DRIVING AND ALL OF A SUDDEN TRACTION CONTROL LIGHT CAME ON ALONG WITH STABILI TRAK AND REDUCED ENGINE POWER. ALL POWER TO ENGINE GONE AND I SEE IN CHEVY FORUM THIS IS COMMON WTH WHERE IS THE RECALL?? OH ONLY 43,000 MILES TOO
2009 Chevrolet Silverado 1500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2009 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
224 reports with mileage · 220 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 230 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Electronic Stability Control (esc) complaints
13 reportsWHILE DRIVING ON I 81 THE TRUCK WENT INTO REDUCED POWER MODE AND VIOLENTLY WENT FROM 70 MILES PER HOUR TO 10 MILES PER HOUR. THIS MODE IS VERY DANGEROUS! FORTY PERCENT OF THE TRAFFIC ON I 81 IS TRACTOR TRAILER. I'M SCARED TO DRIVE THIS VEHICLE. THE MECHANIC TELLS ME THIS IS VERY EXPENSIVE TO REPAIR AS THERE ARE MANY THINGS T…
Read full complaint
WHILE DRIVING ON I 81 THE TRUCK WENT INTO REDUCED POWER MODE AND VIOLENTLY WENT FROM 70 MILES PER HOUR TO 10 MILES PER HOUR. THIS MODE IS VERY DANGEROUS! FORTY PERCENT OF THE TRAFFIC ON I 81 IS TRACTOR TRAILER. I'M SCARED TO DRIVE THIS VEHICLE. THE MECHANIC TELLS ME THIS IS VERY EXPENSIVE TO REPAIR AS THERE ARE MANY THINGS THAT AN CAUSE THIS CONDITION TO OCCUR!!
TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 1500. WHILE AT A RED LIGHT, THE VEHICLE IDLED ROUGHLY AND THE CHECK ENGINE AND STABILITY CONTROL WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED RICK HENDRICK CHEVROLET CHARLESTON (1500 SAVANNAH HWY, CHARLESTON, SC 29407, (843) 300-1232) AND WAS INFORMED TO PURCHASE A NEW VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 1500. WHILE AT A RED LIGHT, THE VEHICLE IDLED ROUGHLY AND THE CHECK ENGINE AND STABILITY CONTROL WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED RICK HENDRICK CHEVROLET CHARLESTON (1500 SAVANNAH HWY, CHARLESTON, SC 29407, (843) 300-1232) AND WAS INFORMED TO PURCHASE A NEW VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 140,000.
AT 75MPH ON TOLL ROAD AT NIGHT, SUDDENLY THE LIGHTS (ALL EXTERNAL & INTERNAL) WENT DARK. HAZARD LIGHT WOULD NOT WORK, ENGINE QUIT, BELL WENT OFF (DOOR-KEY IN IGNITION BELL), RPM SURGED. WAS ABLE TO GET OFF ROAD AND WAITED 10 MINUTES AND TRUCK STARTED. DROVE OFF, GOT TO 60 AND SAME THING HAPPENED. WAITED 30 MINUTES AND TRUCK WAS …
Read full complaint
AT 75MPH ON TOLL ROAD AT NIGHT, SUDDENLY THE LIGHTS (ALL EXTERNAL & INTERNAL) WENT DARK. HAZARD LIGHT WOULD NOT WORK, ENGINE QUIT, BELL WENT OFF (DOOR-KEY IN IGNITION BELL), RPM SURGED. WAS ABLE TO GET OFF ROAD AND WAITED 10 MINUTES AND TRUCK STARTED. DROVE OFF, GOT TO 60 AND SAME THING HAPPENED. WAITED 30 MINUTES AND TRUCK WAS OK EXCEPT WHEN BRAKES APPLIED -DOOR/KEY BELL WENT OFF. DEALER HAD TRUCK FOR THREE DAYS AND COULD NOT DUPLICATE. WENT TO UTUBE AND TYPED IN ELECTRICAL PROBLEMS-2009 SILVERADO AND SEVERAL PAGES OF THE EXACT SAME PROBLEM APPEARED.CALLED DEALER TOLD THEM TO REPLACE THE BATTERY GROUND CABLE AND TO CHECK THE MEGA FUSE. SO FAR THE TRUCK IS RUNNING OK (INCIDENT HAPPENED IN JULY 2017) SEEMS LIKE THE BACK YARD MECHANICS KNOW MORE ABOUT HOW TO FIX THIS PROBLEM. THIS IS SERIOUS, DRIVING AT NIGHT AT 75 AND LOSING ALL ELECTRICS IS AN ACCIDENT WAITING TO HAPPEN. THE MANUFACTURE NEEDS TO BE HELD ACCOUNTABLE FOR THE POOR QUALITY GROUND CABLES; THIS SHOULD BE A RECALL!!!
I HAVE SEEN YOUTUBE VIDEO'S/FORUMS ONLINE ABOUT THE 2009 MODEL YEAR SILVERADO'S INSTRUMENT GAUGE CLUSTER FAILING WHILE DRIVING, AS WELL AS MY OWN. VERY UNSAFE AND SCARY. HAPPENS ON STARTUP, DRIVING, AND PARKED. NEVER KNOW WHEN IT WILL DO IT. *TR
THE TRUCK WAS SITTING PARKED IN THE DRIVEWAY AND MY NEIGHBOR NOTICED THAT THE LIGHTS AND WIPERS CAME ON (TRUCK WAS NOT ON, NO KEYS WERE IN IT, NOBODY WAS IN IT OR NEAR IT!). SMOKE THEN BEGAN TO BILLOW OUT FROM UNDER THE HOOD AND A FIRE STARTED. MY NEIGHBOR WAS ABLE TO DISCONNECT THE BATTERY AND PUT OUT THE FIRE. I HAD THE TRUCK …
Read full complaint
THE TRUCK WAS SITTING PARKED IN THE DRIVEWAY AND MY NEIGHBOR NOTICED THAT THE LIGHTS AND WIPERS CAME ON (TRUCK WAS NOT ON, NO KEYS WERE IN IT, NOBODY WAS IN IT OR NEAR IT!). SMOKE THEN BEGAN TO BILLOW OUT FROM UNDER THE HOOD AND A FIRE STARTED. MY NEIGHBOR WAS ABLE TO DISCONNECT THE BATTERY AND PUT OUT THE FIRE. I HAD THE TRUCK TOWED TO A GARAGE WHERE THEY TOLD ME THAT THE FUSE PANEL CAUGHT ON FIRE. THEY CALLED GM AND WAS TOLD THERE WAS NO RECALL FOR THE PART. DEALING WITH INSURANCE NOW.
SO ABOUT 4 MONTHS AGO I REPLACED THE BATTERY TRUCK WAS RUNNING FINE TILL ABOUT MONTH THREE. I WAS DRIVING MY TRUCK AND ALL OF A SUDDEN ALL THE ELECTRICAL STARTED FREAKING OUT ON ME. I POPPED THE HOOD AND PUSHED THE NEGATIVE WIRE FOR THE BATTERY DOWN AND IT STOPPED FOR A GOOD TWO MONTHS SO TODAY (JUNE 7TH, 2016)I WAS ON MY WAY TO…
Read full complaint
SO ABOUT 4 MONTHS AGO I REPLACED THE BATTERY TRUCK WAS RUNNING FINE TILL ABOUT MONTH THREE. I WAS DRIVING MY TRUCK AND ALL OF A SUDDEN ALL THE ELECTRICAL STARTED FREAKING OUT ON ME. I POPPED THE HOOD AND PUSHED THE NEGATIVE WIRE FOR THE BATTERY DOWN AND IT STOPPED FOR A GOOD TWO MONTHS SO TODAY (JUNE 7TH, 2016)I WAS ON MY WAY TO AUTOZONE TO HAVE THEM CHECK THE BATTERY FOR ME AND ON MY WAY OVER TO THEM TRUCK THRE A TEMPER TANTRUM AND STARTED WITH THE FREAKING OUT THEN I WAS ALMOST THERE AND IT JUST COMPLETELY SHUT OFF ON ME IN THE MIDDLE OF TRAFFIC I WAS LUCKLY IN THE TURNING LANE TO TURN INTO THE AUTOZONE. IT ALSO FID IT WHEN I WAS COMING OVER THE MOUNTAIN FREAKING OUT WITH THE ELECTRICAL. THEN JUST COMPLETLY CAME TO A STOP AT THE INTERSECTION AS I WAS TURNING LEFT ALMOST GOT HIT BY ANOTHER SILVERADO 2500 THAT WAS RIGHT BEHIND ME. BUT EVERY ONCE IN A WHILE IT'LL BE OKAY THEN ALL OF A SUDDEN JUST START UP AGAIN.
WHILE TRAVELING 70 MPH ON THE INTERSTATE EVERYTHING GOES CRAZY AT ONCE: DOORS LOCK AND UNLOCK, ENGINE CUTS AND GOES BACK ON, STABILITRAK LIGHT COMES ON AND GOES OFF, TRANSMISSION KICKS OUT OF GEAR AND THEN DOWNSHIFTS SENDING THE ENGINE TO OVER 5,000 RPM, RADIO GOES OFF AND ON OFF AND ON. THIS EVENT LASTS FOR ABOUT 5 TO 7 SECOND…
Read full complaint
WHILE TRAVELING 70 MPH ON THE INTERSTATE EVERYTHING GOES CRAZY AT ONCE: DOORS LOCK AND UNLOCK, ENGINE CUTS AND GOES BACK ON, STABILITRAK LIGHT COMES ON AND GOES OFF, TRANSMISSION KICKS OUT OF GEAR AND THEN DOWNSHIFTS SENDING THE ENGINE TO OVER 5,000 RPM, RADIO GOES OFF AND ON OFF AND ON. THIS EVENT LASTS FOR ABOUT 5 TO 7 SECONDS THEN EVERYTHING GOES BACK TO NORMAL. THE PROBLEM HAS OCCURRED INTERMITTENTLY AND MAY NOT HAPPEN AGAIN FOR SEVERAL MONTHS. THIS PROBLEM SOUNDS VERY SIMILAR TO NHTSA ID #10871399. IT IS AN EXTREMELY SCARY EVENT AND WHEN IN TRAFFIC GOING 70 AND THE VEHICLE DOWNSHIFTS AND THE SPEED DROPS TO 50 LIKE YOU SLAMMED ON THE BRAKES, BUT THE BRAKES HAVE NOT BEEN TOUCHED. IT ALMOST CAUSED ME TO BE HIT THIS MORNING. I PURCHASED THE VEHICLE IN FEBRUARY 2014 WITH 114,000 MILES, THIS FIRST HAPPENED IN 2014 WITH APPROX. 118,000 MILES. THE VEHICLE CURRENTLY HAS 171,500.
THE VEHICLE FIRST STARTED HAVING ELECTRICAL TROUBLES WHEN WE WERE TRAVELING DOWN THE INTERSTATE. THE DOOR LOCKS WERE CYCLING RAPIDLY, THE GAUGES WERE BOUNCING ALL OVER THE DIALS, WE LOST POWER, THE LIGHTS ON THE DASH WERE FLASHING, AND THE TRANSMISSION STOPPED WORKING, AND WE WERE COASTING - ON AN INTERSTATE. WE PULLED OVER AN…
Read full complaint
THE VEHICLE FIRST STARTED HAVING ELECTRICAL TROUBLES WHEN WE WERE TRAVELING DOWN THE INTERSTATE. THE DOOR LOCKS WERE CYCLING RAPIDLY, THE GAUGES WERE BOUNCING ALL OVER THE DIALS, WE LOST POWER, THE LIGHTS ON THE DASH WERE FLASHING, AND THE TRANSMISSION STOPPED WORKING, AND WE WERE COASTING - ON AN INTERSTATE. WE PULLED OVER AND SHUT IT OFF FOR A FEW MOMENTS, STARTED IT UP AND TOOK OFF AGAIN, WITH NO TROUBLE. GOT HOME AND I LOOKED IT UP ON THE INTERNET, AND FOUND MANY SIMILAR/IDENTICAL STORIES. WE TOOK IT TO THE DEALERSHIP AND THEY SAID THEY COULD FIND NOTHING WRONG. THEY CHARGED US $200, AND THE PROBLEM SEEMED FIXED, FOR A WHOLE TWO MONTHS, JUST LIKE EVERYONE ELSE SAID IN THEIR POSTS. IT HAS DONE IT AT LEAST 7 TIMES OVER THE PAST YEAR, AND WE HAVE RESORTED TO PUSHING IN THE FUSES, WHICH WIGGLE LOOSE - AND IT SEEMS TO FIX IT, ALBEIT TEMPORARILY. UNTIL TODAY. IT STARTED HAPPENING ON THE INTERSTATE AGAIN, AND WE PULLED OVER, OPENED THE HOOD, TOOK OFF THE COVER, AND PUSHED DOWN THE FUSES, BUT NONE WERE LOOSE. IT ACTED UP ABOUT 3 MORE TIMES ON THE WAY BACK HOME, AND WE HAD TO TURN AROUND TO GET THE TRUCK IN THE DRIVEWAY BEFORE IT JUST DIED ALTOGETHER. WE MISSED AN APPOINTMENT WITH A CUSTOMER (WE DO CONSTRUCTION) BECAUSE OF IT. IT'S NOT SAFE TO DRIVE - WE'RE WORRIED ABOUT GETTING INTO AN ACCIDENT BECAUSE OF THE LOSS OF POWER. GM SAYS THEY'RE SYMPATHETIC, BUT THAT DOESN'T FIX IT. WE DON'T NEED SYMPATHY, WE NEED RESULTS! THEY ALSO SAY THEY'VE NOT HEARD OF THE PROBLEM - BULL----. THEY KNOW OF THE PROBLEM, THEY JUST DON'T WANT TO DO ANYTHING ABOUT IT. THUS FAR, I DON'T THINK ANYONE HAS BEEN KILLED, SO THE BEAN COUNTERS AREN'T RATTLED YET. SO FAR, NO LAWSUITS THAT I KNOW OF - THEY GET TO RIDE OFF INTO THE SUNSET WITH OUR MONEY AND ALL WE GET IS A JUNK TRUCK THAT YOU CAN'T RELY UPON EVEN THOUGH IT ONLY HAS 58,000 MILES.
WHILE DRIVING THE STABILITRAK LIGHT CAME ON AND THEN THE ABS LIGHT. IT STAYED ON, SO I TOOK IT TO A MECHANIC WHO DETERMINED IT WAS THE BRAKE SWITCH AND HE REPLACED IT. IT HAS BEEN FINE UNTIL RECENTLY, WHEN IT CAME ON AGAIN AND MY BRAKE LIGHTS WERE STICKING ON, SO I REPLACED THE BRAKE SWITCH AGAIN. SO, FAR IT'S STAYED OFF. M…
Read full complaint
WHILE DRIVING THE STABILITRAK LIGHT CAME ON AND THEN THE ABS LIGHT. IT STAYED ON, SO I TOOK IT TO A MECHANIC WHO DETERMINED IT WAS THE BRAKE SWITCH AND HE REPLACED IT. IT HAS BEEN FINE UNTIL RECENTLY, WHEN IT CAME ON AGAIN AND MY BRAKE LIGHTS WERE STICKING ON, SO I REPLACED THE BRAKE SWITCH AGAIN. SO, FAR IT'S STAYED OFF. MY CONCERN IS THAT MY TRUCK MY START HAVING THE SAME ISSUES AS OUR OTHER GM VEHICLE, WHICH ALSO INVOLVES THE STABILITRAK/TRACTION CONTROL/REDUCED POWER LIGHTS COMING ON. REDUCED POWER IS DANGEROUS WHILE DRIVING, ESPECIALLY ON THE INTERSTATE IN HEAVY TRAFFIC. I HAVE READ GM FORUMS AND HAVE FOUND THAT THIS PROBLEM HAS BEEN HAPPENING AS FAR BACK AS 6 YEARS, AND GM STILL HAS NOT FIGURED OUT HOW TO FIX IT.
Official recalls
321V050000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.
21V052000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.
21V053000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration