NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
30 reportsClear category filter120,000 miles · May 23, 2007
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 CHEVROLET S10. ON MARCH 7, 2007, THE ENGINE FAILED WHILE DRIVING 35 MPH. THE CONTACT WAITED TEN MINUTES BEFORE THE VEHICLE WAS ABLE TO BE RESTARTED. THIS FAILURE OCCURRED ONCE BEFORE IN 2002. WHEN HE CURRENTLY STARTS THE VEHICLE, THE SECURITY LIGHT FLICKERS AND THE VEHICLE FAILS TO START. THE CONT…
Read full complaint
TL*THE CONTACT OWNS A 2000 CHEVROLET S10. ON MARCH 7, 2007, THE ENGINE FAILED WHILE DRIVING 35 MPH. THE CONTACT WAITED TEN MINUTES BEFORE THE VEHICLE WAS ABLE TO BE RESTARTED. THIS FAILURE OCCURRED ONCE BEFORE IN 2002. WHEN HE CURRENTLY STARTS THE VEHICLE, THE SECURITY LIGHT FLICKERS AND THE VEHICLE FAILS TO START. THE CONTACT STATED THAT THE FAILURE IS THE SAME AS NOTED IN TSB # 010856001. THE VEHICLE WAS PURCHASED IN AUGUST OF 2000. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 125,000 AND FAILURE MILEAGE WAS 120,000.
NHTSA ODI #10191564
Mileage unknown · Aug 7, 2006
Engine And Engine CoolingEquipment
SOON AFTER PURCHASE (SOMETIME IN 2001), CHECK ENGINE LIGHT CAME ON. DIAGNOSED AS WATER IN AIR PUMP AND CHECK VALVE CORRODED OPEN. BROUGHT TO DEALER SEVERAL TIMES TO HAVE REPAIRED WITH ONLY THE LAST SERVICE SUCCESSFUL. FORWARD TO PRESENT. AGAIN, CHECK ENGINE LIGHT ILLUMINATED. COMPUTER SCANNED, SAME DIAGNOSIS. EVEN AFTER PR…
Read full complaint
SOON AFTER PURCHASE (SOMETIME IN 2001), CHECK ENGINE LIGHT CAME ON. DIAGNOSED AS WATER IN AIR PUMP AND CHECK VALVE CORRODED OPEN. BROUGHT TO DEALER SEVERAL TIMES TO HAVE REPAIRED WITH ONLY THE LAST SERVICE SUCCESSFUL. FORWARD TO PRESENT. AGAIN, CHECK ENGINE LIGHT ILLUMINATED. COMPUTER SCANNED, SAME DIAGNOSIS. EVEN AFTER PREVIOUS FAILURES WITH AIR PUMP AND CHECK VALVE, NO LONGER WARRANTED. *JB
NHTSA ODI #10164828
30,000 miles · Jul 27, 2006
Engine And Engine Cooling
I OWN A 2000 CHEVROLET S-10 PICK UP TRUCK. I HAVE A PROBLEM WITH THE CHECK ENGINE LIGHT ON. I TOOK MY VEHICLE TO A CHEVROLET DEALERSHIP THE PAST A COUPLE OF TIMES AND WAS ADVISED THAT THE SMOG PUMP NEEDS TO BE REPLACED. THE DEALER ADVISED ME THAT THIS IS A PROBLEM WITH EVERY 2000 CHEVROLET PICK UP TRUCK AND THAT GM NEEDS TO ISS…
Read full complaint
I OWN A 2000 CHEVROLET S-10 PICK UP TRUCK. I HAVE A PROBLEM WITH THE CHECK ENGINE LIGHT ON. I TOOK MY VEHICLE TO A CHEVROLET DEALERSHIP THE PAST A COUPLE OF TIMES AND WAS ADVISED THAT THE SMOG PUMP NEEDS TO BE REPLACED. THE DEALER ADVISED ME THAT THIS IS A PROBLEM WITH EVERY 2000 CHEVROLET PICK UP TRUCK AND THAT GM NEEDS TO ISSUE A RECALL FOR THIS PROBLEM. I A WRITING TO KNOW WHAT IS THE PROCESS FOR GETTING A RECALL STARTED. THANK YOU. *JB
NHTSA ODI #10163729
45,000 miles · Jul 7, 2005
Engine And Engine CoolingStructureInjury
BROKEN TAILGATE SUPPORT CABLES RUSTED THROUGH RECALL ON OTHER MODELS BESIDES THE S-10
NHTSA ODI #10127839
40,000 miles · Feb 23, 2005
Engine And Engine CoolingService Brakes, Hydraulic
BRAKE LINE FAILED AT AN INTERSECTION, TOTAL LOSS OF BRAKE PRESSURE. CHEVROLET NOTIFIED, DEALER COULD NOT FIND PROBLEM, PART TOOK A WEEK TO ARRIVE, AND WE JUST FIXED IT AT HOME OUT OF EXASPIRATION FOR THE DEALER, CHEVY WAS GREAT THOUGH, LINE FOUND WORN RIGHT THROUGH. MANY FAILURES WITH THIS VEHICLE. WENT THROUGH 3 BATTERIES AND …
Read full complaint
BRAKE LINE FAILED AT AN INTERSECTION, TOTAL LOSS OF BRAKE PRESSURE. CHEVROLET NOTIFIED, DEALER COULD NOT FIND PROBLEM, PART TOOK A WEEK TO ARRIVE, AND WE JUST FIXED IT AT HOME OUT OF EXASPIRATION FOR THE DEALER, CHEVY WAS GREAT THOUGH, LINE FOUND WORN RIGHT THROUGH. MANY FAILURES WITH THIS VEHICLE. WENT THROUGH 3 BATTERIES AND 2 ALTERNATORS. UPPER BALL JOINT FAILED ON THE HIGHWAY, PARTS DEPARTMENT TRIED TO SAY BECAUSE IT WASNT GREASED, BUT I KEEP IT GREASED, THE BALL BROKE RIGHT OUT THE SIDE, ALL BALL JOINTS REPLACED. IDLER ARM FOUND BROKEN WHEN VEHICLE TAKEN FOR RE-ALIGNMENT BEFORE THAT. VARIOUS ELECTRICAL FAILURES (SUSPECTED SHORT SOMEWHERE AS BATTERY SPARKS WHEN RECONNECTED). FUEL PUMP FAILURE AT 65,000 MILES, PRECEEDING FUEL GUAGE MALFUNCTION ABOUT 6 MO'S BEFORE, REPLACED FUEL PUMP. HEATING FAILURE SUSPECTED DUE TO DEX-COOL COOLANT (COOLANT SOLIDIFIES AND JAMS HEATER CORE, ECT...), VEHICLE REVERSE FLUSHED, AND NEW THERMOSTAT INSTALLED, NOT MUCH IMPROVEMENT, BLOWS HARDER BUT STILL COLD. TRANSMISSION SLIPS ON OCCASION. CURRENTLY LEAKS STEERING FLUID, THIS HAS NOT BEEN CORRECTED AS I BOUGHT A NEW TRUCK, AND HAVE NOT HAD TIME TO FIX THE S10. WATER COMING IN FROM SOMEWHERE, CARPET CONSISTENTLY SOAKED. VERY UNHAPPY WITH VEHICLE WITH SO MANY REPAIRS, TRUCK ONLY HAS 70,000 MILES, COMPONENTS FAILED FAR BEFORE THEIR TIME, MORE MINOR THINGS WRONG BUT REPAIRED. WE ARE LUCKY TO HAVE A GARAGE AND A WHOLE LOT OF TOOLS FOR THIS VEHICLE. *AK
NHTSA ODI #10112075
Mileage unknown · Aug 17, 2004
Engine And Engine Cooling
WHILE DRIVING CHECK ENGINE LIGHT FLASHED ON THE DASHBOARD AND REMAINED ON. THEN, VEHICLE STALLED. CONSUMER WAS UNABLE TO RESTART VEHICLE, AND HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE ENGINE NEEDED TO BE REPLACED DUE TO SLUDGE INSIDE OF THE ENGINE. *AK
NHTSA ODI #10089096
44,000 miles · Jul 29, 2004
Engine And Engine Cooling
2000 S-10 VORTEC V-6 ENGINE HAVING MANY PROBLEMS WITH COOLING SYSTEM SLUDGE .*AK
NHTSA ODI #10082976
Mileage unknown · Mar 20, 2004
Electrical SystemEngine And Engine CoolingExterior Lighting
I BOUGHT THE CHEVY WITH ONLY 30,000 MILES ON IT. BUT EVER SINCE THE BEGINNING THE THIRD BRAKE LIGHT HAS NEVER WORKED AND I ALWAYS REPLACE THE FUSES AND THE LITTLE LIGHT BULBS. ALSO HAVE HAD TROUBLE WITH THE TRANSMISSION AND HAVE HAD IT REBUILT AND THE RADIATOR TWICE. I JUST HAVE HAD MORE THAN ENOUGH PROBLEMS WITH THE TRUCK I R…
Read full complaint
I BOUGHT THE CHEVY WITH ONLY 30,000 MILES ON IT. BUT EVER SINCE THE BEGINNING THE THIRD BRAKE LIGHT HAS NEVER WORKED AND I ALWAYS REPLACE THE FUSES AND THE LITTLE LIGHT BULBS. ALSO HAVE HAD TROUBLE WITH THE TRANSMISSION AND HAVE HAD IT REBUILT AND THE RADIATOR TWICE. I JUST HAVE HAD MORE THAN ENOUGH PROBLEMS WITH THE TRUCK I REGRET BUYING THIS TRUCK. *JB
NHTSA ODI #10062662
75,000 miles · Mar 16, 2004
Engine And Engine Cooling
WHILE DRIVING AT 70 MPH OR STOPPING AT A LIGHT VEHICLE INTERMITTENTLY STALLED. THIS OCCURRED AT LEAST 3 TIMES IN A HALF HOUR DRIVE. *AK
NHTSA ODI #10063316
Mileage unknown · Jan 28, 2004
Engine And Engine Cooling
WHILE TRAVELING CONSUMER HEARD A LOUD NOISE COMING FROM FRONT END OF VEHICLE. CONSUMER INSPECTED VEHICLE, AND DETERMINED THAT ENGINE HAD DROPPED DOWN, LEAKING AN UNKNOWN FLUID. *AK
NHTSA ODI #10055974
Official recalls
4Sep 8, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH INCORRECT PAYLOAD INFORMATION ON THE VEHICLE CERTIFICATION LABEL. THE PAYLOAD SHOWN ON THE LABEL IS GREATER THAN THE MAXIMUM VALIDATED PAYLOAD. IF THE VEHICLE WERE LOADED TO THE INCORRECTLY LABELED PAYLOAD, IT MAY NOT RIDE AND HANDLE IN THE MANNER THAT THE DRIVER EXPECTS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF CONTROL OF THE VEHICLE OR AN INABILITY TO STOP THE VEHICLE WITHIN EXPECTED STOPPING DISTANCES.
Remedy: OWNERS WILL BE SENT A NEW LABEL FOR INSTALLATION ON THE DRIVER'S DOOR OF THE VEHICLE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Feb 28, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4-WHEEL DISC BRAKES. SOME OF THESE VEHICLES HAVE AN ANTILOCK BRAKE SYSTEM (ABS) MOTOR CONTAINING AN OUT-OF-SPECIFICATION SPRING CLIP. THIS CLIP COULD ALLOW THE MOTOR BEARING TO BECOME MISALIGNED. IF MISALIGNMENT OCCURS, EVENTUALLY THE ABS WOULD BE NON-FUNCTIONAL.
Consequence & remedy
Consequence: THE BASE BRAKES WOULD REMAIN FULLY FUNCTIONAL, BUT THE DYNAMIC REAR PROPORTIONING (DRP) SYSTEM, WHICH OPTIMIZES FRONT TO REAR BRAKE BALANCE, WOULD BECOME INOPERATIVE.
Remedy: DEALERS WILL REPLACE THE BRAKE PRESSURE MODULE VALVE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Illustration