AIR FROM AIR CONDITIONER NOT COOL. NOTICED AIR CONDITIONER NOT COOLING AS WELL IN FALL OF 1999. SINCE WINTER WAS NEAR I DID NOT USE IT UNTIL THE FOLLOWING SPRING. FIRST TIME IN THE SHOP NO LEAK FOUND BUT NO COOLANT IN THE SYSTEM. COOLANT REPLACED AND WORKED FOR ABOUT 4 WEEKS. THEN SAME PROBLEM. IN SHOP AGAIN AND WAS TOLD I…
Read full complaint
AIR FROM AIR CONDITIONER NOT COOL. NOTICED AIR CONDITIONER NOT COOLING AS WELL IN FALL OF 1999. SINCE WINTER WAS NEAR I DID NOT USE IT UNTIL THE FOLLOWING SPRING. FIRST TIME IN THE SHOP NO LEAK FOUND BUT NO COOLANT IN THE SYSTEM. COOLANT REPLACED AND WORKED FOR ABOUT 4 WEEKS. THEN SAME PROBLEM. IN SHOP AGAIN AND WAS TOLD I NEEDED NEW COMPRESSOR. SAID IT WAS LEAKING AROUND CASE OF COMPRESSOR. THIS IS A VERY EXPENSIVE REPAIR ($1000). I ASKED GM TO HELP ME OUT WITH IT BECAUSE I FELT AN AIRCONDITIONER SHOULD LAST LONGER THAN 4 YEARS. THEY DECLINED BECAUSE IT HAD 71,000 MILES ON IT.
NHTSA ODI #728674
Mileage unknown · Aug 15, 2000
Equipment
TWICE WHILE DRIVING MY SPARE TIRE HAS FALLEN OFF (DUE TO CABLE BREAKING).*AK
NHTSA ODI #727972
Mileage unknown · Jun 1, 2000
Equipment
HARNESS WHICH IS HELD WITH COATED CABLE WIRE CORRODED AT ATTACHMENT TO HARNESS CAUSING SPARE TIRE TO FALL ONTO ROAD AT 30 MPH. DEALER CONTACTED. *AK *ML
NHTSA ODI #862878
Mileage unknown · May 24, 2000
Equipment
COMPRESSOR LEAKING AT CLUTCH SEAL. *AK
NHTSA ODI #723154
Mileage unknown · May 3, 2000
EquipmentExterior Lighting
THE LIGHT SWITCH PROBLEM IS A DANGEROUS DEFECT, THE AIR COMPRESSOR AN EXPENSIVE DEFECT. *AK
NHTSA ODI #722232
Mileage unknown · Feb 2, 2000
EquipmentService Brakes, Hydraulic
PRIOR TO RECALL NOTIFICATION VEHICLE EXPERIENCED CONTINUED FAILURES OF THE ABS SYSTEM, ONE INCIDENT RESULTING IN VEHICLE COLLISION DUE TO LOSS OF BRAKE CONTROL. (99V-193) *MJS
NHTSA ODI #550660
Mileage unknown · Dec 8, 1999
Electrical SystemEngine And Engine CoolingEquipment
FRONT SHOCK ABSORBERS FAILED. MJS
NHTSA ODI #549879
Mileage unknown · Oct 23, 1999
Engine And Engine CoolingEquipmentService Brakes, Air
HAVE HAD PROBLEMS WITH THE WINDSHIELD WIPERS FROM THE BEGINNING. I WOULD BE DRIVING IN POURING-DOWN RAIN AND THE WIPERS WOULD GO OUT CAUSING ME TO HAVE TO PULL OVER. RIGHT NOW THEY DO NOT WORK AT ALL. I HAD TO WORK ON MY BRAKES THE FIRST YEAR AND A COUPLE OF TIMES THEREAFTER. I RECENTLY HAD TO HAVE MY AIR-CONDITIONER DONE. T…
Read full complaint
HAVE HAD PROBLEMS WITH THE WINDSHIELD WIPERS FROM THE BEGINNING. I WOULD BE DRIVING IN POURING-DOWN RAIN AND THE WIPERS WOULD GO OUT CAUSING ME TO HAVE TO PULL OVER. RIGHT NOW THEY DO NOT WORK AT ALL. I HAD TO WORK ON MY BRAKES THE FIRST YEAR AND A COUPLE OF TIMES THEREAFTER. I RECENTLY HAD TO HAVE MY AIR-CONDITIONER DONE. THE LATEST WAS MY WATER PUMP THAT I FIXED MYSELF. THE WORSE WAS MY MOTOR. I HAD BEEN STALLED A NUMBER OF TIMES TILL FINALLY IT WOULDN'T GO AT ALL. I HAD IT TOWED TO MICHAEL HOLLEY CHEVROLET IN LAKELAND (THE TOWN I WORKED IN). THEY REFUSED TO HONOR MY SMARTCARE SAYING I HAD NOT CHANGED THE OIL. THAT WAS NOT TRUE SINCE I HAD CHANGED IT MYSELF AND HAD IT CHANGED ALSO. THEY WANTED OVER 3000 FOR A NEW MOTOR. I AM AND WAS STILL PAYING ON MY TRUCK AND DID NOT HAVE THAT MUCH CASH. I HAD TO TOW IT AT MY MOTHERS AND PARK IT. I WAS ABLE TO CHANGE THE OIL AND NOTICED THAT THE CHEVROLET DEALERS HAD REMOVED THE ALTERNATOR BELT AND HAD LEFT IT LOOSE. THAT DID NOT GIVE ME ANY CONFIDENCE IN THEM. 4 MONTHS LATER MY MOTHER'S CAR WAS TOTALLED AND SHE PAID FOR ME TO GET A MOTOR FROM AN AMOCO DEALER. IN SEPTEMBER OF 1999 MY MOTHER WAS SURFING THE NET AND FOUND OUT THAT THERE HAD BEEN RECALLS ON THIS VEHICLE ALMOST FROM THE FIRST AND I HAVE NEVER BEEN NOTIFIED AT ALL. I WROTE TO THE HOME OFFICE IN EARLY SEPTEMBER BUT RECEIVED NO ANSWER. I STILL OWE 2 YEARS PAYMENTS. IF I HAD BEEN TRAVELING ON THE HIGHWAY WHEN MY MOTOR WENT OUT ON ME SOMETHING BAD COULD HAVE VERY WELL HAPPENED. I FEEL SURE THAT I WILL NEVER TRUST IN CHEVY'S PRODUCTS AGAIN.
NHTSA ODI #713753
Mileage unknown · Oct 15, 1999
EquipmentPower TrainService Brakes, Hydraulic
REAR AXLE FELL OFF WHILE MOVING. LUCKILY IN BUMPER TO BUMPER TRAFFIC THERFORE TRUCK DID NOT TURN OVER. COULD HAVE CAUSED FATAL ACCIDENT. MECHANIC SAID INFERIOR PLASTIC PARTS USED. FURTHERMORE, ANTI- LOCK BREAKS MALFUNCTION WHEN THE GROUND IS WET/DAMP. THE FLY WHEEL IS GONE. THE AIRCONDITIONER IS BROKEN. THE CLUTCH IS GOING OUT. …
Read full complaint
REAR AXLE FELL OFF WHILE MOVING. LUCKILY IN BUMPER TO BUMPER TRAFFIC THERFORE TRUCK DID NOT TURN OVER. COULD HAVE CAUSED FATAL ACCIDENT. MECHANIC SAID INFERIOR PLASTIC PARTS USED. FURTHERMORE, ANTI- LOCK BREAKS MALFUNCTION WHEN THE GROUND IS WET/DAMP. THE FLY WHEEL IS GONE. THE AIRCONDITIONER IS BROKEN. THE CLUTCH IS GOING OUT. THE TAIL GATE IS BOKEN. NOT TO MENTION 7 RECALLS ALREADY.
NHTSA ODI #713325
Mileage unknown · Sep 30, 1999
EquipmentSeat BeltsService Brakes, Hydraulic
POWER BRAKE BOOSTER MALFUNCTIONED, CAUSING EXTENDED STOPPING DISTANCE AND MAY RESULTIN A CRASH. ALSO SPARE TIRE FELL OUT WHICH MAY HAVE CAUSE A CRASH/ PROBLEMS WITH GRILL FALLING OUT, AND PASSENGER'S SEATBELT TIGHTENS WHILE IN USE. PLEASE PROVIDE FURTHER INFORMATION. *AK
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Remedy: ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence & remedy
Consequence: THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA99018 · Spare Tire Separation From Vehicle
Opened Jun 30, 1999 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Equipment
No summary supplied.
PE99004 · Separation Of Spare Tire From Vehicle
Opened Jan 15, 1999 · Closed Jun 30, 1999
Status: closed (inferred from source dates) · Equipment
ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1996 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration