NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
8 reportsClear category filter12,000 miles · Mar 18, 2011
Service Brakes, Hydraulic
REAR BRAKE ROTORS WERE RECUT 1 TIME, REPLACED 1 TIME BY DEALER DUE TO PITTING OF THE ROTORS CAUSING RUFF STOPPING. I REPLACE THE REAR PADS AND ROTORS OUT OF POCKET AT 39,000MILES AND STOPPED PROBLEM. FRONT BRAKE PADS CRACKED IN THE FIRST 12,000 MILES AND REPLACED OUT OF POCKET WITH CERAMIC PADS, NO MORE BRAKE TROUBLE YET, THE CA…
Read full complaint
REAR BRAKE ROTORS WERE RECUT 1 TIME, REPLACED 1 TIME BY DEALER DUE TO PITTING OF THE ROTORS CAUSING RUFF STOPPING. I REPLACE THE REAR PADS AND ROTORS OUT OF POCKET AT 39,000MILES AND STOPPED PROBLEM. FRONT BRAKE PADS CRACKED IN THE FIRST 12,000 MILES AND REPLACED OUT OF POCKET WITH CERAMIC PADS, NO MORE BRAKE TROUBLE YET, THE CAR NOW HAS 48,000 MILES. WE HAD NO ACCIDENTS FROM THIS. *TR
NHTSA ODI #10390586
9,000 miles · Jan 28, 2008
Electrical SystemEquipmentService Brakes, Hydraulic
TL*THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. WHILE DECELERATING FROM 45 MPH, THE BRAKES FAILED. THE CONTACT LOST CONTROL OF THE VEHICLE AND STRUCK A GUARD RAIL. THERE WERE NO INJURIES. THE DEALER CLEANED THE ROTORS AND BRAKES; HOWEVER, THE VEHICLE CONTINUED TO HESITATE WHEN ATTEMPTING TO STOP. THE MANUFACTURER STATED T…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. WHILE DECELERATING FROM 45 MPH, THE BRAKES FAILED. THE CONTACT LOST CONTROL OF THE VEHICLE AND STRUCK A GUARD RAIL. THERE WERE NO INJURIES. THE DEALER CLEANED THE ROTORS AND BRAKES; HOWEVER, THE VEHICLE CONTINUED TO HESITATE WHEN ATTEMPTING TO STOP. THE MANUFACTURER STATED THAT THE DEALER SHOULD DIAGNOSE THE FAILURE. THE CURRENT MILEAGE WAS 31,498 AND FAILURE MILEAGE WAS 9,000. UPDATED 02-19-08 *BF THE CONSUMER STATED THEY DID NOT HIT THE GUARD RAIL, THERE WERE LIMITED BRAKES THE VEHICLE PULLED TO THE RIGHT. THE CONSUMER FURTHER STATED THIS IS THE SECOND INCIDENT AND THE REMEDY FOR THE DEALER IS TO MACHINE THE ROTORS, HOWEVER THE DEFECT PERSISTS AND PEDAL PULSATES. THE CONSUMER STATED AFTER VEHICLE STARTS THE STARTER STAYS ENGAGED AND A/C IS INOPERABLE. UPDATED 02/14/08 *TR
NHTSA ODI #10216308
50,000 miles · Jul 6, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE BRAKE PEDAL PULSATED VIOLENTLY. AS SPEED OF THE VEHICLE DECREASED TO 5 MPH, THE BRAKES EMITTED A GRINDING NOISE. THE VEHICLE WAS NOT INSPECTED BY A MECHANIC.
