NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
341 reportsClear category filter53,000 miles · Jul 31, 2017
Electrical SystemElectronic Stability Control (esc)Steering
TOOK MY TRUCK IN OCT. 2016 TO HAVE IT REPAIRED FOR STEERING WHEEL SHUDDERING AND HAVING TO FIGHT IT ON TURNS. AND THE TRUCK JUST SHUTTING DOWN. TOLD IT WAS AN ELECTRICAL PROBLEM. WELL 9 MONTHS LATER DOING THE SAME THING. AFTER THE CHEVROLET DEALER SUPPOSEDLY FIXED IT. I THINK IT IS A PROBLEM WHEN YOU LOSE CONTROL OF STEERING AN…
Read full complaint
TOOK MY TRUCK IN OCT. 2016 TO HAVE IT REPAIRED FOR STEERING WHEEL SHUDDERING AND HAVING TO FIGHT IT ON TURNS. AND THE TRUCK JUST SHUTTING DOWN. TOLD IT WAS AN ELECTRICAL PROBLEM. WELL 9 MONTHS LATER DOING THE SAME THING. AFTER THE CHEVROLET DEALER SUPPOSEDLY FIXED IT. I THINK IT IS A PROBLEM WHEN YOU LOSE CONTROL OF STEERING AND YOUR TRUCK JUST STOPS ON TURNS. MY TRUCK WAS IN MOTION ON A CITY STREET.
NHTSA ODI #11011880
22,800 miles · Jul 24, 2017
Electrical SystemEngineSteering
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE TURNING RIGHT AT 5 MPH, THE ENGINE STALLED, THE BRAKES FAILED TO SLOW DOWN THE VEHICLE, THE STEERING WHEEL BECAME DIFFICULT TO TURN, AND THE VEHICLE LOST POWER EXCEPT FOR THE ESC INDICATOR AND A WARNING CHIME SOUNDED. THE FAILURES RECURRED AS THE CONTACT TURNED THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE TURNING RIGHT AT 5 MPH, THE ENGINE STALLED, THE BRAKES FAILED TO SLOW DOWN THE VEHICLE, THE STEERING WHEEL BECAME DIFFICULT TO TURN, AND THE VEHICLE LOST POWER EXCEPT FOR THE ESC INDICATOR AND A WARNING CHIME SOUNDED. THE FAILURES RECURRED AS THE CONTACT TURNED THE VEHICLE TO THE LEFT AND THE STEERING WHEEL ALSO SPUN INDEPENDENTLY TO THE RIGHT. THE VEHICLE WAS TAKEN TO JESSUP AUTO PLAZA IN CATHEDRAL CITY, CA WHERE IT WAS DIAGNOSED THAT THE BATTERY CABLE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED A CASE FOR POTENTIAL REPURCHASE. THE VIN WAS INCLUDED IN MANUFACTURER RECALL NUMBER: N172085440. THE APPROXIMATE FAILURE MILEAGE WAS 22,800.
NHTSA ODI #11010306
38,000 miles · Jul 14, 2017
Electrical SystemElectronic Stability Control (esc)Steering
THIS PROBLEM HAS HAPPENED SEVERAL DIFFERENT TIMES. THE FIRST TIME WAS IN MAY 2017. AS I WAS DRIVING HOME, I KEPT GETTING A "SERVICE STABILITRAC" MESSAGE. ABOUT 2 MINUTES AFTER THE LAST MESSAGE I WAS SLOWING DOWN TO TURN AND MY TRUCK COMPLETELY LOST ALL POWER. IT WENT COMPLETELY DARK. THE STEERING WHEEL RIPPED OUT OF MY HANDS AND…
Read full complaint
THIS PROBLEM HAS HAPPENED SEVERAL DIFFERENT TIMES. THE FIRST TIME WAS IN MAY 2017. AS I WAS DRIVING HOME, I KEPT GETTING A "SERVICE STABILITRAC" MESSAGE. ABOUT 2 MINUTES AFTER THE LAST MESSAGE I WAS SLOWING DOWN TO TURN AND MY TRUCK COMPLETELY LOST ALL POWER. IT WENT COMPLETELY DARK. THE STEERING WHEEL RIPPED OUT OF MY HANDS AND I NEARLY CRASHED HEAD ON INTO ONCOMING TRAFFIC. WITH ALL MY STRENGTH I TURNED THE WHEEL ENOUGH TO AVOID A HEAD ON COLLISION. AFTER I COASTED TO A STOP, I TURNED THE KEY OFF, THEN RESTARTED IT AND DROVE HOME. I TOOK IT TO A DEALER AND THEY TOLD ME THEY COULDN'T FIND A PROBLEM. FOR THE LAST 3 MONTHS IT HASN'T HAPPENED AGAIN UNTIL YESTERDAY. ALL KINDS OF ELECTRICAL PROBLEMS. LOSING POWER, STABILITRAC MESSAGES, DIMINISHED STEERING, LOSS OF POWER BRAKES. I PULLED INTO MY DRIVEWAY YESTERDAY AND LOST ALL POWER, MY DOOR LOCKS WENT UP AND DOWN LIKE THREE TIMES, AC SURGES, RADIO WENT ON AND OFF A FEW TIMES. I LOOKED UP THE PROBLEM ONLINE AND FOUND THAT THIS ISAME PROBLEM IS HAPPENING TO A LOT OF 2014 1500 SILVERADOS. THIS SHOULD DEFINITELY BE A RECALL ISSUE. TOTAL LOSS OF POWER WHILE DRIVING. SOMEONE IS GOING TO DIE FROM THIS ISSUE. TODAY WHEN I WAS DRIVING HOME I WAS GOING ABOUT 30 MPH IN TRAFFIC AND MY TRUCK LOST ALL POWER AGAIN, TOTAL BLACKOUT OF ALL ELECTRONICS, NO STEERING OR BRAKES, BUT THANKFULLY ALL SYSTEMS TURNED BACK ON IN A MATTER OF SECONDS AND I MADE IT HOME. AFTER LOOKING ONLINE, IT SEEMS THAT SOMEONE HAS LOCATED THE SOURCE. IT IS A FAULT AT THE "G218" GROUND POINT WHICH IS LOCATED UNDER THE FRONT LEFT DASH SPEAKER. (SEE YOUTUBE VIDEO, SEARCH 2014 CHEVY SILVERADO 1500 STABILITRAC PROBLEM). SERIOUSLY, HOW IS THIS NOT A RECALL, TOTAL LOSS OF POWER WHILE DRIVING.
NHTSA ODI #11005412
54,000 miles · Jul 13, 2017
Electrical SystemSteeringVisibility/wiper
SEVERAL TIMES THE VEHICLE WOULD LOOSE POWER AND SHUT DOWN THE POWER STEERING WHILE ATTEMPTING TO PARK OR TURN AROUND IN DRIVEWAY.. ON TIMES,ONLY WARNINGS WOULD FLASH UP ON THE INFORMATION DISPLAY ABOUT LOSE OF SYSTEMS AND THE DOOR LOCKS WOULD CYCLE. OCCASIONALLY, THE TURN SIGNALS WOULD SHUT OFF THE CRUSE CONTROL.
NHTSA ODI #11005197
72,000 miles · Jul 11, 2017
Electrical System
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE DRIVING AT ANY SPEED, THE AIR CONDITIONING CONDENSER DID NOT WORK WITHOUT WARNING. THE MANUFACTURER AND DEALER WERE CONTACTED (DEFOUWU CHEVROLET IN LAFAYETTE, INDIANA) AND STATED THAT THERE WERE NO RECALLS OR PARTS AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE DRIVING AT ANY SPEED, THE AIR CONDITIONING CONDENSER DID NOT WORK WITHOUT WARNING. THE MANUFACTURER AND DEALER WERE CONTACTED (DEFOUWU CHEVROLET IN LAFAYETTE, INDIANA) AND STATED THAT THERE WERE NO RECALLS OR PARTS AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 72,000.
NHTSA ODI #11004261
36,500 miles · Jul 10, 2017
Electrical System
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE AIR CONDITIONER FAILED TO WORK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER (DONDELINGER CHEVROLET CADILLAC LOCATED AT 6720 PINE BEACH RD, BAXTER, MN 56425; (218) 829-4787) WHERE IT WAS DIAGNOSED THAT THE CONDENSER NEEDED TO BE REPLACED. TH…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE AIR CONDITIONER FAILED TO WORK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER (DONDELINGER CHEVROLET CADILLAC LOCATED AT 6720 PINE BEACH RD, BAXTER, MN 56425; (218) 829-4787) WHERE IT WAS DIAGNOSED THAT THE CONDENSER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-462-8782 AND STATED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 36,500.
NHTSA ODI #11003987
37,000 miles · Jun 22, 2017
Electrical SystemElectronic Stability Control (esc)Steering
STEERING ASSIST ERROR, SERVICE STABILITRAC ERROR,- STEERING WHEEL JERKED OUT OF HAND WHILE TURNING , LOSS OF STEERING. ELECTRICAL LOSS- ALL GAUGES AND LIGHTING BLANK WHILE DRIVING ON HIGHWAY
NHTSA ODI #11000576
40,000 miles · May 19, 2017
Electrical SystemExterior LightingSteering
TRAVELING AT APPROX. 65MPH ON US17 A DIVIDED FOUR LANE HIGHWAY IN TRAFFIC WHEN THE ENGINE SHUT OFF WITH NO WARNING WHICH RESULTED IN COMPLETE LOSS OF LIGHTS, SIGNALS, FLASHERS, HORN, AND THE STEERING WHEEL WENT INTO LOCKED POSITION. I WAS ABLE TO SAFELY BRING THE TRUCK TO A STOP IN THE GRASS MEDIAN. AFTER COLLECTING MY THOUGHTS …
Read full complaint
TRAVELING AT APPROX. 65MPH ON US17 A DIVIDED FOUR LANE HIGHWAY IN TRAFFIC WHEN THE ENGINE SHUT OFF WITH NO WARNING WHICH RESULTED IN COMPLETE LOSS OF LIGHTS, SIGNALS, FLASHERS, HORN, AND THE STEERING WHEEL WENT INTO LOCKED POSITION. I WAS ABLE TO SAFELY BRING THE TRUCK TO A STOP IN THE GRASS MEDIAN. AFTER COLLECTING MY THOUGHTS I TRIED TO RESTART THE TRUCK BUT THERE WAS NO RESPONSE AND ALL ELECTRICAL FUNCTIONS WOULD NOT OPERATE. ABOUT 10 MINUTES LATER WHILE I WAS ON MY CELL PHONE WITH A TOW SERVICE THE INTERIOR LIGHTS CAM ON ALONG WITH THE RADIO. THE TRUCK STARTED UP AND AFTER CALLING THE CLOSEST GM DEALER WHICH HAPPEN TO BE ONLY A FEW MILES AWAY I MADE MY WAY TO THE DEALERSHIP SERVICE DEPT. THEY WERE QUICKLY ABLE TO IDENTIFY THE PROBLEM AS GM HAD ISSUED A SERVICE BULLETIN #PIT5405C ON THIS TYPE OF ISSUE. IT WAS CAUSED BY DASHBOARD FABRIC TRIM BEING CAUGHT UNDER A GROUND POST DURING ASSEMBLY THAT RESULTED IN LOSS OF ALL ELECTRICAL SERVICE. THE TRUCK HAD APPROX. 40,000 MILES AT THE TIME OF THE EVENT AND IT SEEMS IT TOOK EITHER TWO YEARS OR THAT REASONABLY LOW MILEAGE BEFORE THE PROBLEM SURFACED. THE DEALER REPAIRED THE PROBLEM BY SIMPLY LOSING A GROUND POST AND TRIMMING OUT THE FABRIC INTRUSION. THEY WERE GREAT AND APOLOGIZED FOR WHAT THEY SAW AS CLEARLY A DEFECT IN MANUFACTURING. THEY DID CHARGE AS THE TRUCK WAS OUT OF THE 36,000 MILE WARRANTY BUT SAID I SHOULD CONTACT GM CUSTOMER SERVICE FOR HELP WITH THE COST. GM REFUSED BUT IT WAS ONLY ABOUT $100.00 SO THAT IS NOT THE ISSUE. HOW CAN A COMPANY ALLOW THIS PROBLEM TO EXIST AND BE AWARE OF IT ( TECHNICAL BULLETIN ISSUED). IT IS A WONDER THAT I OR ANOTHER MOTORIST ON THE ROAD WITH ME WAS NOT HURT OR WORSE. THIS NOT LIKE A TRUCK NOT STARTING BUT TOTAL LOSS OF CONTROL AT HIGHWAY SPEED. THANKS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10990620
100 miles · May 18, 2017
Air BagsElectrical SystemExterior Lighting
ELECTRICAL, GET NUMEROUS WARNINGS HOOD OPEN, THEFT ALERT, AIR BAG, TRANSMISSION, HORN BEEPS NUMEROUS ALL TIMES OF DAY EVENING, KEY FOB AFRAID TO LOCK DOORS HAVE TO RESET NUMEROUS TIMES TO STOP HORN FROM SOUNDING...PIA ELECTRICAL BEEN TO DEALER PUT NEW BATTERY IN STILL PROBLEM STILL PERSISTS STARED AT 20,000 CAR NOW HAS 40,000 ML…
Read full complaint
ELECTRICAL, GET NUMEROUS WARNINGS HOOD OPEN, THEFT ALERT, AIR BAG, TRANSMISSION, HORN BEEPS NUMEROUS ALL TIMES OF DAY EVENING, KEY FOB AFRAID TO LOCK DOORS HAVE TO RESET NUMEROUS TIMES TO STOP HORN FROM SOUNDING...PIA ELECTRICAL BEEN TO DEALER PUT NEW BATTERY IN STILL PROBLEM STILL PERSISTS STARED AT 20,000 CAR NOW HAS 40,000 MLS.
NHTSA ODI #10986295
36,000 miles · Apr 17, 2017
Electrical System
DASH LIGHTS WOULD FLICKER ALONG WITH HEADLIGHTS. WHEN YOU WOULD TURN THE WHEEL, THE ENTIRE DASH WOULD GO OUT LIKE YOU TURNED OFF THE KEY AND THEN COME RIGHT BACK ON. SOMETIMES THE TRUCK WOULD DIE IN THE ROAD AND DIED WHILE TURNING AND CREATED NEAR MISSES FOR ACCIDENTS. WHEN THE SYSTEM WOULD COME BACK ON, IT WOULD DISABLE THE STE…
Read full complaint
DASH LIGHTS WOULD FLICKER ALONG WITH HEADLIGHTS. WHEN YOU WOULD TURN THE WHEEL, THE ENTIRE DASH WOULD GO OUT LIKE YOU TURNED OFF THE KEY AND THEN COME RIGHT BACK ON. SOMETIMES THE TRUCK WOULD DIE IN THE ROAD AND DIED WHILE TURNING AND CREATED NEAR MISSES FOR ACCIDENTS. WHEN THE SYSTEM WOULD COME BACK ON, IT WOULD DISABLE THE STEERING ASSIST AND CAUSE THE STEERING WHEEL TO JERK BACK TOWARDS CENTER. TOOK THE TRUCK TO THE DEALER WITH VIDEO EVIDENCE OF PROBLEM AND THEY ADVISED THERE WAS NOT RECALLS, SERVICE BULLETINS OR EVEN KNOWLEDGE OF A PROBLEM AND WANTED TO CHARGE $128.00 PER HOUR FLAT RATE TO TROUBLE SHOOT THE PROBLEM. AFTER DOING SOME RESEARCH AT HOME, I FOUND NUMEROUS ISSUES WITH THE SAME PROBLEMS ON FORUMS AND RELATED BACK TO A KNOWN GROUND ISSUE UNDER THE DASH THAT IS LABELED G218 WHERE INSULATION OR MATERIAL IS FOUND UNDER THE GROUND NUT CREATING A HIGHER RESISTANCE. I WAS ABLE TO REMOVE THIS MATERIAL MYSELF AND CORRECT THE PROBLEM WITH NO FURTHER ISSUES. THE SCARY PART ABOUT THIS IS, MY DAUGHTER HAD THE TRUCK DIE ON HER A COUPLE TIMES IN THE MIDDLE OF TRAFFIC AND WAS ALMOST IN A WRECK BECAUSE OF IT. GM REFUSES TO ACCEPT THEIR RESPONSIBILITY ON THIS WHEN IT IS A GM MANUFACTURE PROBLEM.
NHTSA ODI #10978744
Official recalls
6Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Jun 29, 2017
General Motors LLC (GM) is recalling certain 2014 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The vehicles may have a temporary loss of electric power steering (EPS) assist, especially during low-speed turning maneuvers.
Consequence & remedy
Consequence: If EPS assist is lost and then returns, the driver might lose temporary control of the steering wheel, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began on August 10, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-432-8782. GM's number for this recall is 17276.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration