WHILE DRIVING, THE BRAKE LINE LEAKED. AS A RESULT, THE PEDAL BECAME MUSHY AND WAS UNABLE TO GRAB. THE DEALER STATED THE FUEL TANK WAS DESIGNED TOO CLOSE TOGETHER, THEREFORE, DIRT SETTLED ON THE LINE AND CAUSED RUSTING. *AK THE FRONT BRAKE PADS AND REAR BRAKE SHOES WERE INSTALLED ON THE VEHICLE. WHEN THE REPAIRS WERE BEI…
Read full complaint
WHILE DRIVING, THE BRAKE LINE LEAKED. AS A RESULT, THE PEDAL BECAME MUSHY AND WAS UNABLE TO GRAB. THE DEALER STATED THE FUEL TANK WAS DESIGNED TOO CLOSE TOGETHER, THEREFORE, DIRT SETTLED ON THE LINE AND CAUSED RUSTING. *AK THE FRONT BRAKE PADS AND REAR BRAKE SHOES WERE INSTALLED ON THE VEHICLE. WHEN THE REPAIRS WERE BEING MADE, THE TECHNICIAN(S) NOTICED THE FRONT PADS WORE OUT PREMATURELY DUE TO THE DEFECT. (AC DELCO DURASTOP BRAKES) *SC *JB
NHTSA ODI #10046716
168,500 miles · Nov 1, 2003
Fuel System, GasolineFire
FUEL LEAK AT #4 INJECTOR DRIPPING ONTO EXHAUST MANIFOLD. EXTREME FIRE HAZARD! I AM A CERTIFIED MASTER MECHANIC AND I AM GOING TO FIX THIS MY SELF. THERE IS A RECALL ON THIS VEHICLE WITH THIS ENGINE BUT THE CHEVY DEALER SAID IT WAS NOT FOR THIS VIN #[XXX] (1996 CHEVY S10 PU 2.2 LITER ENGINE). *LA INFORMATION REDACTED PURSUA…
Read full complaint
FUEL LEAK AT #4 INJECTOR DRIPPING ONTO EXHAUST MANIFOLD. EXTREME FIRE HAZARD! I AM A CERTIFIED MASTER MECHANIC AND I AM GOING TO FIX THIS MY SELF. THERE IS A RECALL ON THIS VEHICLE WITH THIS ENGINE BUT THE CHEVY DEALER SAID IT WAS NOT FOR THIS VIN #[XXX] (1996 CHEVY S10 PU 2.2 LITER ENGINE). *LA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10045249
Mileage unknown · Jan 7, 2002
Fuel System, Gasoline
CONSUMER NOTICED GASOLINE FUMES INSIDE VEHICLE. VEHICLE TAKEN TO DEALER, WHO DETERMINED FUEL INJECTOR TOPS WERE MADE OF PLASTIC AND ALLOW ED FUEL TO LEAK ONTO INTAKE MANIFOLD. FUEL INJECTORS NEED TO BE REPLACED.*AK
NHTSA ODI #8001662
Mileage unknown · Feb 1, 2001
Fuel System, Gasoline
WHEN DRIVING WOULD GET AN ODOR OF FUEL INSIDE CAB. PROBLEM WAS GETTING WORSE. COULD SMELL FUMES WHEN EITHER STOPPING OR STARTING. TOOK VEHICLE TO INDEPENDENT MECHANIC, AND WAS INFORMED THAT FUEL INJECTION SYSTEM WAS CAUSING ODOR. *AK
NHTSA ODI #879634
Mileage unknown · Sep 8, 2000
Fuel System, GasolineFuel System, Other
GAS GAUGE WILL NOT READ ACCURATELY. CONSUMER NOTICED THAT IT WAS ABOUT A QUARTER OFF, CAUSING VEHICLE TO RUN OUT OF GAS, AND LEFT STRANDED. A MECHANIC STATES THAT IT WAS DUE TO THE DESIGN OF THE INTERIOR OF GAS TANK. *AK
NHTSA ODI #869998
Mileage unknown · Aug 30, 2000
Engine And Engine CoolingFuel System, Gasoline
HAD TAKEN VEHICLE IN FOR ROUTINE MAINTENANCE FOR SMOG. INFORMED BY MECHANIC INTAKE MANIFOLD WAS CRACKED & NEEDED REPAIRING. MANIFOLD PROBLEM WAS REPAIRED 2 YEARS AGO FOR SAME CRACK. *AK
NHTSA ODI #869123
Mileage unknown · Mar 10, 2000
Fuel System, Gasoline
FUEL PUMP FAILED, REPLACED TWICE. *AK *ML
NHTSA ODI #719914
Mileage unknown · Feb 24, 2000
Engine And Engine CoolingFuel System, GasolineUnknown Or Other
TEMPERATURE GAUGE AND ENGINE CHECK LIGHT CAME ON. DEALER SAID COOLANT AND OIL INTERMIXED IN THE CRANKSHAFT WHICH WAS CAUSED BY A FAILED INTAKE MANIFOLD GASKET. *AK *ML
NHTSA ODI #857498
Mileage unknown · Jul 14, 1999
Engine And Engine CoolingFuel System, Gasoline
CYLINDER HEAD GASKET FAILED. *YC
NHTSA ODI #546569
Mileage unknown · Jun 20, 1999
Engine And Engine CoolingFuel System, GasolinePower Train
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1996 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration