NHTSA owner reports · September 18, 2026 snapshot.
Electronic Stability Control (esc) complaints
161 reportsClear category filter100,000 miles · Sep 23, 2020
Electrical SystemElectronic Stability Control (esc)Steering
IT IS TOO BAD I CAN NOT CHECK ALL THAT APPLY! I HAVE THE SAME PROBLEMS AS OTHER PEOPLE LOOSING STEERING AND GETTING THE STABILTRACK MESSAGE AT LOW SPEEDS. WHEN THIS HAPPENS YOU LOOSE ALL POWER AND THE LIGHTS ALL DIM. I ALSO HAVE BEGUN TO NOTICED THAT WHILE DRIVING DOWN THE HIGHWAY IN CRUISE CONTROL ANY TURN OF THE VEHICLE WIT…
Read full complaint
IT IS TOO BAD I CAN NOT CHECK ALL THAT APPLY! I HAVE THE SAME PROBLEMS AS OTHER PEOPLE LOOSING STEERING AND GETTING THE STABILTRACK MESSAGE AT LOW SPEEDS. WHEN THIS HAPPENS YOU LOOSE ALL POWER AND THE LIGHTS ALL DIM. I ALSO HAVE BEGUN TO NOTICED THAT WHILE DRIVING DOWN THE HIGHWAY IN CRUISE CONTROL ANY TURN OF THE VEHICLE WITH THE STEERING WHEEL KILLS THE CRUISE CONTROL. I ALSO HAVE THE TRAILER, BREAK SYSTEM MESSAGE FLASH RANDOMLY AT LOW SPEEDS WITHOUT A TRAILER OR PULLING ANYTHING THIS IS JUST ANNOYING THE OTHER PROBLEMS ARE MAJOR SAFETY ISSUES!!! I HAVE HAD THIS TRUCK IN THE DEALERSHIP SEVERAL TIMES HAD VERY POOR CUSTOMER SERVICE AND WASN'T EVEN TOLD ABOUT THE RECALLS THAT WERE ON IT. HOWEVER, I DON'T SEEM TO SEE ANY RECALLS FOR THE PROBLEMS THAT I HAVE AND THAT THOUSANDS OF OTHER PEOPLE ARE DESCRIBING WITH THE ELECTRICAL ISSUE AND STABILTRACK AT LOW SPEEDS. I ALSO WANT TO ADD THAT THE REAR SEATBELTS IN THIS VEHICLE ARE COMPLETE JUNK.
NHTSA ODI #11360684
Mileage unknown · Sep 17, 2020
Electrical SystemElectronic Stability Control (esc)Steering
NUMEROUS INCIDENTS WHILE DRIVING AND MAKING A TURN INTO A PUBLIC PARKING LOT FROM A 55 MPH HWY, ALL POWER WENT OFF, ENGINE DIED AND JUST BEFORE THIS STEERING WAS VERY HARD TO TURN, STABIL TRACK LIGHT HAS BEEN COMING ON. GM DEALER STATED MAYBE BAD BATTERY, I HAD THE NEW BATTERY CHECKED AND IT IS GOOD
NHTSA ODI #11355599
130,000 miles · Aug 27, 2020
Electrical SystemElectronic Stability Control (esc)Steering
150 MILES AFTER REGULAR SERVICE OF ENGINE LIGHT/ABS/AND STABILTRAK LIGHTS BEING ON, AND AN OIL CHANGE, THE TRUCK STALLED (LUCKILY I WAS IN MY OWN DRIVEWAY). SHORTLY AFTER, THE ENGINE LIGHT, FOLLOWED BY ABS LIGHT CAME ON. SUDDENLY THE SPEEDOMETER GAUGE ACTED WILDLY, THERE WAS A VERY HARD SHIFT. I PUT IT ON CRUISE CONTROL JUST TO …
Read full complaint
150 MILES AFTER REGULAR SERVICE OF ENGINE LIGHT/ABS/AND STABILTRAK LIGHTS BEING ON, AND AN OIL CHANGE, THE TRUCK STALLED (LUCKILY I WAS IN MY OWN DRIVEWAY). SHORTLY AFTER, THE ENGINE LIGHT, FOLLOWED BY ABS LIGHT CAME ON. SUDDENLY THE SPEEDOMETER GAUGE ACTED WILDLY, THERE WAS A VERY HARD SHIFT. I PUT IT ON CRUISE CONTROL JUST TO HELP THE ENGINE QUIT HARD SHIFTING....CC CANCELLED ITSELF OUT. EVERYTHING SETS BACK TO NORMAL FOR A MINUTE OR LESS AND IT ALL HAPPENS AGAIN, THIS TIME TAKING AWAY POWER STEERING AND A LOUDER "HARD SHIFT". IN THE MEAN TIME, EVERY WARNING I THINK THERE IS WOULD POP UP...."STABILTRAK OFF, STARRING ASSIST REDUCED...ETC". THIS JUST CONTINUES AND SEEMS TO GET MORE AGGRESSIVE, MORE FREQUENT...INCLUDING RESETTING TO NORMAL BRIEFLY EACH TIME. SCHUMACHER BUICK/GM/CHEVY SAID IT COULD BE TCM, OR ECM, OR ANOTHER I CAN'T RECALL. UNHAPPY WITH LACK OF KNOWLEDGE OF ISSUE, AND A "LET'S TRY THIS THEN THIS THEN THIS..", IT HAS PERPLEXED NOT ONE BUT TWO VERY ACCREDITED MECHANIC TEAMS. THE TRUCK HAS 130,000 MILES, AND WAS SERVICED AS IT SHOULD HAVE BEEN BY THE CHEVY DEALER SINCE IACQUIRED IT NEW. IT NEVER HAD ANY SIMILAR ISSUE UNTIL JUST AFTER ITS MOST RECENT MAINTENANCE. THANKFULLY THIS ALL OCCURRED WITHIN MILES OF MY HOME, AS THE ISSUE IS MOST DEFINITELY A THREAT TO ANY HOPES OF SAFETY. TOWING IT, IS THE ONLY WAY TO SAFELY MOVE THAT VEHICLE AFTER EXPERIENCING THE ISSUES.
NHTSA ODI #11351639
84,000 miles · Aug 21, 2020
Electronic Stability Control (esc)Steering
I GOT A STABILITRAK FAILURE CHIME AND MESSAGE WITH A REDUCED STEERING ASSIST MESSAGE AND I LOST MY POWER ASSIST FOR A SECOND THEN IT CAME BACK. I WAS FORTUNATE THAT IT WAS JUST MYSELF IN THE TRUCK GOING SLOW AND PULLING INTO A PARKING LOT. I'D HATE TO THINK OF MY WIFE BEHIND THE WHEEL GOING DOWN THE FREEWAY WITH MY GRAND KIDS IN…
Read full complaint
I GOT A STABILITRAK FAILURE CHIME AND MESSAGE WITH A REDUCED STEERING ASSIST MESSAGE AND I LOST MY POWER ASSIST FOR A SECOND THEN IT CAME BACK. I WAS FORTUNATE THAT IT WAS JUST MYSELF IN THE TRUCK GOING SLOW AND PULLING INTO A PARKING LOT. I'D HATE TO THINK OF MY WIFE BEHIND THE WHEEL GOING DOWN THE FREEWAY WITH MY GRAND KIDS INSIDE.
NHTSA ODI #11350580
125,000 miles · Aug 20, 2020
Electrical SystemElectronic Stability Control (esc)SteeringInjury
STARTED MAKING A TURN AND THE TRUCK INSTANTLY SHUT OFF LEADING TO POWER STEERING LOSS CAUSING ME TO END UP IN THE OPPOSING LANE ALMOST HITTING TWO CHILDREN AND THEIR FATHER ON BIKES. FATHER DIDN'T HAVE MUCH PATIENCE WITH ME TRYING TO EXPLAIN THAT IT WAS A PROBLEM WITH THE TRUCK... FIX THIS ISSUE OR ELSE IT WILL BECOME A HUGE LIA…
Read full complaint
STARTED MAKING A TURN AND THE TRUCK INSTANTLY SHUT OFF LEADING TO POWER STEERING LOSS CAUSING ME TO END UP IN THE OPPOSING LANE ALMOST HITTING TWO CHILDREN AND THEIR FATHER ON BIKES. FATHER DIDN'T HAVE MUCH PATIENCE WITH ME TRYING TO EXPLAIN THAT IT WAS A PROBLEM WITH THE TRUCK... FIX THIS ISSUE OR ELSE IT WILL BECOME A HUGE LIABILITY. BUY BACK ALL OF THESE TRUCKS AND CRUSH THEM.
NHTSA ODI #11350446
67,111 miles · Aug 18, 2020
Electrical SystemElectronic Stability Control (esc)Steering
WHILE DRIVING THROUGH A PUBLIC PARKING LOT, AT A SLOW TURN THE TRUCK STOPPED DEAD. NO POWER, BARELY WAS ABLE TO STOP WITHOUT HITTING PARKED VEHICLES. TO MAKE IT EVEN MORE DANGEROUS THAN IT ALREADY WAS, ANOTHER CAR ALMOST HIT ME BECAUSE OF MY SUDDEN STOP. I WAS THEN TRAPPED IN MY PICKUP. WINDOWS AND DOORS WOULD NOT OPEN. NO RESP…
Read full complaint
WHILE DRIVING THROUGH A PUBLIC PARKING LOT, AT A SLOW TURN THE TRUCK STOPPED DEAD. NO POWER, BARELY WAS ABLE TO STOP WITHOUT HITTING PARKED VEHICLES. TO MAKE IT EVEN MORE DANGEROUS THAN IT ALREADY WAS, ANOTHER CAR ALMOST HIT ME BECAUSE OF MY SUDDEN STOP. I WAS THEN TRAPPED IN MY PICKUP. WINDOWS AND DOORS WOULD NOT OPEN. NO RESPONSE FROM TURNING THE KEY. THIS IS THE SECOND TIME ITS HAPPENED AND BOTH WERE AT LOW SPEEDS. THE FIRST TIME I THOUGHT IT WAS MY ERROR. I LOOKED IT UP ON SOCIAL MEDIA AND FOUND MANY OTHERS HAD THE SAME PROBLEM. SOME PEOPLE SAID NO RECALL ON SUCH A 'COMMON' AND UNSAFE PROBLEM, ANOTHER SAID THERE WAS A RECALL OPEN. I WAS TOLD BY GM HEADQUARTERS NO RECALL. TOLD BY SERVICE MGR AT THE DEALERSHIP, TOLD ME THERE IS A RECALL ISSUED. ONLY AFTER I BROUGHT IT TO THE DEALERSHIP, THEY TELL ME IT'LL COST ME $364. I ASKED ABOUT WHAT HE TOLD ME ONLY 3 DAYS EARLIER OF THE RECALL, HE THEN DENIED IT. WITH THE SEVERITY OF THE PROBLEM AND THE NUMBERS OF PERSONS WHO COMPLAINED, I WOULD THINK THIS SHOULD BE AT CHEVY'S EXPENSE. I WILL BE TAKING THE TRUCK ON VACATION THE END OF THE MONTH. IF SOMETHING SHOULD HAPPEN, I'VE INSTRUCTED OUR TWO CHILDREN TO SECURE A GOOD LAWYER AND OPEN A WRONGFUL DEATH/INJURY SUIT. I WILL HAVE DOCUMENTATION OF THE INFORMATION I REVIEWED THROUGH SOCIAL MEDIA COMMENTS ALONG WITH THIS COMPLAINT AND THE REPAIRS BY THIS 'CERTIFIED' DEALERSHIP AT THEIR READY.
NHTSA ODI #11350095
10 miles · Aug 17, 2020
Electrical SystemElectronic Stability Control (esc)Steering
LOSS OF POWER TO VEHICLE WHEN MAKING TURNS AT LOW SPEEDS ON CITY ROADS, IN PARKING LOTS, AND ON AND OFF HIGHWAYS, YOU HAVE TO PLACE VEHICLE IN PARK AND TURN BACK ON. STEERING ASSIST AND STABILITRAK HAS BEEN BECOMING DISABLED ON A REGULAR BASIS ALONG WITH THE STEERING WHEEL BEING JERKED OUT OF MY HANDS WHILE MAKING TURNS ON CITY …
Read full complaint
LOSS OF POWER TO VEHICLE WHEN MAKING TURNS AT LOW SPEEDS ON CITY ROADS, IN PARKING LOTS, AND ON AND OFF HIGHWAYS, YOU HAVE TO PLACE VEHICLE IN PARK AND TURN BACK ON. STEERING ASSIST AND STABILITRAK HAS BEEN BECOMING DISABLED ON A REGULAR BASIS ALONG WITH THE STEERING WHEEL BEING JERKED OUT OF MY HANDS WHILE MAKING TURNS ON CITY STREETS, IN PARKING LOTS, AND ON AND OFF THE HIGHWAY. SERVICE STABILITRAK AND STEERING ASSIST MESSAGES ARE DISPLAYED DURING THESE TIME HOWEVER DO NOT LEAVE A CHECK ENGINE LIGHT NO TO BE SCANNED. GM DEALER STATES THEY ARE NOT ABLE TO DUPLICATE THE ISSUE AND ARE NOT ABLE TO FIX IT. THIS IS A SAFETY CONCERN FOR ME AND OTHER DRIVERS ON THE ROAD.
NHTSA ODI #11349845
86,191 miles · Aug 16, 2020
Electronic Stability Control (esc)Steering
WHILE DRIVING IN REVERSE I WILL LOSE POWER STEERING AND STABILITY CONTROL WARNING COMES ON. THIS HAS BEEN HAPPENING FOR MONTHS NOW. TODAY WHILE DRIVING WHEN I PUT MY BLINKER ON THE STABILITY CONTROL WARNING WENT ON MY LIGHTS DIMMED AND TRUCK WAS SHUTTING OFF BUT THEN CAME BACK ON. WHEN TURNING THE STABILITY CONTROL CAME ON AND M…
Read full complaint
WHILE DRIVING IN REVERSE I WILL LOSE POWER STEERING AND STABILITY CONTROL WARNING COMES ON. THIS HAS BEEN HAPPENING FOR MONTHS NOW. TODAY WHILE DRIVING WHEN I PUT MY BLINKER ON THE STABILITY CONTROL WARNING WENT ON MY LIGHTS DIMMED AND TRUCK WAS SHUTTING OFF BUT THEN CAME BACK ON. WHEN TURNING THE STABILITY CONTROL CAME ON AND MY VEHICLE COMPLETELY SHUT OFF WHILE DRIVING. IF I WASN'T GOING DOWN A LOW TRAFFIC STREET I WOULD HAVE CRASHED. WHEN DRIVING AT NIGHT WITH THE AC ON WHEN GETTING ON MY BRAKES THE HEADLIGHTS DIM STEERING WHEEL WILL LOCK UP AND THE STABILITY CONTROL WILL COME ON AND TRIES TO KILL THE MOTOR. THIS FOR THE MOST TIME HAPPENS WHEN GETTING IN MY DRIVEWAY, TODAY WAS THE FIRST TIME IT HAPPENED WHILE DRIVING AT HIGHER SPEEDS.
NHTSA ODI #11349668
15 miles · Aug 13, 2020
Electrical SystemElectronic Stability Control (esc)Steering
SOMETIMES WHEN I HOLD DOWN ON THE BRAKE PEDAL SOME ELECTRICAL ISSUE HAPPENES AND MY STEERING WHEEL GETS VERY HARD MY AC TURNS OFF MY WHOLE DASHBOARD TURNS OFF AND SO DOES MY RADIO THEN AFTER ABOUT 10 SECONDS IT TURNS BACK ON. I ALSO NOTICED THAT WHEN I'M ROLLING UP THE WINDOWS MY HEADLIGHTS DIM. I THINK SOMETHINGS WRONG WITH THE…
Read full complaint
SOMETIMES WHEN I HOLD DOWN ON THE BRAKE PEDAL SOME ELECTRICAL ISSUE HAPPENES AND MY STEERING WHEEL GETS VERY HARD MY AC TURNS OFF MY WHOLE DASHBOARD TURNS OFF AND SO DOES MY RADIO THEN AFTER ABOUT 10 SECONDS IT TURNS BACK ON. I ALSO NOTICED THAT WHEN I'M ROLLING UP THE WINDOWS MY HEADLIGHTS DIM. I THINK SOMETHINGS WRONG WITH THE ELECTRICAL SYSTEM OF THE VEHICLE I HAD THE BATTERY CHECKED ONCE AND IT WAS NOT THE VOLTAGE IT NEEDED I REPLACED IT WITH THE BATTERY FROM THE DEALERSHIP IT WAS WELL FOR ABOUT THREE MONTHS AND THE ISSUE REOCCURRED. WHEN I AM REVERSING MY STEERING WHEEL GETS VERY HARD AS I'M PRESSING ON THE PEDAL WHILE I'M PARKING IT DOESN'T DO IT ALL THE TIME BUT IT DOES DO IT FREQUENTLY.
NHTSA ODI #11349113
105,000 miles · Aug 10, 2020
Electronic Stability Control (esc)SteeringWheels
MY SEATBELT HAS LOCKED ON ME A COUPLE OF TIMES WITHOUT EVEN BEING ON BREAK AN THE FOOT AREA IS EXTREMELY HOT . I'VE TOOK IT TO GET SERVICED AN IT STILLS DOES IT . MY STEERING WHEEL AN LOCKED ALSO I JUST DON'T DRIVE IT LIKE I USE TO AN I'M STILL PAYING A NOTE ON IT .VERY FRUSTRATING .I WAS DRIVING AT ALL TIME THESE PROBLEMS OCCUR…
Read full complaint
MY SEATBELT HAS LOCKED ON ME A COUPLE OF TIMES WITHOUT EVEN BEING ON BREAK AN THE FOOT AREA IS EXTREMELY HOT . I'VE TOOK IT TO GET SERVICED AN IT STILLS DOES IT . MY STEERING WHEEL AN LOCKED ALSO I JUST DON'T DRIVE IT LIKE I USE TO AN I'M STILL PAYING A NOTE ON IT .VERY FRUSTRATING .I WAS DRIVING AT ALL TIME THESE PROBLEMS OCCURRED
NHTSA ODI #11348415
Official recalls
6Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Jun 29, 2017
General Motors LLC (GM) is recalling certain 2014 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The vehicles may have a temporary loss of electric power steering (EPS) assist, especially during low-speed turning maneuvers.
Consequence & remedy
Consequence: If EPS assist is lost and then returns, the driver might lose temporary control of the steering wheel, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began on August 10, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-432-8782. GM's number for this recall is 17276.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration