Electronic Stability Control (esc)Seat BeltsService Brakes
OUR ABS LIGHT KEEPS COMING ON AND WHEN IT DOES THE ABS DON'T WORK. IT COMES ON WHENEVER IT WANTS. IT IS THE SAME ISSUES AS THE 2000 ARE HAVING AND THEY HAVE A RECALL. IT RECENTLY CAUSED THE BACK WHEEL NOT TO MOVE AT ALL. WE WERE TOLD THE SPRING INSIDE THE MODULE IS GOING OUT. IT ALSO AFFECTS THE AIR BAG FROM GOING ON. ALS…
Read full complaint
OUR ABS LIGHT KEEPS COMING ON AND WHEN IT DOES THE ABS DON'T WORK. IT COMES ON WHENEVER IT WANTS. IT IS THE SAME ISSUES AS THE 2000 ARE HAVING AND THEY HAVE A RECALL. IT RECENTLY CAUSED THE BACK WHEEL NOT TO MOVE AT ALL. WE WERE TOLD THE SPRING INSIDE THE MODULE IS GOING OUT. IT ALSO AFFECTS THE AIR BAG FROM GOING ON. ALSO, THE IGNITION WON'T WORK THE TRUCK WON'T START. IT TAKES SEVERAL TRIES TO GET IT TO START. WE WERE JUST TOLD THAT IT'S THE STARTER. THE SEATBELT LOCKS INTERMITTENTLY AND WON'T LET ME MOVE. *TR
NHTSA ODI #10625834
39,000 miles · Jan 20, 2006
Air BagsSeat BeltsCrashFireInjury
DT*: THE CONSUMER STATED WHILE DRIVING AT 35 MPH ANOTHER VEHICLE CAME ACROSS THE MEDIAN AND CRASHED INTO THE VEHICLE. UPON IMPACT THE DRIVER'S SEAT BELT FAILED TO LOCK AND BOTH FRONTAL AIRBAGS FAILED TO DEPLOY. THE CONSUMER SUSTAINED INJURIES TO THE NECK AND BACK. THERE WAS A FIRE COMING FROM THE ENGINE AREA AFTER IMPACT. T…
Read full complaint
DT*: THE CONSUMER STATED WHILE DRIVING AT 35 MPH ANOTHER VEHICLE CAME ACROSS THE MEDIAN AND CRASHED INTO THE VEHICLE. UPON IMPACT THE DRIVER'S SEAT BELT FAILED TO LOCK AND BOTH FRONTAL AIRBAGS FAILED TO DEPLOY. THE CONSUMER SUSTAINED INJURIES TO THE NECK AND BACK. THERE WAS A FIRE COMING FROM THE ENGINE AREA AFTER IMPACT. THE FIRE DEPARTMENT CUT ALL THE ELECTRICAL WIRES TO EXTINGUISH THE FIRE. ALTHOUGH THE POLICE RESPONDED NO REPORT WERE FILED. THE VEHICLE WAS TOWED TO THE DEALERSHIP WERE IT HAS NOT BEEN INSPECTED. *JB
NHTSA ODI #10148230
92,000 miles · Feb 22, 2005
Electrical SystemEngine And Engine CoolingEquipment
2004 TAIL GATE ASS FAILED REPLACED AFTER MARKET PARTS 2004 BACK UP LIGHTS IN/OP;004 INTERRIOR LIGHT WILL NOT TURN OFF/ OVER RIDE BOTTON USED TO SAVE BATTERY2005 LEFT FRONT HUB ASS REPLACED. 004 RIGHT FRONT HUB ASS REPLACED;005 FRONT END REPLACED/PITTMAN/TIE RODS;2004 OIL FILTER LEAK / TIGHTENED 2004 REAR EMERGENCY BR…
Read full complaint
2004 TAIL GATE ASS FAILED REPLACED AFTER MARKET PARTS 2004 BACK UP LIGHTS IN/OP;004 INTERRIOR LIGHT WILL NOT TURN OFF/ OVER RIDE BOTTON USED TO SAVE BATTERY2005 LEFT FRONT HUB ASS REPLACED. 004 RIGHT FRONT HUB ASS REPLACED;005 FRONT END REPLACED/PITTMAN/TIE RODS;2004 OIL FILTER LEAK / TIGHTENED 2004 REAR EMERGENCY BRAKES IN/OP 5 LEFT EMERGENCY BRAKE DRUM REPLACED;005 RIGHT EMERGENCY BRAKE DRUM REPLACED 2005 GAS SENDING UNIT REPLACED ERADIC BEHAVIOR 2004 LEFT BRAKE SHOE REPLACED ;004 RIGHT BRAKE SHOE REPLACED;005 LEFT BRAKE SHOE REPLACED FRONT;005 RIGHT BRAKE SHOE REPLACED FRONT 2005 LEFT BRAKE SHOE REPLACED REAR;005 RIGHT BRAKE SHOE REPLACED REAR;005 U JOINTS REPLACED;04 BATTERY REPLACED 2005 TRANSMISSION SHOWING SIGNS OF WEAR;005 REAR END {3.42} LOCKER CLANGS BETWEEN 1ST AND REVVED. 004 4 TIRES 005 4 TIRES 2004 DOOR HINGES FREEZE UP LUBE;005 TAIL GATE HINGES SHOW WEAR 2005 PARTS 4 EA TIE RODS/O/RING TYPE BRAKE SHOESAND DRUMS/U JOINTS. I HAVE FOR INSPECTION.*AK
NHTSA ODI #10111922
72,820 miles · Aug 1, 2003
Seat BeltsCrashInjury
THE CONSUMER WAS INVOLVED IN A MAJOR COLLISION WHERE THE VEHICLE FLIPPED APPROXIMATELY 6 TIMES AND ULTIMATELY CRASHED INTO A WALL. THE FRONT DRIVER AND PASSENGER SEAT BELTS HAD COME UNLATCHED. *AK THE VEHICLE HYDROPLANED AFTER HITTING WATER IN THE ROAD, SPUN AROUND 5-6 TIMES, FLIPPED BACK TO FRONT, HIT A ROCK WALL, AND FL…
Read full complaint
THE CONSUMER WAS INVOLVED IN A MAJOR COLLISION WHERE THE VEHICLE FLIPPED APPROXIMATELY 6 TIMES AND ULTIMATELY CRASHED INTO A WALL. THE FRONT DRIVER AND PASSENGER SEAT BELTS HAD COME UNLATCHED. *AK THE VEHICLE HYDROPLANED AFTER HITTING WATER IN THE ROAD, SPUN AROUND 5-6 TIMES, FLIPPED BACK TO FRONT, HIT A ROCK WALL, AND FLIPPED ON ITS OUTSIDE. *SCC *JB
NHTSA ODI #10027013
Mileage unknown · Oct 16, 2001
Seat Belts
CLIPS IN THE SEAT BELT DESIGNED TO KEEP THE METAL LATCH IN PLACE FELL OUT, RESULTING IN UNRAVELING. DEALER NOTIFIED AND REPLACED SEAT BELT. BOTH FRONT SEAT BELTS ALSO DO NOT RETRACT PROPERLY; ON OCCASION, THE SEAT BELTS WILL NOT PULL FROM THEIR HOUSINGS AT ALL. *AK
NHTSA ODI #753278
Mileage unknown · Mar 19, 2001
Seat Belts
WEBBING ON DRIVER SIDE SEAT BELT IS UNRAVELING. DEALER IS REPLACING IT. *AK
NHTSA ODI #883322
Mileage unknown · Jan 29, 2001
Seat BeltsService Brakes, Hydraulic
DRIVER'S SIDE SEAT BELT WILL NOT RETRACT FROM HOUSING MECHANISM. ALSO, WHEN VEHICLE WAS STOPPED WITH FOOT DEPRESSED ON BRAKE PEDAL, PEDAL WENT ALL WAY DOWN TO FLOOR . CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
2001 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration