NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
26 reportsClear category filter92,000 miles · Nov 12, 2007
Electrical System
THIS COMPLAINT IS ABOUT THE 2000 CHEVROLET S-10 PICKUP TRUCK WITH THE 4 CLN. MOTOR. IT FIRST STARTED GOING DEAD WHILE DRIVING UP THE ROAD. I WOULD PULL OVER, TURN IT COMPLETELY OFF AND RESTART IT WITHOUT A PROBLEM. AFTER GIVING IT A TUNE UP IT STOPPED GOING DEAD BUT BEGAN STALLING WHEN TRYING TO PULL OFF FROM A STOP SIGN OR TR…
Read full complaint
THIS COMPLAINT IS ABOUT THE 2000 CHEVROLET S-10 PICKUP TRUCK WITH THE 4 CLN. MOTOR. IT FIRST STARTED GOING DEAD WHILE DRIVING UP THE ROAD. I WOULD PULL OVER, TURN IT COMPLETELY OFF AND RESTART IT WITHOUT A PROBLEM. AFTER GIVING IT A TUNE UP IT STOPPED GOING DEAD BUT BEGAN STALLING WHEN TRYING TO PULL OFF FROM A STOP SIGN OR TRAFFIC LIGHT. I WOULD BE SURPRISED IF NO ONE HAS BEEN KILLED YET BECAUSE OF THIS. I HAVE ASKED SEVERAL PEOPLE I HAVE SEEN WITH THIS TYPE OF TRUCK AND THEY HAVE HAD THE SAME PROBLEM. *TR
NHTSA ODI #10208720
150,554 miles · May 8, 2007
Electrical SystemFire
TL*THE CONTACT OWNS A CHEVROLET S10. THE CONTACT STARTED THE VEHICLE AND SMOKE BEGAN TO RISE FROM UNDER THE HOOD. NO FLAMES WERE VISIBLE. THE VEHICLE WAS DRIVEN TO THE REPAIR SHOP. THE HEADLIGHTS, TAIL LIGHTS, AND BLINKERS FAILED TO ACTIVATE. WHEN THE BRAKES WERE DEPRESSED, THE FUSE BLEW WITHOUT WARNING. THE MECHANIC RE-S…
Read full complaint
TL*THE CONTACT OWNS A CHEVROLET S10. THE CONTACT STARTED THE VEHICLE AND SMOKE BEGAN TO RISE FROM UNDER THE HOOD. NO FLAMES WERE VISIBLE. THE VEHICLE WAS DRIVEN TO THE REPAIR SHOP. THE HEADLIGHTS, TAIL LIGHTS, AND BLINKERS FAILED TO ACTIVATE. WHEN THE BRAKES WERE DEPRESSED, THE FUSE BLEW WITHOUT WARNING. THE MECHANIC RE-SPLICED THE WIRING. THE CONTACT HAS THE REPAIR INVOICE. THE CURRENT AND FAILURE MILEAGES WERE 150,554. UPDATED 07/06/07 *TR
NHTSA ODI #10190166
70,000 miles · Feb 10, 2006
Electrical System
DT*: THE CONTACT STATED WHEN TURNING THE KEY IN THE IGNITION, IT WOULD NOT RELEASE TO THE NEUTRAL POSITION. THIS CAUSED THE STARTER TO GRIND AND THE VEHICLE WOULD NOT TURN OFF. THE CONTACT DISCONNECTED THE BATTERY AND FUEL PUMP AND HAD THE VEHICLE TOWED TO THE DEALERSHIP. THE DEALERSHIP REPLACED THE IGNITION CYLINDER. THE P…
Read full complaint
DT*: THE CONTACT STATED WHEN TURNING THE KEY IN THE IGNITION, IT WOULD NOT RELEASE TO THE NEUTRAL POSITION. THIS CAUSED THE STARTER TO GRIND AND THE VEHICLE WOULD NOT TURN OFF. THE CONTACT DISCONNECTED THE BATTERY AND FUEL PUMP AND HAD THE VEHICLE TOWED TO THE DEALERSHIP. THE DEALERSHIP REPLACED THE IGNITION CYLINDER. THE PROBLEM RETURNED AND THE IGNITION CYLINDER WAS REPLACED A SECOND TIME. UPDATED 03/09/06. *JB
NHTSA ODI #10149981
55,000 miles · Jun 3, 2005
Electrical SystemCrash
DT: CONSUMER TURNED TO GO UP HILL AND VEHICLE DIDN'T STALL, BUT WANTED TO, AS IF IT DID NOT GET ENOUGH FUEL. THIS HAPPENED TWICE. CONSUMER SAYS THAT WHEN SHE APPLIED BRAKE, THE VEHICLE REVVED AND ACTED AS IF REGAINING POWER BACK THEN ACCELERATED QUICKLY. THIS HAPPENED ABOUT TWO WEEKS AGO. CONSUMER SHUT VEHICLE OFF, AND WHEN …
Read full complaint
DT: CONSUMER TURNED TO GO UP HILL AND VEHICLE DIDN'T STALL, BUT WANTED TO, AS IF IT DID NOT GET ENOUGH FUEL. THIS HAPPENED TWICE. CONSUMER SAYS THAT WHEN SHE APPLIED BRAKE, THE VEHICLE REVVED AND ACTED AS IF REGAINING POWER BACK THEN ACCELERATED QUICKLY. THIS HAPPENED ABOUT TWO WEEKS AGO. CONSUMER SHUT VEHICLE OFF, AND WHEN STARTED BACK IT WAS FINE. WHEN ATTEMPTING TO GET ON FREEWAY PARKWAY WEST 279 IN GREENTREE, VEHICLE ACCELERATED WHEN CONSUMER APPLIED BRAKE, HITTING ANOTHER VEHICLE IN THE REAR. THIS HAPPENED A FEW DAYS LATER. *TT
NHTSA ODI #10124095
Mileage unknown · Dec 21, 2004
Electrical SystemFire
FIRE LOSS TO 2000 CHEVROLET S10 BLAZER. FIRE LOSS TO 2002 CHEVROLET EXPRESS CARGO VAN NO KNOWN CAUSE OF FIRE TO BOTH VEHICLES. *AK THE VEHICLE SPONTANEOUSLY IGNITED A FIRE THAT DESTROYED THE VEHICLE. *SC
NHTSA ODI #10102210
Mileage unknown · Sep 29, 2004
Electrical System
CRUISE CONTROL ACCELERATING AND CAN NOT BE SHUT OFF. *BF THE CONSUMER HAD FOUR SEPARATE INCIDENTS WITH HIS VEHICLE IN WHICH CUISE CONTROL STARTS ACCELORATING AND CON NOT BE SHUT OFF UNLESS THE CONSUMER TURNS OFF VEHICLE.
NHTSA ODI #10095476
75,000 miles · Aug 17, 2004
Electrical SystemFire
VEHICLE CAUGHT ON FIRE WHILE PARKED IN THE DRIVEWAY. LOCAL FIRE DEPTARTMENT ARRIVED TO EXTINGUISH THE FIRE. IT WAS CAUSED BY AN ELECTRICAL SHORT. *AK
NHTSA ODI #10088077
Mileage unknown · Mar 20, 2004
Electrical SystemEngine And Engine CoolingExterior Lighting
I BOUGHT THE CHEVY WITH ONLY 30,000 MILES ON IT. BUT EVER SINCE THE BEGINNING THE THIRD BRAKE LIGHT HAS NEVER WORKED AND I ALWAYS REPLACE THE FUSES AND THE LITTLE LIGHT BULBS. ALSO HAVE HAD TROUBLE WITH THE TRANSMISSION AND HAVE HAD IT REBUILT AND THE RADIATOR TWICE. I JUST HAVE HAD MORE THAN ENOUGH PROBLEMS WITH THE TRUCK I R…
Read full complaint
I BOUGHT THE CHEVY WITH ONLY 30,000 MILES ON IT. BUT EVER SINCE THE BEGINNING THE THIRD BRAKE LIGHT HAS NEVER WORKED AND I ALWAYS REPLACE THE FUSES AND THE LITTLE LIGHT BULBS. ALSO HAVE HAD TROUBLE WITH THE TRANSMISSION AND HAVE HAD IT REBUILT AND THE RADIATOR TWICE. I JUST HAVE HAD MORE THAN ENOUGH PROBLEMS WITH THE TRUCK I REGRET BUYING THIS TRUCK. *JB
NHTSA ODI #10062662
15,040 miles · Jan 15, 2004
Electrical SystemExterior LightingService Brakes, Hydraulic
PASSLOCK FAILED ON SEVERAL OCCASSIONS. DEALER REPAIRED EACH TIME AT NO CHARGE(WARRENTY) BRAKES FAILED BEFORE 15000MILES, HAD TO REPLACE BOTH FRONT ROTORS. DEALER REFUSES TO ACKNOWLEDGE ANY FAULT OR REIMBURSEMENT. WE BELEIVE THAT SINCE THE MILLAGE IS SO LOW, THE DEALER SHOULD REIMBURSE US FOR THE REPAIRS.
NHTSA ODI #10069551
30,000 miles · Apr 8, 2003
Electrical System
THE VEHICLE DOES NOT START EASILY, IT TAKES A COUPLE OF TRIES AFTER IT HAS BEEN SITTING. *NLM
NHTSA ODI #10014152
Official recalls
4Sep 8, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH INCORRECT PAYLOAD INFORMATION ON THE VEHICLE CERTIFICATION LABEL. THE PAYLOAD SHOWN ON THE LABEL IS GREATER THAN THE MAXIMUM VALIDATED PAYLOAD. IF THE VEHICLE WERE LOADED TO THE INCORRECTLY LABELED PAYLOAD, IT MAY NOT RIDE AND HANDLE IN THE MANNER THAT THE DRIVER EXPECTS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF CONTROL OF THE VEHICLE OR AN INABILITY TO STOP THE VEHICLE WITHIN EXPECTED STOPPING DISTANCES.
Remedy: OWNERS WILL BE SENT A NEW LABEL FOR INSTALLATION ON THE DRIVER'S DOOR OF THE VEHICLE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Feb 28, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4-WHEEL DISC BRAKES. SOME OF THESE VEHICLES HAVE AN ANTILOCK BRAKE SYSTEM (ABS) MOTOR CONTAINING AN OUT-OF-SPECIFICATION SPRING CLIP. THIS CLIP COULD ALLOW THE MOTOR BEARING TO BECOME MISALIGNED. IF MISALIGNMENT OCCURS, EVENTUALLY THE ABS WOULD BE NON-FUNCTIONAL.
Consequence & remedy
Consequence: THE BASE BRAKES WOULD REMAIN FULLY FUNCTIONAL, BUT THE DYNAMIC REAR PROPORTIONING (DRP) SYSTEM, WHICH OPTIMIZES FRONT TO REAR BRAKE BALANCE, WOULD BECOME INOPERATIVE.
Remedy: DEALERS WILL REPLACE THE BRAKE PRESSURE MODULE VALVE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA05008 · Tailgate Support Cables
Opened Apr 14, 2005 · Closed May 19, 2006
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch
GENERAL MOTORS IS CONDUCTING A SPECIAL POLICY PROGRAM FOR 903,464 OWNERS OF 2000 - 2003 MODEL S/T VEHICLES THROUGH WHICH OWNERS MAY, AT THEIR OPTION, EITHER (1) PERIODICALLY INSPECT THE TAILGATE SUPPORT CABLES INSTALLED IN THEIR VEHICLE AND HAVE THE CABLES REPLACED IF THE CABLE COATING EXHIBITS ANY INDICATIONS OF DAMAGE OR DETERIORATION OR (2) REQUEST THAT THE TAILGATE SUPPORT CABLES BE REPLACED FREE OF CHARGE. GM WILL HONOR ALL REQUESTS BY OWNERS WHO OPT FOR REPLACEMENT WITHOUT QUESTION REGARDLESS OF THE CONDITION OR APPEARANCE OF THE CABLES. GM HAS AGREED TO MAIL REMINDER NOTIFICATIONS TO OWNERS EVERY TWO YEARS UNTIL THE TAILGATE SUPPORT CABLES HAVE BEEN REPLACED OR UNTIL THE VEHICLE IS 12 YEARS OLD.ODI'S INVESTIGATION INDICATES THAT A SIGNIFICANT MAJORITY OF THE REPORTED COMPLAINTS (87%) AND INJURIES (94%) HAVE OCCURRED IN MY 2000 - 2003 S/T VEHICLES.
RQ04012 · Tailgate Support Cable(s) Break
Opened Nov 22, 2004 · Closed Apr 14, 2005
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI IS UPGRADING RQ04-012 AND OPENING AN EA TO INVESTIGATE THE TAILGATE SUPPORT CABLES INSTALLED IN 1998 - 2004 MODEL YEAR SONOMA AND S10 MODEL VEHICLES.GENERAL MOTORS IS CONDUCTING RECALL CAMPAIGN 04V-129 TO REPLACE THE TAILGATE SUPPORT CABLES ORIGINALLY INSTALLED IN CERTAIN MODEL YEAR 2000-2004 SIERRAS AND SILVERADOS AND CERTAIN MODEL YEAR 2002-2004 AVALANCHES AND ESCALADE EXTS (C/K MODELS).GENERAL MOTORS HAS ADVISED ODITHAT THE TAILGATE SUPPORT CABLES INSTALLED IN THE SUBJECT VEHICLES WERE FABRICATED USING IDENTICAL OR SIMILAR SHEATHING MATERIAL AS THE RECALLED VEHICLES.HOWEVER,GENERAL MOTORS HAS ADVISED ODI THAT SONOMA AND S-10 VEHICLES DIFFER FROM C/K MODELS IN SEVERAL WAYS: THE VEHICLE HEIGHT IS LOWER; THE TAILGATE DISPLACEMENT (DROP) WHEN NOT SUPPORTED BY THE CABLES IS SMALLER AND THE TAILGATE COMES TO REST AT A LESS SEVERE TIP ANGLE WHEN NOT SUPPORTED BY THE CABLES; THE TAILGATE MASS IS SMALLER; AND THE SIZE, PAYLOAD, AND USAGE CHARACTERISTCIS ARE LESS DEMANDING THAN C/K MODEL VEHICLES.GM ALSO STATED THAT SONOMA AND S-10 WARRANTY CLAIM INFORMATION INDICATES A LOWER CLAIM COUNT AND A LOWER CLAIM RATE THAN RECALLED C/K MODELS.NOTWITHSTANDING THE ABOVE INFORMATION, ODI HAS RECEIVED AN ADDITIONAL 73 NON-INJURY COMPLAINTS AND 10 INJURY COMPLAINTS ON THE SUBJECT VEHICLES DURING RQ04-012 (SINCE NOVEMBER 2004 TO DATE), WHICH JUSTIFIES OPENING AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS ISSUE.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Illustration