IllustrationWHILE OPENING THE TAILGATE THE STRAPS BROKE AND CAUSED THE TAILGATE TO COLLAPSE COMPLETELY TO THE GROUND. DEALER NOTIFIED, AND INFORMED CONSUMER THAT IT WAS NOT COVERED UNDER A RECALL. *AK
1997 Chevrolet S10
Owner reports · Recalls · Investigations
More warning signs than most S10 years
Owner complaints for the 1997 Chevrolet S10 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 109 of 469 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 113 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
62 crash reports8 fire reports33 injury reports
Structure complaints
20 reportsFRAME IS CRACKED, TWO BODY SHOPS STATED IT IS A FATIGUE CRACK DUE TO DEFECTIVE METAL USED DURING THE MANUFACTURING OF THE VEHICLE. GMC HAS STATED THEY ARE NOT WILLING TO DO ANYTHING AS THE VEHICLE IS OVER THE WARRANTY, HOWEVER, THE VEHICLE IS ONLY FOUR YEARS OLD AND NEVER BEEN IN A SERIOUS ACCIDENT. BOTH BODY SHOPS, AN INDEPEN…
Read full complaint
FRAME IS CRACKED, TWO BODY SHOPS STATED IT IS A FATIGUE CRACK DUE TO DEFECTIVE METAL USED DURING THE MANUFACTURING OF THE VEHICLE. GMC HAS STATED THEY ARE NOT WILLING TO DO ANYTHING AS THE VEHICLE IS OVER THE WARRANTY, HOWEVER, THE VEHICLE IS ONLY FOUR YEARS OLD AND NEVER BEEN IN A SERIOUS ACCIDENT. BOTH BODY SHOPS, AN INDEPENDENT SHOP AND BOB MAGUIRE CHEVROLET BODY SHOP, HAVE AGREED THIS IS NOT A WEARABLE PART AND NEVER SHOULD HAVE CRACKED. EVEN WITH 500,000 MILES THE FRAME SHOULD NOT CRACK. I TAKE CARE OF MY VEHICLES, OTHERWISE I WOULD NOT BE ABLE TO GET 179,000 MILES ON THE TRUCK. I HAVE A 1991 CHEVROLET SILVERADO AT HOME THAT HAS 286,000+ MILES ON IT AND STILL HAS THE ORIGINAL FRAME WITH NO CRACKS. I STILL HAVE 10 PAYMENTS LEFT ON THE S10 AND THE TRUCK IS UNSAFE TO DRIVE. THE BODY SHOP MANAGER AT BOB MAGUIRE HAS INFORMED ME THAT HE WOULD NOT EVEN DRIVE THE TRUCK AROUND THE CORNER, THAT IS HOW UNSAFE THIS VEHICLE IS. I BELIEVE CHEVROLET SHOULD BE RESPONSIBLE FOR REPLACING THE FRAME OR TRUCK, AS I INTENDED TO HAVE THIS TRUCK IN USE FOR ANOTHER FIVE PLUS YEARS, AS I HAVE DONE WITH MY 1991 THAT IS STILL ON THE ROAD. I WAS TOLD THAT I WAS VERY LUCKY THAT I NOTICED THE CRACK, AS IT WAS JUST ABOUT TO BREAK ALL THE WAY THROUGH AND I WOULD HAVE BEEN IN A VERY SERIOUS ACCIDENT IF IT HAD. IF THE ENTIRE FRAME IS NOT REPLACED, HOW WOULD ONE KNOW IF THE VEHICLE WILL EVER HAVE ITS FULL INTEGRITY AGAIN, AS OTHER PARTS OF THE FRAME MIGHT HAVE ADDITIONAL DEFECTS, AS WELL. IF YOU NEED ANY ADDITIONAL INFORMATION, PLEASE CALL ME. ALSO BRUCE IS THE BODY SHOP MANAGER AT BOB MAGUIRE AND IS WILLING TO ANSWER ANY QUESTIONS.*AK
CONSUMER OPENED THE TAILGATE AND WENT TO APPLY HIS KNEE AND JUST BEFORE HIS FOOT TOUCHED TAILGATE RAIL. TAILGATE COLLAPSED IN FRONT OF HIM ONTO THE GROUND. CONSUMER NOTIFIED THE DEALERSHIP, AND HE TOLD HIM THAT HE WAS OUT OF WARRANTY.*AK
FLOOR BEHIND BENCH SEAT IS SPLITTING. IF THE FLOOR SPLITS ALL THE WAY , SEAT WILL COME DOWN ON THE BREAK LINE. DEALER IS TRYING TO LOOK INTO THE PROBLEM. CONSUMER IS IN THE PROCESS OF CONTACTING THE MANUFACTURER. *AK
I HAVE REPLACED THE LEAF SPRINGS AND THE REAR SHOCKS AND THE RIGHT SIDE OF THE TRUCK MEASURES 9 3/4 AND THE LEFT IS 8 3/4 FROM THE TOP OF THE WHEEL WELL TO THE TIRE, THE DEALER AGREES THAT IT IS OFF BUT THEY SAY IT IS WITHIN GM SPECS, THEY HAVE YET TO SHOW ME THIS BOOK WITH THE SPECS IN IT. I CALLED THE GM CONSUMER HOTLINE AND T…
Read full complaint
I HAVE REPLACED THE LEAF SPRINGS AND THE REAR SHOCKS AND THE RIGHT SIDE OF THE TRUCK MEASURES 9 3/4 AND THE LEFT IS 8 3/4 FROM THE TOP OF THE WHEEL WELL TO THE TIRE, THE DEALER AGREES THAT IT IS OFF BUT THEY SAY IT IS WITHIN GM SPECS, THEY HAVE YET TO SHOW ME THIS BOOK WITH THE SPECS IN IT. I CALLED THE GM CONSUMER HOTLINE AND THEY JUST TOLD ME THE SAME THING AS THE DEALER. SO I E-MAILED CLARK HOWARD AND NOW YOU, THIS IS COUSING UNDUE WEAR ON MY TIRES AND I HAVE A WIFE AND A LITTLE BOY TO THINK OF, I WANT TO KNOW IF THEY ARE BEING TRUTHFULL? THANK YOU.
ENGINE OIL LEAK. *YC
DRIVER GETS A SOUND AS IF THE THROW OUT BEARING ON THE CLUTCH IS GOING OUT, BUT THE MANUFACTORER OF THE VEHICLE SAY IT IS NORMAL. YH
CLEAR COAT FINISH DOES NOT PROTECT PAINT.
FRONT BRAKES FAILED.
WHEN DRIVING VEHICLE TILTS TO LEFT SIDE. HAS TO HOLD TIGHTLY TO STEERING WHEEL TO KEEP VEHICLE ON ROAD. TAKEN IT TO DEALER WHO NOTICED FRAME WAS BENT & OUT OF ALIGNMENT. ALSO TRANSMISSION HAS SLIPPAGE. *AK
Official recalls
603V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V159000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jun 16, 2000
VEHICLE DESCRIPTION: ELECTRIC PICKUP TRUCKS. A CONDITION IN WHICH THE FUEL-FIRED HEATER FILL PIPE GROUND STRAP CONTACTS THE REAR PASSENGER SIDE BRAKE PIPE.
Consequence & remedy
Consequence: THIS COULD WEAR OFF THE CORROSION PROTECTION ON THE BRAKE PIPE, LEADING TO PREMATURE CORROSION AND EVENTUAL LOSS OF BRAKE PIPE INTEGRITY. WHEN BRAKE PIPE INTEGRITY IS LOST, BRAKE FLUID LEAKAGE CAN OCCUR.
Remedy: DEALERS WILL RELOCATE THE GROUND STRAP ATTACHMENT, INSPECT THE BRAKE PIPE FOR WEAR, AND REPLACE THE BRAKE PIPE IF NECESSARY.
00V069200 · Electrical SYSTEM:12V/24V/48V Battery
Mar 3, 2000
VEHICLE DESCRIPTION: GENERATION 1 ELECTRIC LIGHT DUTY PICKUP TRUCKS. THESE VEHICLES WERE BUILT WITH A CHARGE PORT ASSEMBLY THAT COULD FAIL DURING A CHARGING EVENT.
Consequence & remedy
Consequence: HEAT COULD BUILD UP WITHIN THE CHARGE PORT AND A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE CHARGE PORT ASSEMBLY WITH A REDESIGNED CHARGE PORT ASSEMBLY.
98V177000 · Visibility:defroster/defogger/hvac System
Aug 4, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH ELECTRIC DRIVE. RAPID FOGGING OF THE INTERIOR GLASS CAN OCCUR WITHIN TWO MINUTES AFTER THE HEAT IS TURNED ON IF (1) THE OUTSIDE TEMPERATURE IS BETWEEN 35 AND 76 DEGREES FAHRENHEIT AND (2) WATER HAS COLLECTED ON THE HEAT EXCHANGER DURING PREVIOUS OPERATION OF THE AIR CONDITIONING.
Consequence & remedy
Consequence: IF RAPID FOGGING WERE TO OCCUR DURING DRIVING, IT COULD OBSTRUCT THE DRIVER'S VISION INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: OWNERS ARE BEING PROVIDED WITH A CAUTION LABEL AND SUPPLEMENTAL INSERT FOR THEIR OWNER'S MANUAL ADVISING THEM TO FOLLOW A "STOP AND WAIT" PROCEDURE TO HELP AVOID WINDOW FOGGING WHILE DRIVING.
97V146001 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Sep 11, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ04002 · Driver's Seat Belt Buckle Assembly
Opened Feb 18, 2004 · Closed May 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:webbing
ON FEBRUARY 18, 2004, ODI OPENED THIS RECALL QUERY (RQ) BASED ON TWO FATALITY REPORTS INVOLVING MY 1997 GM S-10 PICKUP TRUCKS.EACH REPORT ALLEGED THAT THE BELTED DRIVER OCCUPANT WAS EJECTED IN A MULTIPLE-ROTATION ROLLOVER CRASH.THE MY 1997 S/T SERIES PICKUPS USE AN ENERGY-ABSORBING LOOP IN THE DRIVER SEAT BELT THAT ALLOWS THE WEBBING TO ELONGATE UP TO 10 INCHES (TO MITIGATE DRIVER INJURY IN FRONTAL CRASHES).GM ALSO USED THIS ENERGY-ABSORBING LOOP SEAT BELT DESIGN IN MY1997 S/T SERIES UTILITY VEHICLES (CHEVROLET BLAZER, GMC JIMMY AND OLDSMOBILE BRAVADA).GM CONDUCTED A SAFETY RECALL CAMPAIGN (03V-117) TO REPLACE THE DRIVER SEAT BELT IN THESE UTILITY VEHILCES BASED ON A HIGHER FATALITY RATE OF EJECTED BELTED DRIVERS IN ROLLOVER CRASHES.BOTH FATAL CRASHES ARE SEVERE ROLLOVER CRASHES (MULTIPLE-ROTATION ROLLOVER) AND BOTH VEHICLES SUSTAINED DAMAGE TO THE ROOF STRUCTURE.ODI REVIEWED THE FIELD DATA PERFORMANCE OF THE SUBJECT VEHICLES AND COMPARED THEM TO PEER VEHICLES USING NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE FARS DATA DID NOT INDICATE A FIELD PERFORMANCE TREND FOR THE SUBJECT VEHICLE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Seat Belts:front
ON FEBRUARY 18, 2004, ODI OPENED THIS RECALL QUERY (RQ) BASED ON TWO FATALITY REPORTS INVOLVING MY 1997 GM S-10 PICKUP TRUCKS.EACH REPORT ALLEGED THAT THE BELTED DRIVER OCCUPANT WAS EJECTED IN A MULTIPLE-ROTATION ROLLOVER CRASH.THE MY 1997 S/T SERIES PICKUPS USE AN ENERGY-ABSORBING LOOP IN THE DRIVER SEAT BELT THAT ALLOWS THE WEBBING TO ELONGATE UP TO 10 INCHES (TO MITIGATE DRIVER INJURY IN FRONTAL CRASHES).GM ALSO USED THIS ENERGY-ABSORBING LOOP SEAT BELT DESIGN IN MY1997 S/T SERIES UTILITY VEHICLES (CHEVROLET BLAZER, GMC JIMMY AND OLDSMOBILE BRAVADA).GM CONDUCTED A SAFETY RECALL CAMPAIGN (03V-117) TO REPLACE THE DRIVER SEAT BELT IN THESE UTILITY VEHILCES BASED ON A HIGHER FATALITY RATE OF EJECTED BELTED DRIVERS IN ROLLOVER CRASHES.BOTH FATAL CRASHES ARE SEVERE ROLLOVER CRASHES (MULTIPLE-ROTATION ROLLOVER) AND BOTH VEHICLES SUSTAINED DAMAGE TO THE ROOF STRUCTURE.ODI REVIEWED THE FIELD DATA PERFORMANCE OF THE SUBJECT VEHICLES AND COMPARED THEM TO PEER VEHICLES USING NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE FARS DATA DID NOT INDICATE A FIELD PERFORMANCE TREND FOR THE SUBJECT VEHICLE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Seat Belts:front:webbing
ON FEBRUARY 18, 2004, ODI OPENED THIS RECALL QUERY (RQ) BASED ON TWO FATALITY REPORTS INVOLVING MY 1997 GM S-10 PICKUP TRUCKS.EACH REPORT ALLEGED THAT THE BELTED DRIVER OCCUPANT WAS EJECTED IN A MULTIPLE-ROTATION ROLLOVER CRASH.THE MY 1997 S/T SERIES PICKUPS USE AN ENERGY-ABSORBING LOOP IN THE DRIVER SEAT BELT THAT ALLOWS THE WEBBING TO ELONGATE UP TO 10 INCHES (TO MITIGATE DRIVER INJURY IN FRONTAL CRASHES).GM ALSO USED THIS ENERGY-ABSORBING LOOP SEAT BELT DESIGN IN MY1997 S/T SERIES UTILITY VEHICLES (CHEVROLET BLAZER, GMC JIMMY AND OLDSMOBILE BRAVADA).GM CONDUCTED A SAFETY RECALL CAMPAIGN (03V-117) TO REPLACE THE DRIVER SEAT BELT IN THESE UTILITY VEHILCES BASED ON A HIGHER FATALITY RATE OF EJECTED BELTED DRIVERS IN ROLLOVER CRASHES.BOTH FATAL CRASHES ARE SEVERE ROLLOVER CRASHES (MULTIPLE-ROTATION ROLLOVER) AND BOTH VEHICLES SUSTAINED DAMAGE TO THE ROOF STRUCTURE.ODI REVIEWED THE FIELD DATA PERFORMANCE OF THE SUBJECT VEHICLES AND COMPARED THEM TO PEER VEHICLES USING NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE FARS DATA DID NOT INDICATE A FIELD PERFORMANCE TREND FOR THE SUBJECT VEHICLE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
PE96061 · Seat Belt Webbing Separation
Opened Oct 25, 1996 · Closed Feb 28, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
ON 9/9/96 NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) PERFORMED A 35 MPH BARRIER CRASH TEST WITH A 1997 CHEVROLET S10 EXTENDED CAB PICKUP.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.