NHTSA ODI #10161663
32,161 miles · Apr 5, 2006
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
DT*: THE CONTACT STATED WHILE DRIVING 40 MPH,THE VEHICLE LOST POWER WITHOUT WARNING. NO DASH PANEL LIGHTS ILLUMINATED TO INDICATE A FAILURE. THE ENGINE WAS EASILY RESTARTED, BUT THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION. A DIAGNOSTIC TEST WAS PERFORMED WHICH INDICATED THE FUEL RELAY CONNECTOR HOSE WAS LOOSE. ALTHOUG…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 40 MPH,THE VEHICLE LOST POWER WITHOUT WARNING. NO DASH PANEL LIGHTS ILLUMINATED TO INDICATE A FAILURE. THE ENGINE WAS EASILY RESTARTED, BUT THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION. A DIAGNOSTIC TEST WAS PERFORMED WHICH INDICATED THE FUEL RELAY CONNECTOR HOSE WAS LOOSE. ALTHOUGH THIS WAS REPAIRED, THE PROBLEM PERSISTED. THE VEHICLE IS CURRENTLY AT THE DEALERSHIP AWAITING FURTHER INSPECTION. UPDATED ON 05/16/2006. THE BRAKES PULSATED WHILE BRAKING. THE DEALER REPLACED THE ROTORS BECAUSE THE WERE PITTED AND WARPED. THEY ALSO REPLACED THE REAR BRAKES. *AK *NM
NHTSA ODI #10154618
16,500 miles · Jan 8, 2005
Service Brakes, Hydraulic
BRAKE PEDAL WENT TO FLOOR, CAR WOULD NOT STOP. NO WARNING LIGHTS CAME ON. NOISE FROM FRONT RIGHT BRAKES WHEN GOING FORWARD OR IN REVERSE. PEDAL TO FLOOR HAPPENED IN GOOD DRY WEATHER ON BOTH OCCASIONS. ABS WAS NOT ACTIVE AT TIME OF INCIDENT. TOOK CAR TO DEALER AND WAS REPAIRED AT NO COST TO ME,CAR IS UNDER WARRANTY AND DEALER GA…
Read full complaint
BRAKE PEDAL WENT TO FLOOR, CAR WOULD NOT STOP. NO WARNING LIGHTS CAME ON. NOISE FROM FRONT RIGHT BRAKES WHEN GOING FORWARD OR IN REVERSE. PEDAL TO FLOOR HAPPENED IN GOOD DRY WEATHER ON BOTH OCCASIONS. ABS WAS NOT ACTIVE AT TIME OF INCIDENT. TOOK CAR TO DEALER AND WAS REPAIRED AT NO COST TO ME,CAR IS UNDER WARRANTY AND DEALER GAVE ME A LOANER FOR THE DAY. DEALER STATED THAT "BRAKE CALIPER WAS SEIZED TO PADS".THEY CLEANED AND LUBED "CALIPER SLIDERS". DEALER WAS VERY COOPERATIVE I HAVE NO COMPLAINTS WITH THE DEALER, THEY WERE EXCELLENT. I BOUGHT THE CAR BRAND NEW AND IT HAD 16,500 MILES ON IT AT TIME OF PROBLEM. I AM THE ONLY OPERATOR OF THIS CAR. I WANTED TO INFORM THE PEOPLE CAUSE I SEE THERE ARE SEVERAL PROBLEMS WITH BRAKES ON THIS CAR TYPE. I WILL UPDATE IF PROBLEM HAPPENS AGAIN.*AK
NHTSA ODI #10105969
3,400 miles · Dec 29, 2004
Electrical SystemLatches/locks/linkagesService Brakes, Hydraulic
WARPED DASHBOARD IN MY 2004 MONTE CARLO, RADIO FACE ALSO GETS BLISTERING HOT, TRUNK LID OPEN APPEARS ALL THE TIME ON DASH, TOO K TO DEALER, TRUNK LID FIXED NEW DASH INSTALLED 3 DAYS LATER DASH WARPED WORSE THAN BEFORE AND BOTH SIDE PILLARS NOW CRACKED, BRAKES STILL NOISY AND PEDAL TO THE FLOOR, DEALER STATES NORMAL. SCHEDULING F…
Read full complaint
WARPED DASHBOARD IN MY 2004 MONTE CARLO, RADIO FACE ALSO GETS BLISTERING HOT, TRUNK LID OPEN APPEARS ALL THE TIME ON DASH, TOO K TO DEALER, TRUNK LID FIXED NEW DASH INSTALLED 3 DAYS LATER DASH WARPED WORSE THAN BEFORE AND BOTH SIDE PILLARS NOW CRACKED, BRAKES STILL NOISY AND PEDAL TO THE FLOOR, DEALER STATES NORMAL. SCHEDULING FOR MY SECOND DASHBOARD, AND STILL NO ANSWERS ON WHY YOU CANT TOUCH THE RADIO. *NM
NHTSA ODI #10104740
16,000 miles · Oct 18, 2004
Service Brakes, Hydraulic
BRAKE PEDAL FELT MUSHY, PEDAL WENT TO FLOOR WHEN APPLIED. *BF THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE PROBLEM WAS NORMAL. *NM
NHTSA ODI #10097359
Mileage unknown · Aug 20, 2004
Service Brakes, Hydraulic
RECALL NOTICE CONCERNING BOLTS THAT ATTACHES THE BRAKE CALIPER TO THE STEERING KNUCKLE BEING LOOSE. *MR THE DEALER DID NOT HAVE THE SPECIFIC SEALANT THAT THE RECALL REQUIRED. *SC *JB
NHTSA ODI #10089712
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 6, 2015
General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Consequence & remedy
Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Jun 23, 2004
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Consequence & remedy
Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration