IllustrationBRAKE LINE BROKE IN MY DRIVEWAY AS I WAS PUTTING THE TRUCK IN GEAR. THERE IS NO RUST ON TRUCK EXCEPT BRAKE LINES. *TR
2005 Chevrolet Silverado 1500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
570–25K
10225–50K
12850–75K
8375–100K
61100–150K
31150K+
462 reports with mileage · 63 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 189 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 82 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports34 fire reports10 injury reports
What owners actually said
525 reportsREAR BRAKE LINE RUPTURED WHILE BRAKING FOR A HIGHWAY EXIT. ALL THE BRAKE FLUID LEAKED OUT WHEN I ATTEMPTED TO PUMP THE BRAKES TO STOP. I WAS ABLE TO USE THE EMERGENCY BRAKE TO COME TO A COMPLETE AND SAFE STOP. WHEN I LOOKED TO FIND THE PROBLEM, I FOUND THE REAR BRAKE LINE DIRECTLY UNDER THE DRIVER DOOR WAS COMPLETELY RUSTED A…
Read full complaint
REAR BRAKE LINE RUPTURED WHILE BRAKING FOR A HIGHWAY EXIT. ALL THE BRAKE FLUID LEAKED OUT WHEN I ATTEMPTED TO PUMP THE BRAKES TO STOP. I WAS ABLE TO USE THE EMERGENCY BRAKE TO COME TO A COMPLETE AND SAFE STOP. WHEN I LOOKED TO FIND THE PROBLEM, I FOUND THE REAR BRAKE LINE DIRECTLY UNDER THE DRIVER DOOR WAS COMPLETELY RUSTED AND BLOWN OUT. *TR
BRAKE LINES RUPTURED. BRAKE PEDAL WENT TO FLOOR.
BRAKE LINES RUSTED; BRAKE LINE LEAK; TRUCK WOULD NOT BRAKE/STOP IN DRIVEWAY; HAD TRUCK TOWED TO REPAIR SHOP TO REPLACE BRAKE LINES COMPLETELY RUSTED. *TR
DROVE INTO THE GARAGE AND PARKED. A LOUD EXPLOSIVE NOISE CAME FROM THE TRUCK AND FUMES BEGAN FUNNELING THROUGH THE HOOD OF TRUCK. QUICKLY TURNED OFF IGNITION AND GOT OUT OF VEHICLE. IN A FEW MINUTES GARAGE WAS FULL OF INTENSE FLAMES. THE HEAT WAS SO INTENSE IT BLEW OPEN THE DOOR INTO THE HOUSE AND BURNED/MELTED THE LAUNDRY …
Read full complaint
DROVE INTO THE GARAGE AND PARKED. A LOUD EXPLOSIVE NOISE CAME FROM THE TRUCK AND FUMES BEGAN FUNNELING THROUGH THE HOOD OF TRUCK. QUICKLY TURNED OFF IGNITION AND GOT OUT OF VEHICLE. IN A FEW MINUTES GARAGE WAS FULL OF INTENSE FLAMES. THE HEAT WAS SO INTENSE IT BLEW OPEN THE DOOR INTO THE HOUSE AND BURNED/MELTED THE LAUNDRY EQUIPMENT AND THREE ROOMS, AND THE SECOND CAR IN THE GARAGE, SENDING SMOKE DAMAGE THROUGHOUT THE ENTIRE HOUSE. VEHICLES MELTED AND EVERYTHING IN THEM AND IN THE GARAGE- MOWER, SNOW BLOWER, SMALL EQUIPMENT AND MORE, WAS TOTALLY DESTROYED. THE FIREFIGHTERS WERE ABLE TO CONTAIN THE FIRE TO AREAS IDENTIFIED ABOVE. THERE WAS EXTREME SMOKE DAMAGE THROUGHOUT THE ENTIRE HOUSE. *TR
BRAKE LINES BURSTING DUE TO FAULTY (CHEAP) MATERIAL. I HAVE OWNED SEVERAL CHEVY TRUCKS WITHOUT ANY PROBLEMS BUT THIS IS THE WORST I HAVE EVER SEEN. LOOKS LIKE ALL LINES WILL NEED TO BE REPLACED. THEY ARE MADE FROM CHEAP MATERIAL. *TR
CRUISE CONTROL STOPPED WORKING, WILL NOT POWER ON. *JS
NO BRAKE LAMP ILLUMINATES WHEN THE BRAKE PEDAL IS DEPRESSED, ALL OTHER LIGHTS WORK. *JS
ONE DAY AFTER SITTING IN A PARKING LOT THE "CHECK AIR BAG" MESSAGE CAME ON WITH AIR BAG LIGHT. THE PAST WINTER HAD BEEN PARTICULARLY WET AND COLD FOR OHIO. AFTER RESEARCH ONLINE, I FOUND THAT THE FRONT DRIVER SIDE AIR BAG SENSOR WAS DEFORMED AND CAUSING THE PROBLEM. APPARENTLY THE DESIGN CAN ALLOW WATER INTO THE SENSOR, BUT N…
Read full complaint
ONE DAY AFTER SITTING IN A PARKING LOT THE "CHECK AIR BAG" MESSAGE CAME ON WITH AIR BAG LIGHT. THE PAST WINTER HAD BEEN PARTICULARLY WET AND COLD FOR OHIO. AFTER RESEARCH ONLINE, I FOUND THAT THE FRONT DRIVER SIDE AIR BAG SENSOR WAS DEFORMED AND CAUSING THE PROBLEM. APPARENTLY THE DESIGN CAN ALLOW WATER INTO THE SENSOR, BUT NOT DRAIN OUT. HENCE, THE WATER FROZE INSIDE THE SENSOR, EXPANDED AND DAMAGED THE SENSOR, RENDERING THE AIR BAG SYSTEM INOPERABLE. PART NUMBER 15103522. FURTHER RESEARCH REVEALED THAT THE PART HAS BEEN REPLACED BY ANOTHER PART NUMBER - 10370149. UNSURE IF THIS NEW PART CORRECTS THE LACK OF DRAINAGE OR NOT BUT ACCORDING TO THE ONLINE RESEARCH, IT JUST MIGHT. CONTACTED CHEVY AUTHORIZED SERVICE AND THEY ARE NOT WILLING TO REPLACE THE PART AT THEIR COST SINCE THERE HAS NOT BEEN AN OFFICIAL RECALL. I WAS PUT ON HOLD FOR 5 MINUTES WAITING TO LEARN OF THE PART PRICE, AT WHICH POINT I HUNG UP. THERE ARE NUMEROUS ONLINE REPORTS OF THIS PROBLEM AND BEING THAT IT IS A LIFE SAFETY ISSUE, ONE MIGHT THINK THAT CHEVY WOULD BE INTERESTED IN NOT INCURRING MORE LAWSUITS THAN THEY ALREADY HAVE AGAINST THEM. *TR
IGNITION SWITCH IS GETTING HARDER AND HARDER TO GET THE KEY TO TURN. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.