TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO LS. THE STEERING SHAFT MADE A CLANKING NOISE WHEN MAKING A LEFT TURN. THE STEERING SHAFT WAS REPLACED IN YEAR 2005 AT 26,000, AND THEN IN YEAR 2007 AT 47,000. THE VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL # 08E063000 (INTERMEDIATE STEERING). THE MANUFACTURER WAS …
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO LS. THE STEERING SHAFT MADE A CLANKING NOISE WHEN MAKING A LEFT TURN. THE STEERING SHAFT WAS REPLACED IN YEAR 2005 AT 26,000, AND THEN IN YEAR 2007 AT 47,000. THE VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL # 08E063000 (INTERMEDIATE STEERING). THE MANUFACTURER WAS NOTIFIED, AND SHE WAS ADVISED THAT SHE WOULD HAVE TO PAY FOR THE REPAIRS TO REMEDY THE FAILURE. THE FAILURE MILEAGE WAS 72,000. UPDATED 12/7/09 *CN UPDATED 12/08/09.*JB
NHTSA ODI #10290407
47,000 miles · Oct 28, 2009
Steering
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. INTERMITTENTLY WHILE TURNING THE STEERING COLUMN WHEN DRIVING SHE HEARS A CLINGING NOISE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON TWO SEPARATE OCCASIONS FOR THE IDENTICAL FAILURES, AND THE STEERING SHAFT WAS REPLACED. THE REPAIRS DID NOT REMEDY THE FAILURE. THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. INTERMITTENTLY WHILE TURNING THE STEERING COLUMN WHEN DRIVING SHE HEARS A CLINGING NOISE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON TWO SEPARATE OCCASIONS FOR THE IDENTICAL FAILURES, AND THE STEERING SHAFT WAS REPLACED. THE REPAIRS DID NOT REMEDY THE FAILURE. THE VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL CAMPAIGN ID NUMBERS 08E063000 AND 09E005000 (STEERING). THE FAILURE MILEAGE WAS 47,000. THE CURRENT MILEAGE WAS 67,000.
NHTSA ODI #10290093
16,112 miles · Aug 12, 2008
Steering
TODAY WE WERE TOLD THAT THE RIGHT TIE ROD END NEEDED TO BE REPLACED. YEARLY INSPECTIONS ARE DONE ON OUR CAR AND THIS PAST YEAR WE HAVE ONLY PUT ABOUT 2500-3000 MILES ON IT, TOTAL 16,200. WE KEEP THE CAR IN THE GARAGE AND IN GREAT CONDITION. OBVIOUSLY WE ARE A BIT AGGRAVATED TO BE REPLACING ANY PARTS OF A VEHICLE WITH SUCH L…
Read full complaint
TODAY WE WERE TOLD THAT THE RIGHT TIE ROD END NEEDED TO BE REPLACED. YEARLY INSPECTIONS ARE DONE ON OUR CAR AND THIS PAST YEAR WE HAVE ONLY PUT ABOUT 2500-3000 MILES ON IT, TOTAL 16,200. WE KEEP THE CAR IN THE GARAGE AND IN GREAT CONDITION. OBVIOUSLY WE ARE A BIT AGGRAVATED TO BE REPLACING ANY PARTS OF A VEHICLE WITH SUCH LITTLE MILES. *TR
NHTSA ODI #10237841
38,230 miles · Jul 10, 2008
Steering
IT'S CONCERNING THE NOISE THAT MY FRONT END MAKES WHENEVER I MAKE A TURN OR REVERSE. I SEARCHED THIS SITE AND FOUND AN NHTSA ITEM #618086, SERVICE BULLETIN # 01-02-32-001 THAT PRETTY MUCH COVERS THE ISSUE WITH MY CAR. WHAT DO I DO ABOUT THIS AND IS IT DANGEROUS? *TR
NHTSA ODI #10233805
37,000 miles · May 2, 2007
Steering
CLUNKING NOISE FROM THE STEERING COLUMN. SERVICE WRITER TOOK THE INFO & AN HOUR LATER INFORMED ME THAT PROBLEM WAS FIXED AND I OWED $108.00!!!! NO COMMUNICATION, NO ESTIMATE, NO NOTHING BUT THIS CHARGE, EVEN THOUGH I HAVE AN EXTENDED WARRANTY AND GM KNOWS ABOUT THIS PROBLEM. SAID THEY LUBED A NEOPRENE SEAL ON THE INTERMEDI…
Read full complaint
CLUNKING NOISE FROM THE STEERING COLUMN. SERVICE WRITER TOOK THE INFO & AN HOUR LATER INFORMED ME THAT PROBLEM WAS FIXED AND I OWED $108.00!!!! NO COMMUNICATION, NO ESTIMATE, NO NOTHING BUT THIS CHARGE, EVEN THOUGH I HAVE AN EXTENDED WARRANTY AND GM KNOWS ABOUT THIS PROBLEM. SAID THEY LUBED A NEOPRENE SEAL ON THE INTERMEDIATE SHAFT OF THE STEERING COLUMN. *TR
NHTSA ODI #10189591
44,000 miles · Apr 11, 2007
Steering
I OWN A 2004 CHEVROLET MONTE CARLO. I STARTING HAVING STEERING PROBLEMS. THE STEERING FELT LOOSE AND LIKE METAL GRINDING TOGETHER. THE BUMPING COULD BE FELT OVER IN THE PASSENGER SEAT AS WELL SO IT RAISED SOME CONCERNS. AFTER DOING SOME ONLINE RESEARCH I FOUND IT WAS THE INTERMEDIATE STEERING SHAFT. I AM SURE THE COMPANY…
Read full complaint
I OWN A 2004 CHEVROLET MONTE CARLO. I STARTING HAVING STEERING PROBLEMS. THE STEERING FELT LOOSE AND LIKE METAL GRINDING TOGETHER. THE BUMPING COULD BE FELT OVER IN THE PASSENGER SEAT AS WELL SO IT RAISED SOME CONCERNS. AFTER DOING SOME ONLINE RESEARCH I FOUND IT WAS THE INTERMEDIATE STEERING SHAFT. I AM SURE THE COMPANY HEARD THIS COMPLAINT BEFORE. I FOUND CHEVROLET'S FIX TO FIRST BE A LUBE KIT THAT WOULD FIX THE PROBLEM FOR MAYBE 20,000 MILES IN WHICH I PURCHASED AND HAD THE DEALER APPLY. WAS LATER TOLD THE PROBLEM WAS MISSING AND DEFECTIVE SUB FRAME WELDS. THEY ALSO FIXED THE WELD PROBLEM WITH SUPER GLUE? IM NOT EXACTLY SURE WHAT THE MECHANIC DID WHILE FIXING MINE, BUT I HAD TO PAY FOR IT OUT OF POCKET WITH NO CLUE HOW SAFE AND HOW LONG THIS FIX WILL WORK. PAPER JUST SAID INTERMEDIATE REPLACED. AND I PURCHACED THE LUBE. IT WAS A DEALER'S DEFECT, AND THEY WERE VERY AWARE OF.IT. ASK ANY OF THEIR MECHANICS. YET NO RECALL. *AK
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Consequence & remedy
Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Consequence & remedy
Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Chevrolet Monte Carlo Problems, Complaints & Recalls | Skip That Year
Illustration