Electrical System. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports11 fire reports8 injury reports

Seat Belts complaints

3 reports

Clear category filter

63,000 miles · Feb 29, 2016

Seat Belts

TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE SEAT BELTS ON THE FRONT DRIVER AND PASSENGER SIDE FAILED TO RETRACT AFTER BEING USED. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE …

Read full complaint

NHTSA ODI #10838881

97,000 miles · Oct 30, 2013

Seat Belts

TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE RETRACTABLE SEAT BELT WAS PURCHASED ON 4/7/2011 AND WILL NOT RETRACT; HOWEVER, IT WILL SPORADICALLY FAIL TO UNLATCH. THE SEAT BELT WAS REPLACED FOUR TIMES BUT THE ISSUE HAS RECURRED. THE SEAT BELT WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED THAT THE…

Read full complaint

NHTSA ODI #10550157

Mileage unknown · Jan 12, 2010

Seat Belts

Read full complaint

SEAT BELTS ON BOTH DRIVER & PASSENGER SEATS DO NOT RETRACT PROPERLY. IF BELTS ARE NOT MANUALLY PULLED IN THEY HANG LOOSELY. ALSO ON SEVERAL OCCASIONS, BELTS WILL BE VERY TIGHT WHEN WEARING (ACROSS CHEST). IF YOU TRY TO MOVE FORWARD YOU ARE UNABLE. THE INITIAL PROBLEM WITH SEAT BELTS NOT RETRACTING STARTED HAPPENING OCCASIONALLY ABOUT 2 YRS AGO BUT NOW HAPPENS ALL THE TIME. IT IS EXTREMELY FRUSTRATING TO NOT HAVE THE SEAT BELT WORK PROPERLY AND TO HAVE TO MANUALLY PULL SEATBELT IN. I HAVE BEEN SEARCHING VARIOUS WEBSITES TO SEE IF CHEVY HAS DONE ANY RECALLS ON THIS PROBLEM & HAVEN'T SEEN ANYTHING. I FEEL THIS IS A SAFETY PROBLEM SINCE STATE LAW REQUIRES US TO ALWAYS WEAR SEATBELTS WHEN DRIVING. *TR

NHTSA ODI #10299546

Official recalls

15V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Oct 26, 2015

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence & remedy

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Engine And Engine Cooling:engine

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

15V201000 · Engine And Engine Cooling:engine

Apr 6, 2015

General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

Consequence & remedy

Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.

14V400000 · Electrical System:ignition

Jul 3, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

04V287000 · Service Brakes, Hydraulic

Jun 23, 2004

CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.

Consequence & remedy

Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.

Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.