I HAVE A 2001 CHEVY S10 PICKUP, WAS SITTING ON MY TAILGATE WHENONE OF THE TAILGATE STRAPS BROKE, THROWING ME OFF OF THE TAILGATE. I WAS SUPRISED, BUT NOT INJURED. . UPON EXAMINATION, I NOTICE THAT THE TAILGATE STRAP CABLE WAS RUSTING OUT ON THE INSIDE OF THE COATING THAT HAD BEEN PLACED OVER THE CABLEM. MANY OF THE CALBLE STRAND…
Read full complaint
I HAVE A 2001 CHEVY S10 PICKUP, WAS SITTING ON MY TAILGATE WHENONE OF THE TAILGATE STRAPS BROKE, THROWING ME OFF OF THE TAILGATE. I WAS SUPRISED, BUT NOT INJURED. . UPON EXAMINATION, I NOTICE THAT THE TAILGATE STRAP CABLE WAS RUSTING OUT ON THE INSIDE OF THE COATING THAT HAD BEEN PLACED OVER THE CABLEM. MANY OF THE CALBLE STRANDS HAD RUSTED THOUGH. THERE IS A RECALL ON TAILGAT STRAPS FOR FULL SIZE PICKUPS, BUT NOT THE S10. I BELIEVE THAT THE SAME PROBLEM OF THE TAILGATE STRAPS RUSTING THROUGH AND CAUSING AN INJURY IF BOTH FAIL AT THE SAME TIME EXISTS IN THE S10 LINE OF PICKUPS ALSO.
NHTSA ODI #10121426
90,000 miles · May 16, 2005
Structure
OWNER WAS STANDING ON THE TAILGATE UNLOADING HIS TRUCK WHEN THE SUPPORT CABLES SNAPPED, CAUSING THE OWNER TO FALL TO THE GROUND. OWNER LATER CONTACTED THE MANUFACTURER, AND WAS TOLD THAT THIS VEHICLE WAS NOT BEING RECALLED FOR THIS DEFECT, AND THERE WAS NOTHING ELSE THEY COULD DO. *AK THE TAILGATE SUPPORT BRACKETS BROKE. *BF …
Read full complaint
OWNER WAS STANDING ON THE TAILGATE UNLOADING HIS TRUCK WHEN THE SUPPORT CABLES SNAPPED, CAUSING THE OWNER TO FALL TO THE GROUND. OWNER LATER CONTACTED THE MANUFACTURER, AND WAS TOLD THAT THIS VEHICLE WAS NOT BEING RECALLED FOR THIS DEFECT, AND THERE WAS NOTHING ELSE THEY COULD DO. *AK THE TAILGATE SUPPORT BRACKETS BROKE. *BF *NM
NHTSA ODI #10117855
66,000 miles · Apr 26, 2005
Structure
BOTH TAILGATE SUPPORT CABLES ON MY 2001 S10 PICKUP THAT HAS A BLAZER VIN # HAVE BROKEN IN HALF DUE TO RUST AND CORROSION. I WENT TO MY DEALER AND THAT SAID THAT THE RECALL ONLY APPLIES TO FULLSIZE PU/U'S AND OTHER TAILGATE VEHICLES. MY VEHICLE IS NOT LISTED. I AM SEEING THAT THE BLAZER S10 HAS A RECALL ON THESE ITEMS. WHY WOULDN…
Read full complaint
BOTH TAILGATE SUPPORT CABLES ON MY 2001 S10 PICKUP THAT HAS A BLAZER VIN # HAVE BROKEN IN HALF DUE TO RUST AND CORROSION. I WENT TO MY DEALER AND THAT SAID THAT THE RECALL ONLY APPLIES TO FULLSIZE PU/U'S AND OTHER TAILGATE VEHICLES. MY VEHICLE IS NOT LISTED. I AM SEEING THAT THE BLAZER S10 HAS A RECALL ON THESE ITEMS. WHY WOULDN'T MINE? CAN YOU HELP ME GET THESE REPOLACED?*AK
NHTSA ODI #10118471
95,000 miles · Apr 19, 2005
Structure
WHILE LOADING MATERIALS IN THE BED OF THE PICKUP TRUCK THE CABLE SUPPORT FAILED, CAUSING THE TAILGATE TO FALL. THE TAILGATE STAYED LOOSELY ATTACHED TO THE VEHICLE. *AK
NHTSA ODI #10118131
42,000 miles · Apr 19, 2005
Structure
TAILGATE CABLE FAILURE BOTH SIDES ON GM , S10 TRUCK. *AK
NHTSA ODI #10118096
110,000 miles · Apr 19, 2005
Structure
RIGHT HAND SUPPORT CABLE SNAPPED WHILE MYSELF AND ANOTHER WERE SITTING ON THE TAILGATE LAST YEAR. NOT SURE OF EXACT DATE. NO INJURIES. JUST NOTICED ARTICLE IN MEDIA AND THOUGHT THAT I WOULD ADD ANOTHER TO THE LIST. AT THIS TIME, LOCATING ANOTHER CABLE AND LEAVING THE TAILGATE CLOSED.*AK
NHTSA ODI #10118088
39,368 miles · Apr 19, 2005
Structure
TAILGATE STRAP, 1 BROKE ABOUT 2 MONTHS BEFORE THE OTHER ONE BROKE, NOTHING HAS BEEN DONE TO CORRECT THIS, I FIGURE THEY RECALLED ALL THE FULL SIZE TRUCK TO REPLACE THEM ,THEY SHOULD REPLACE THESE AT NO CHARGE. ALSO, IT IS A GOOD THIN I WAS NOT STANDING ON IT WHEN THEY BROKE . I COULD HAVE GOTTEN HURT BY FALLING OFF WHEN THE TAI…
Read full complaint
TAILGATE STRAP, 1 BROKE ABOUT 2 MONTHS BEFORE THE OTHER ONE BROKE, NOTHING HAS BEEN DONE TO CORRECT THIS, I FIGURE THEY RECALLED ALL THE FULL SIZE TRUCK TO REPLACE THEM ,THEY SHOULD REPLACE THESE AT NO CHARGE. ALSO, IT IS A GOOD THIN I WAS NOT STANDING ON IT WHEN THEY BROKE . I COULD HAVE GOTTEN HURT BY FALLING OFF WHEN THE TAIL GATE FELL TO THE BUMPER.*AK
NHTSA ODI #10118086
25,000 miles · Mar 17, 2005
StructureInjury
THE TAILGATE STRAPS ON MY CHEVROLET S-10 GAVE WAY WHILE I WAS KNEELING ON THE BACK OF THE TRUCK, MY KNEES WERE HURT FOR SEVERAL WEEKS. GM KNOWS THAT THEIR TAILGATE STRAPS ARE DEFECTIVE YET THEY DO NOT WARN THAT THEY MAY JUST GIVE OUT LIKE THEY DO. *AK
NHTSA ODI #10114260
74,000 miles · Mar 8, 2005
Structure
PASSENGER SIDE TAILGATE STRAP ON THE BED OF A 2001 CHEVROLET S-10 BROKE AT THE BEND.*AK
NHTSA ODI #10112694
30,000 miles · Mar 2, 2005
Structure
AFTER LOWERING THE TAILGATE CONSUMER NOTICED PASSENER SIDE TAILGTATE STRAP WAS BROKEN. *AK *TC
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
2001 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration