND TRY TO REACH SIDE OF STREET AS SOON POSSIBLE I HAVE TAKEN IT TO DEALER EVERY TIME AND THEY DO NOT GIVE ME A CAUSE OF WHY THIS IS HAPPENING NOR DO THEY FIX IT. I HAVE BEEN CHARGED EACH TIME I HAVE TAKEN TH…
Read full complaint
VEHICLE SHUTS DOWN WHILE DRIVING IT HAS DONE THIS 4 TIMES TO WHICH I LOSE ABILITY TO CONTROL STEERING AND I HAVE TO BRAKE AND TRY TO REACH SIDE OF STREET AS SOON POSSIBLE I HAVE TAKEN IT TO DEALER EVERY TIME AND THEY DO NOT GIVE ME A CAUSE OF WHY THIS IS HAPPENING NOR DO THEY FIX IT. I HAVE BEEN CHARGED EACH TIME I HAVE TAKEN THIS VEHICLE IN TO VERIFY WHY IS THIS HAPPENING. I HAD A LETTTER SENT TO ME BY A LAW FIRM LAW OFFICE OF RONALD J BOLZ, PLLC. ADDRESS 30928 FORD ROAD GARDEN CITY MICHIGAN, 48135 PHONE NUMBER 1-888-453-6667 FAX NUMBER 1-888-334-8333 WEB ADDRESS WWW.LEMONAUTO.COM EMAIL ADDRESS RBOLZ@LEMON AUTO.COM. MANUFACTURE DENIED ANY CLAIM. I HAVE DONE MY RESEARCH ON THIS VEHICLE AND THERE ARE MANY ISSUES AND COMPLAINTS ON THIS VEHICLE AND THIS ISSUE MENTIONED ABOVE. I AM AFRAID TO USE VEHICLE TO WHERE I LOSE CONTROL AND CAUSE AND ACCIDENT. SEE DOCUMENTATION ON DATES OF OCCURENCE
NHTSA ODI #11172447
Mileage unknown · Jan 7, 2019
Electrical SystemEngineSteering
MY STEERING WHEEL IS HARD TO MOVE AND THE A/C DOES NOT WORK
NHTSA ODI #11164961
70,000 miles · Jan 1, 2019
EnginePower Train
IN LESS THAN A YEAR THAT I HAVE OWNED IT THE WELDS ON THE RADIATOR CRACKED OPEN THE WELDS CRACKED OPEN ON THE AC CONDENSER THE TRANSMISSION HAD TO BE REBUILT FROM SOMETHING EXPLODING INSIDE AND SHARDING METAL EVERYWHERE AND I HAVE ALSO HAD MY VACUUM PUMP GO OUT WHICH HAS SHOT METAL INTO MY ENGINE AND ALMOST CAUSED A CRASH WHEN…
Read full complaint
IN LESS THAN A YEAR THAT I HAVE OWNED IT THE WELDS ON THE RADIATOR CRACKED OPEN THE WELDS CRACKED OPEN ON THE AC CONDENSER THE TRANSMISSION HAD TO BE REBUILT FROM SOMETHING EXPLODING INSIDE AND SHARDING METAL EVERYWHERE AND I HAVE ALSO HAD MY VACUUM PUMP GO OUT WHICH HAS SHOT METAL INTO MY ENGINE AND ALMOST CAUSED A CRASH WHEN IT FIRST STARTED GOING OUT I DIDN'T REALIZE WHAT IT WAS AND ALMOST CRASHED A FEW TIMES ON THE WAY HOME .
NHTSA ODI #11164407
103,446 miles · Dec 20, 2018
EngineFire
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. AFTER STARTING THE VEHICLE, A TAPPING NOISE WAS PRESENT COMING FROM THE ENGINE COMPARTMENT AND WHITE SMOKE APPEARED FROM THE EXHAUST. THE VEHICLE WAS TAKEN TO BILL NAVARRE CHEVROLET (1620 BEGLIS PKWY, SULPHUR, LA 70663) WHERE IT WAS DIAGNOSED THAT THE ENGINE WAS FAULTY AND NE…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. AFTER STARTING THE VEHICLE, A TAPPING NOISE WAS PRESENT COMING FROM THE ENGINE COMPARTMENT AND WHITE SMOKE APPEARED FROM THE EXHAUST. THE VEHICLE WAS TAKEN TO BILL NAVARRE CHEVROLET (1620 BEGLIS PKWY, SULPHUR, LA 70663) WHERE IT WAS DIAGNOSED THAT THE ENGINE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,446.
NHTSA ODI #11162680
90,000 miles · Dec 17, 2018
Engine
THE VEHICLE SUFFERED INTERMITTENT FAILURES TO START (ENGINE WOULD NOT CRANK). THE INITIAL ATTEMPT TO REPAIR THE ISSUE BY THE DEALER WAS TO REPLACE THE BATTERY AND NEGATIVE BATTERY CABLE. THE BATTERY BEING REPLACED WAS LESS THAN 3 YEARS OLD AND IT WAS THE SECOND BATTERY THE DEALER HAD REPLACED IN LESS THAN 5 YEARS. THE INITIAL …
Read full complaint
THE VEHICLE SUFFERED INTERMITTENT FAILURES TO START (ENGINE WOULD NOT CRANK). THE INITIAL ATTEMPT TO REPAIR THE ISSUE BY THE DEALER WAS TO REPLACE THE BATTERY AND NEGATIVE BATTERY CABLE. THE BATTERY BEING REPLACED WAS LESS THAN 3 YEARS OLD AND IT WAS THE SECOND BATTERY THE DEALER HAD REPLACED IN LESS THAN 5 YEARS. THE INITIAL REPAIRS FAILED. ULTIMATELY, THE PROBLEM WAS A FAULTY STARTER MOTOR. A CHECK OF THE PART NUMBER OF THE FACTORY STARTER MOTOR THAT HAD BEEN REMOVED (SEE ATTACHED PHOTO) INDICATES IT IS COMPATIBLE WITH 2014 CHEVROLET SILVERADO/GMC SIERRA 1500 WITH THE 4.3L V6 ENGINE. HOWEVER, THIS VEHICLE HAS THE 5.3L V8 ENGINE. EITHER THE INCORRECT PART WAS INSTALLED AT THE FACTORY OR GM DETERMINED IT IS NOT APPROPRIATE FOR THE 5.3L V8 ENGINE AND DISCONTINUED USING IT FOR THIS MODEL. REGARDLESS, GM NEVER MADE ANY NOTIFICATION OF THE ISSUE.
NHTSA ODI #11161959
64,500 miles · Nov 29, 2018
Engine
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY SHUT OFF. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE CONTACT INDICATED THAT THE FAILURE OCCURRED ON FIVE SEPARATE OCCASIONS. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEA…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY SHUT OFF. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE CONTACT INDICATED THAT THE FAILURE OCCURRED ON FIVE SEPARATE OCCASIONS. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER (MIKE RICKENBACH, 10 UNIVERSITY PKWY, OKATIE, SC 29909) WERE NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 64,500.
NHTSA ODI #11154800
45,217 miles · Nov 8, 2018
EngineSteering
RECALL # 17276 FOR LOW VOLTAGE STEERING. OUR VEHICLE HAS AN EXTREMELY DANGEROUS SAFETY PROBLEM. WHEN THE STEERING WHEEL IS TURNED QUICKLY, THE STEERING IS EXTREMELY STIFF, THE HEADLIGHTS DIM, AND THE ENGINE SHUTS OFF. THIS IS LIFE THREATENING WHEN MAKING A TURN ACROSS ONCOMING TRAFFIC LANES. WE TOOK THE TRUCK TO A CHEVROLET …
Read full complaint
RECALL # 17276 FOR LOW VOLTAGE STEERING. OUR VEHICLE HAS AN EXTREMELY DANGEROUS SAFETY PROBLEM. WHEN THE STEERING WHEEL IS TURNED QUICKLY, THE STEERING IS EXTREMELY STIFF, THE HEADLIGHTS DIM, AND THE ENGINE SHUTS OFF. THIS IS LIFE THREATENING WHEN MAKING A TURN ACROSS ONCOMING TRAFFIC LANES. WE TOOK THE TRUCK TO A CHEVROLET DEALERSHIP FOR THE RECALL # 17276 FOR LOW VOLTAGE STEERING. THEY REPROGRAMMED THE STEERING SYSTEM. THIS DID NOT RESOLVE THE PROBLEM. WE HAVE TAKEN THE TRUCK BACK TO THE DEALERSHIP 3 ADDITIONAL TIMES NOW FOR THIS ISSUE. THE DEALERSHIP HAS OPENED A CASE WITH GM, AND GM HAS RECOMMENDED MANY THINGS, ALL AT MY COST THAT HAVE NOT RESOLVED THE SAFETY PROBLEM. I FEEL THAT GM IS USING ME AS A CRASH TEST DUMMY. I SENT AN E MAIL REQUEST TO GM DOCUMENTING THIS ISSUE. GM REPLIED THAT THEY WILL ONLY WORK BY TELEPHONE THEY ASK TO RECORD THE CALL BUT WILL NOT ALLOW THE CUSTOMER TO DO THE SAME. THEY HAVE REFUSED TO READ OR REPLY TO MY DOCUMENTED REQUEST FOR HELP. PLEASE CONTACT ME FOR ANY DETAILS OR QUESTIONS, I DESPERATELY NEED HELP ON THIS. THANK YOU, *TR
NHTSA ODI #11150184
Official recalls
6Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Jun 29, 2017
General Motors LLC (GM) is recalling certain 2014 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The vehicles may have a temporary loss of electric power steering (EPS) assist, especially during low-speed turning maneuvers.
Consequence & remedy
Consequence: If EPS assist is lost and then returns, the driver might lose temporary control of the steering wheel, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began on August 10, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-432-8782. GM's number for this recall is 17276.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration