2005 CHEVY 1500 SILVERADO - HEATER BLOWS HOT AIR ON DRIVERS SIDE, COLD ON PASSENGER SIDE - HAPPENS WITHOUT NOTICE - HAVE SPENT AROUND $300.00 (+) DOLLARS TRYING TO FIX THIS. WAS TOLD BY GM SERVICE TECH IT WAS THE HEATER MOTOR RESISTOR WIRING HARNESS, IT BURNS OUT THE RESISTOR. I REPLACED BOTH, THE RESISTOR BURNED OUT AGAIN AND T…
Read full complaint
2005 CHEVY 1500 SILVERADO - HEATER BLOWS HOT AIR ON DRIVERS SIDE, COLD ON PASSENGER SIDE - HAPPENS WITHOUT NOTICE - HAVE SPENT AROUND $300.00 (+) DOLLARS TRYING TO FIX THIS. WAS TOLD BY GM SERVICE TECH IT WAS THE HEATER MOTOR RESISTOR WIRING HARNESS, IT BURNS OUT THE RESISTOR. I REPLACED BOTH, THE RESISTOR BURNED OUT AGAIN AND THE WIRING HARNESS WAS FRIED AGAIN. THE INTERNET IS FULL OF THESE REPORTS - A RECALL IS NEEDED - THIS CONDITION IS NOT SAFE. THANK YOU FOR YOUR HELP. *TR
NHTSA ODI #10285115
42,000 miles · Sep 23, 2009
Electrical SystemFire
WIRING HARNESS CAUGHT ON FIRE UNDER DASH. *TR
NHTSA ODI #10285062
Mileage unknown · Sep 20, 2009
Electrical SystemVisibility
THE WIRES LEADING TO A/C BLOWER ARE SHORTING OUT ONE AT A TIME. IT STARTED WITH THE CLIMATE CONTROL SET ON HI STOPPED WORKING THEN WENT ON DOWN TO 4. COULD POSSIBLE SHORT OUT AND CAUSE A FIRE. I HAVE NOT YET PURCHASED THE NEW PARTS TO REPLACE LOOKED ONLINE FIRST TO SEE IF THERE HAD BEEN A RECALL FOR THIS PROBLEM. *TR
NHTSA ODI #10284680
93,000 miles · Sep 16, 2009
Electrical System
THE SPEEDOMETER ON MY 2005 CHEVROLET SILVERADO 1500 Z71 WITH THE 5.3 LITER V8 STOPPED WORKING AT ABOUT 93K. THE SPEEDOMETER IN NOW STUCK AT 120MPH AND DOES NOT GIVE ME A CORRECT READING. *TR
NHTSA ODI #10284207
99,000 miles · Aug 20, 2009
Electrical System
SPEEDOMETER STOPPED WORKING ON MY 2005 CHEVY SILVERADO. *TR
NHTSA ODI #10281202
47,000 miles · Aug 5, 2009
Electrical SystemVisibilityFire
WHILE PARKED THE BLOWER MOTOR FOR THE CLIMATE SYSTEM CONTINUED TO RUN. THE KEYS WERE REMOVED, ENGINE OFF. UPON DISCOVERY I COULD NOT TURN OFF THE BLOWER. I DECIDED TO TAKE IT TO A SHOP. BEFORE I COULD LEAVE THE PARKING LOT THE CAB WAS FULL OF A THICK WHITE SMOKE. I WAS ABLE TO SHUT THE ENGINE OFF AND DISCONNECT THE BATTERY …
Read full complaint
WHILE PARKED THE BLOWER MOTOR FOR THE CLIMATE SYSTEM CONTINUED TO RUN. THE KEYS WERE REMOVED, ENGINE OFF. UPON DISCOVERY I COULD NOT TURN OFF THE BLOWER. I DECIDED TO TAKE IT TO A SHOP. BEFORE I COULD LEAVE THE PARKING LOT THE CAB WAS FULL OF A THICK WHITE SMOKE. I WAS ABLE TO SHUT THE ENGINE OFF AND DISCONNECT THE BATTERY BEFORE A FIRE STARTED. THE DEALERSHIP SAID IT WAS A COMMON PROBLEM. THERE IS NO RECALL ON IT THOUGH AS THE DEALER IS NOT REPORTING THE OCCURRENCES TO GM SO NOBODY IS AWARE OF THE FREQUENCY. AN EASY INTERNET SEARCH RETURNS MANY OCCURRENCES OF SIMILAR PROBLEMS. *TR
NHTSA ODI #10279517
22,588 miles · Jul 13, 2009
Electrical SystemVisibilityFire
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE HEATING CIRCUITS UNDER THE DASHBOARD WERE HEATING UP EXCESSIVELY AND WOULD CRACKLE AND SPARKLE. THERE WERE NO RECALLS FOR THIS FAILURE. THE MANUFACTURER WOULD NOT ASSUME LIABILITY FOR THE FAILURE. THE CONTACT WAS CONCERNED THAT A FIRE COULD OCCU…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE HEATING CIRCUITS UNDER THE DASHBOARD WERE HEATING UP EXCESSIVELY AND WOULD CRACKLE AND SPARKLE. THERE WERE NO RECALLS FOR THIS FAILURE. THE MANUFACTURER WOULD NOT ASSUME LIABILITY FOR THE FAILURE. THE CONTACT WAS CONCERNED THAT A FIRE COULD OCCUR. HE ALSO STATED THAT THE HEATER AND DEFROSTER WERE INOPERABLE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 22,588.
NHTSA ODI #10276520
72,000 miles · Jul 10, 2009
Electrical SystemFire
FAN MOTOR RESISTOR MELTED CAUSING PLASTIC TO BURN AND SMOKE BADLY PART COST $100 FOR THE WIRING $80 FOR THE RESISTOR $160 LABOR. WITH ALL THE TAX DOLLARS GIVEN TO GM THEY WERE NOT WILLING TO HELP WITH THIS KNOWN PROBLEM. THEY SAID THEY CHANGE THESE EVERYDAY. THERE WAS ACTUALLY TWO OF THEM SITTING ON THE PARTS COUNTER READY T…
Read full complaint
FAN MOTOR RESISTOR MELTED CAUSING PLASTIC TO BURN AND SMOKE BADLY PART COST $100 FOR THE WIRING $80 FOR THE RESISTOR $160 LABOR. WITH ALL THE TAX DOLLARS GIVEN TO GM THEY WERE NOT WILLING TO HELP WITH THIS KNOWN PROBLEM. THEY SAID THEY CHANGE THESE EVERYDAY. THERE WAS ACTUALLY TWO OF THEM SITTING ON THE PARTS COUNTER READY TO BE REPLACED FOR SOMEONE ELSE WHEN I WALKED IN. THIS IS A TRUE SAFETY PROBLEM AND WE WOULD LIKE SOME HELP. *TR
NHTSA ODI #10276307
45,000 miles · Jul 6, 2009
Electrical SystemVisibilityFire
THE WIRING HARNESS TO THE BLOWER MOTOR RESISTOR IN MY 2005 CHEVROLET STARTED SMOKING, FROM EXCESS HEAT WITHIN THE WIRING TO THE HARNESS OR RESISTOR. I HAVE SINCE REPLACED THE HARNESS AND RESISTOR, BUT IT STILL DOES THE SAME THING. HOPEFULLY THIS FAULTY WIRING HARNESS IS THE ONLY ONE IN THESE MODELS. *TR
NHTSA ODI #10275819
71,600 miles · Jun 28, 2009
Electrical System
JUST PURCHASED A GSA PICKUP JUNE 26. JUNE 27 WAS HIGHWAY DRIVING IT AND THOUGHT I WAS GOING ABOUT 60 MPH AND THE SPEEDOMETER SAID I WAS GOING 30 MPH. WENT THROUGH TOWN AT APPROXIMATELY 30 MPH AND THE SPEEDOMETER READ LESS THAN 0. *TR
NHTSA ODI #10275143
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Chevrolet Silverado 1500 Problems, Complaints & Recalls | Skip That Year
Illustration