2006 Chevrolet Silverado 1500

WHILE TRAVELING AT HIGHWAY SPEED THE BREAKS WERE APPLIED TO STOP FOR A RED LIGHT, THE FRONT BREAK LINE BROKE AND THE BREAKING PETAL WENT TO THE FLOOR. THE BREAKS WERE THEN PUMPED BUT THERE WAS NO REAL REDUCTION IN SPEED ALLOWING THE TRUCK TO TRAVEL THRU THE INTERSECTION AT A HIGH RATE OF SPEED THRU THE RED LIGHT. THE TRUCK DID EVENTUALLY COME TO A STOP WITH THE CONTINUED PUMPING OF THE BREAKS

THE BRAKES WENT TO THE FLOOR AND COMPLETELY FAILED; THROUGH THE INTERSECTION WE WENT. I WAS ABLE TO USE THE EMERGENCY BRAKE TO SLOW AND THEN STOP THE TRUCK. SOMEHOW, WE WERE ABLE TO AVOID AN ACCIDENT. I WAS ABLE TO GET THE TRUCK THE REST OF THE WAY HOME USING THE EMERGENCY BRAKE. THE BRAKE FLUID RESERVOIR WAS FULL, BUT I COULD SEE FLUID LEAKING UNDER THE TRUCK FROM THE FRAME AREA NEAR THE DRIVER'S DOOR. LOOKING UNDER THE TRUCK, I NOTICED THE BRAKE LINES WERE RUSTED; EVERY BRAKE LINE ON THE TRUCK WAS RUSTED. LOOKING ON-LINE, I NOTICED I WASN'T THE ONLY ONE WITH THIS PROBLEM. I ORDERED A COMPLETE SET OF STAINLESS STEEL BRAKE LINES. WE HAD THE TRUCK TOWED THE TRUCK TO THE CHEVY DEALER ($200.00). THEY REPLACED EVERY BRAKE LINE ON THE TRUCK AS WELL AS THE FRONT CALIPERS ($2100). THE DEALER DID A GREAT JOB; $1600.00 OF THE COST WAS FOR LABOR.

WAS TRAVELING APPROXIMATELY 55 MPH DOWN A STATE HIGHWAY. AFTER COMING AROUND A BLIND CURVE, CAME UPON STOPPED TRAFFIC DUE TO ROAD WORK. APPLIED PRESSURE TO BRAKE PEDAL WHEN PEDAL WENT SOFT AND DEPRESSED ALL THE WAY TO THE FLOOR. AFTER RELEASING BRAKES AND PUSHING AGAIN STILL HAD NO BRAKES. HAD TO SWERVE OUT OF ROAD-WAY TO AVOID REAR ENDING MULTIPLE VEHICLES. AFTER RUNNING OUT OF ROAD, HIT 2 CULVERT PIPES ALONG WITH ROAD WORK SIGNAGE, FINALLY BRINGING THE TRUCK TO A STOP IN A RESIDENTIAL YARD. TRUCK BRAKE LINES FOR FRONT BRAKES HAD CORRODED AND RUPTURED CAUSING THE INCIDENT. FURTHER INVESTIGATION INTO THIS MATTER SHOWS AN APPARENT ISSUE WITH THIS MODEL GMS FOR BRAKE LINE CORROSION THAT GM HAS FAILED TO ADDRESS THROUGH THE RECALL PROCESS.

PARKED VEHICLE IN DRIVEWAY, MOVED IT ABOUT THREE FEET AND BRAKED. THE PEDAL WENT TO THE FLOOR. LOOKED UNDER THE TRUCK AND FOUND A LARGE PUDDLE OF BRAKE FLUID COMING FROM A RUSTED THROUGH BRAKE LINE. UPON FURTHER INSPECTION THE OTHERS WERE IN THE SAME STATE. LUCKY THIS DIDN'T HAPPEN WITH FAMILY ONBOARD WHILE DRIVING ON A ROADWAY, COULD HAVE RESULTED IN A TERRIBLE ACCIDENT.

BRAKE LINES ARE RUSTING AWAY. I NOTICED A SOFT BRAKE PEDAL, ON MY WAY BACK TO ST. LOUIS FROM ATLANTA, GA. I NOTICED FLUID UNDER THE TRUCK IN MY DRIVEWAY AFTER I GOT HOME. I STARTED LOOKING AROUND THE TRUCK. THE MASTER CYLINDER WAS LOW ON FLUID. NO WARNING LIGHT CAME ON. I NOTICED FLUID UNDER THE DRIVERS SIDE DOOR. IT WAS BRAKE FLUID COMING FROM A RUSTED THRU BRAKE LINE. AFTER INSPECTION, ALL OF THE OTHER BRAKE LINES WERE BADLY RUSTED. THE REPAIR(REICHERS AUTO AND TIRE-WASHINGTON, MO) SHOP IS REPLACING ALL OF THE BRAKE LINES DUE TO HEAVY RUST. COST IS GOING TO BE OVER $800.

REAR BRAKE LINE RUSTED COMPLETELY THROUGH DURING NORMAL DRIVING OPERATION WHICH RESULTED IN A BRAKE FLUID SPILL AND REDUCED BRAKING CAPACITY OF THE VEHICLE. VEHICLE WAS ON A CITY STREET TURNING ONTO A HIGHWAY WHEN THE INCIDENT HAPPENED. FURTHER INSPECTION FOUND THAT ALL BRAKE LINES ON THE VEHICLE HAD EXTENSIVE CORROSION AND HAD TO BE REPLACED. VEHICLE HAD 120,000 MILES ON IT WITH NO ACCIDENT HISTORY.