MY 2001 S-10 PICK UP STALLS WHEN DRIVING DOWN THE ROAD. ACTS SIMILAR TO INVESTIGATION PE02-066. TOOK VEHICLE TO DEALER AND EXPLAINED PROBLEM. THEY COULD NOT FIND ANYTHING WRONG. I STILL HAVE THE PROBLEM. TRUCK WAS OUT OF WARRANTY WHEN TAKEN IN HAD 44,106 MILES. SHOULDN'T THE DEALER BEEN AWARE OF YOUR INVESTIGATION AND POSS…
Read full complaint
MY 2001 S-10 PICK UP STALLS WHEN DRIVING DOWN THE ROAD. ACTS SIMILAR TO INVESTIGATION PE02-066. TOOK VEHICLE TO DEALER AND EXPLAINED PROBLEM. THEY COULD NOT FIND ANYTHING WRONG. I STILL HAVE THE PROBLEM. TRUCK WAS OUT OF WARRANTY WHEN TAKEN IN HAD 44,106 MILES. SHOULDN'T THE DEALER BEEN AWARE OF YOUR INVESTIGATION AND POSSIBLY LOOKED AT THIS FILTER?. I THINK YOU SHOULD REOPEN THIS CASE, I THINK THAT THERE IS A SEVERE DEFECT IN THEIR DESIGN. TOMORROW I AM GOING TO DEALER ARMED WITH INFORMATION FROM YOUR WEBSITE AND I AM GOING TO PUT UP A STINK ABOUT THIS. PLEASE TAKE ANOTHER LOOK AT THIS CASE. THANK YOU. SINCERELY, ROBERT A. WRIGHT. *LA
NHTSA ODI #10047434
Mileage unknown · Oct 28, 2003
Engine And Engine CoolingFuel System, GasolineFuel System, Other
CONSUMER STATED THAT VEHICLE IN THE LAST 3 MONTHS IN REPAIR SHOP FOR TRANSMISSION PROBLEMS 9 TIMES. AFTER BRINGING VEHICLE TO REPAIR SHOP SHOP EVERYTHING ELSE STARTED TO BREAK DOWN. ALSO, FUEL PUMP WAS REPLACED 3 TIMES. FUEL GAUGE OPERATED POORLY, AND VEHICLE DIED/STOPPED WHILE DRIVING ON THE ROAD. *AK
NHTSA ODI #10044911
47,003 miles · Jun 26, 2003
Engine And Engine CoolingFuel System, Gasoline
WHILE DRIVING AT 55/70 MPH VEHICLE WILL STALL OUT WITHOUT WARNING. THE DEALERSHIP HAS REPLACED THE CATALYTIC CONVERTER, FUEL PUMP, AND SENDING UNIT.*AK
NHTSA ODI #10024990
40,000 miles · Apr 21, 2003
Fuel System, Gasoline
THERE ARE 40,000 MILES ON MY 2001 S-10 AND THE FUEL PUMP WENT OUT. I FILLED THE TANK FULL OF GAS AND 8 MILES DOWN THE ROAD , THE FUEL PUMP WENT OUT. I HAD THE VEHICLE TOWED TO A CHEVROLET DEALER AND IT COST OVER $900.00 TO REPLACE THE PUMP. $500.00 FOR THE PUMP, $60 FOR THE DIAGNOSTIC, 400.00 FOR THE LABOR. THIS IS UNACCEPTABLE!…
Read full complaint
THERE ARE 40,000 MILES ON MY 2001 S-10 AND THE FUEL PUMP WENT OUT. I FILLED THE TANK FULL OF GAS AND 8 MILES DOWN THE ROAD , THE FUEL PUMP WENT OUT. I HAD THE VEHICLE TOWED TO A CHEVROLET DEALER AND IT COST OVER $900.00 TO REPLACE THE PUMP. $500.00 FOR THE PUMP, $60 FOR THE DIAGNOSTIC, 400.00 FOR THE LABOR. THIS IS UNACCEPTABLE! . *JB
NHTSA ODI #10016272
Mileage unknown · Jan 30, 2002
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
ENGINE HAS STALLED FOUR TIMES UNEXPECTEDLY WHILE DRIVING AT ANY SPEED. DEALERSHIP HAS REPLACED THE FOLLOWING COMPONENTS: CATALYTIC CONVERTER/ FUEL PUMP/ OXYGEN SENSOR, AND IGNITION SWITCH. ALL REPAIRS HAVE FAILED TO EFFECTIVELY REMEDY THE PROBLEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK
NHTSA ODI #8003157
Mileage unknown · Jan 2, 2002
Fuel System, Gasoline
VEHICLE RUNNING OUT OF FUEL WITH A 1/4 TANK SHOWING ON FUEL GAUGE. DEALER WAS NOT NOTIFIED AT THIS TIME. *AK
NHTSA ODI #8001390
Mileage unknown · Sep 7, 2001
Electrical SystemFuel System, GasolineFuel System, Other
FUEL MONITORING SYSTEM DOES NOT WORK PROPERLY, GAUGE DOES NOT GIVE PROPER READING ON HOW MUCH FUEL IS IN THE TANK, CONTACTED DEALER AND DEALER MADE 3 ATTEMPTS TO FIX VEHICLE, DEALER REPLACED GAS SENDING UNIT AND MODULE CLUSTER, BUT STILL HAS NOT CORRECTED PROBLEM, ALSO DEALER FOUND OUT ALL 2001 CREW CAB, S10 HAVE SAME PROBLEM, D…
Read full complaint
FUEL MONITORING SYSTEM DOES NOT WORK PROPERLY, GAUGE DOES NOT GIVE PROPER READING ON HOW MUCH FUEL IS IN THE TANK, CONTACTED DEALER AND DEALER MADE 3 ATTEMPTS TO FIX VEHICLE, DEALER REPLACED GAS SENDING UNIT AND MODULE CLUSTER, BUT STILL HAS NOT CORRECTED PROBLEM, ALSO DEALER FOUND OUT ALL 2001 CREW CAB, S10 HAVE SAME PROBLEM, DEALER WAS TOLD BY MANUFACTURER THAT VEHICLES HAD A PROGRAM PROBLEM IN THE ELECTRONIC MODULE. *AK *SLC
NHTSA ODI #895999
Mileage unknown · Jul 11, 2001
Fuel System, Gasoline
VEHICLE HAD A FUEL LEAK THAT SET OFF SERVICE ENGINE LIGHT. ALSO SMELLED ODOR OF GAS. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
2001 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration