IllustrationWHILE APPLYING BRAKES PEDAL WENT NEARLY TO FLOOR. FOUND HOLE IN STEEL BRAKE LINE THAT WAS RUSTY ALONG THE FRAME NEAR THE LAST PLASTIC CLAMP BEFORE IT JUMPS TO THE FLEX HOSE. AMPP. *AK
1996 Chevrolet Pickup
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pickup years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 60 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports1 fire reports2 injury reports
Service Brakes, Hydraulic complaints
8 reportsBRAKES MAKES A VERY LOUD NOISE WHEN STOPPING TRUCK. CONSUMER HAS CHANGED THE BRAKES ON TRUCK NINE TIMES. *AK
TRAVELING DOWN GRADE AND APPLIED PRESSURE TO PEDAL, NO RESPONSE FROM ABS. * AK CONSUMER STATES PROBLEM OCCURS FIRST TIME DRIVEN IN DAY, SEEMS TO OCCUR FOLLOWING DAY OF RAIN. *SLC
WHEN DRIVING UNDER WET ROAD CONDITIONS AND PUTTING FOOT ON THE BRAKE PEDAL TO STOP THE TRUCK, IT TAKES LONGER FOR THE TRUCK TO STOP, IT CONTINUES TO TRAVEL AND THEN STOPS. IT ONLY DOES THIS WHEN IT RAINS. *AK THE INSURANCE REPORT INDICATES THAT THERE WAS A HIGH RATE OF PROBLEMS WITH THIS VEHICLE. *YH
SQUEAKY BRAKE PADS.
OWNERS FEEL THE BRAKE SYSTEM IS DEFECTIVE. THIS IS THE THIRD TIME THE ENTIRE FRONT END HAS HAD TO BE REPLACED.
DIFFERENTIAL FAILURES CAUSED BY OVERHEATING CREATE A PROPANE ODOR.
BRAKE PEDAL GOES TO THE FLOOR, ABS BRAKES WON'T GRASP. THIS IS 2ND REPLACEMENT. VEHICLE HAS TO BE IN NEUTRAL BEFORE STEPPING ON BRAKES. *AK
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA97007 · Steering Shaft Separations
Opened Apr 17, 1997 · Closed Mar 12, 1998
Status: closed (inferred from source dates) · Steering
COUPLING BOLTS, JOINING THE STEERING SHAFT, MAY SEPARATE.IN SOME CASES, TOTAL UNFORESEEN, LOSS OF STEERING CONTROL MAY RESULT.
PE96076 · Steering Shaft Separations
Opened Dec 18, 1996 · Closed Apr 17, 1997
Status: closed (inferred from source dates) · Steering
BOLT IN THE COUPLING, JOINING THE UPPER INTERMEDIATE AND STEERING COLUMN SHAFTS, FALLS OUT.TOTAL LOSS OF STEERING OCCURS WHEN THE SHAFTS THEN SEPARATE.