NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
23 reportsClear category filter119,295 miles · Jul 28, 2016
Engine
I TOOK MY CAR IN TO TOM HENRY CHEVROLET ON MAY 19, 2016 TO HAVE RECALL NUMBER 14574 PERFORMED. I PREVIOUSLY HAD NO OIL LEAK FROM THIS VALVE COVER, BUT TOOK IT IN ONLY BECAUSE OF THE RECALL. MILEAGE TO TIME OF REPAIR WAS 117748...CURRENT MILEAGE, AT TIME OF PHOTO, IS 119295. THE PHOTO SHOWS THE GASKET PROTRUDING OUT FROM UNDER T…
Read full complaint
I TOOK MY CAR IN TO TOM HENRY CHEVROLET ON MAY 19, 2016 TO HAVE RECALL NUMBER 14574 PERFORMED. I PREVIOUSLY HAD NO OIL LEAK FROM THIS VALVE COVER, BUT TOOK IT IN ONLY BECAUSE OF THE RECALL. MILEAGE TO TIME OF REPAIR WAS 117748...CURRENT MILEAGE, AT TIME OF PHOTO, IS 119295. THE PHOTO SHOWS THE GASKET PROTRUDING OUT FROM UNDER THE VALVE COVER TO THE LEFT OF THE BOLT, AND OIL ON THE BLOCK AND EXHAUST. SUCH A SIMPLE PROCEDURE, SCREWED UP BY INCOMPETENT DEALERSHIP!!!! NOW, I HAVE A PROBLEM!!!!
NHTSA ODI #10889174
169,800 miles · Apr 12, 2016
EngineFireInjury
TL* THE CONTACT OWNED A 2004 CHEVROLET MONTE CARLO. AFTER STRIKING A POTHOLE AT APPROXIMATELY 15 MPH, AN ABNORMAL SOUND EMITTED FROM THE VEHICLE WITHOUT WARNING. THE AIR BAGS DEPLOYED. THE VEHICLE FILLED WITH SMOKE AND CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED AND THE CONTACT SUSTAINED …
Read full complaint
TL* THE CONTACT OWNED A 2004 CHEVROLET MONTE CARLO. AFTER STRIKING A POTHOLE AT APPROXIMATELY 15 MPH, AN ABNORMAL SOUND EMITTED FROM THE VEHICLE WITHOUT WARNING. THE AIR BAGS DEPLOYED. THE VEHICLE FILLED WITH SMOKE AND CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED AND THE CONTACT SUSTAINED A MINOR THUMB INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 169,800. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10855034
100,000 miles · Apr 11, 2016
Electrical SystemEngine
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE SECURITY WARNING LIGHT CONSTANTLY FLASHED AND THE VEHICLE WAS UNABLE TO START. IN ADDITION, THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE KEYS FOR THE IGNITION BUT THE FAILURE CONTINUED. THE SECURITY WARNING L…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE SECURITY WARNING LIGHT CONSTANTLY FLASHED AND THE VEHICLE WAS UNABLE TO START. IN ADDITION, THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE KEYS FOR THE IGNITION BUT THE FAILURE CONTINUED. THE SECURITY WARNING LIGHT CONTINUED TO ILLUMINATE. THE PASS LOCK PROTECTION SYSTEM WAS UNABLE TO BE OVERRIDDEN SO THE CONTACT WAS UNABLE TO DETERMINE THE SOLUTION TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10854832
Mileage unknown · Mar 3, 2016
Engine
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WAS A BURNING OIL ODOR. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TI…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WAS A BURNING OIL ODOR. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10839701
70,000 miles · Feb 9, 2016
Engine
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. WHEN ACCELERATING, THE ENGINE RPMS WOULD INCREASE. HOWEVER, ONCE REACHED TO 4,000, IT WOULD INDEPENDENTLY DECREASE AND CAUSED THE VEHICLE TO LOSE ACCELERATION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PARTS T…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. WHEN ACCELERATING, THE ENGINE RPMS WOULD INCREASE. HOWEVER, ONCE REACHED TO 4,000, IT WOULD INDEPENDENTLY DECREASE AND CAUSED THE VEHICLE TO LOSE ACCELERATION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10825081
138,000 miles · Jan 21, 2016
EngineFire
TL* THE CONTACT OWNED A 2004 CHEVROLET MONTE CARLO. WHILE THE VEHICLE WAS PARKED IN THE GARAGE, THE CONTACT NOTICED THAT THE GARAGE WAS ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE, ENGINE COOLING). THE MAN…
Read full complaint
TL* THE CONTACT OWNED A 2004 CHEVROLET MONTE CARLO. WHILE THE VEHICLE WAS PARKED IN THE GARAGE, THE CONTACT NOTICED THAT THE GARAGE WAS ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE, ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 138,000. UPDATED 04/14/16*LJ *CN
NHTSA ODI #10821561
75,000 miles · Jan 19, 2016
Engine
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING). THE RECALL CALLED FOR THE REPLACEMENT OF THE FRONT VALVE COVER ONLY, EVEN THOUGH THE REAR VALVE COVER WAS LEAKING AT THE TIME. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING). THE RECALL CALLED FOR THE REPLACEMENT OF THE FRONT VALVE COVER ONLY, EVEN THOUGH THE REAR VALVE COVER WAS LEAKING AT THE TIME. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 75,000.
NHTSA ODI #10821111
104,000 miles · Jan 5, 2016
Electrical SystemEngineFire
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. A FEW MINUTES AFTER THE VEHICLE WAS PARKED IN THE DRIVEWAY, IT BURST INTO FLAMES. THE FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. THE FRONT END OF THE VEHICLE WAS COMPLETELY BURNED. THE CONTACT STATED THAT THERE WERE NO WARNING INDICATORS. A POLICE REPORT AND A FIRE REPORT W…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MONTE CARLO. A FEW MINUTES AFTER THE VEHICLE WAS PARKED IN THE DRIVEWAY, IT BURST INTO FLAMES. THE FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. THE FRONT END OF THE VEHICLE WAS COMPLETELY BURNED. THE CONTACT STATED THAT THERE WERE NO WARNING INDICATORS. A POLICE REPORT AND A FIRE REPORT WERE FILED. PRIOR TO THE FIRE, THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBERS: 14V400000 (ELECTRICAL SYSTEM) AND 15V201000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PARTS TO DO THE REPAIRS WERE NOT AVAILABLE. THE FAILURE MILEAGE WAS 104,000.
NHTSA ODI #10818120
Mileage unknown · Dec 22, 2015
Engine
I RECEIVED A RECALL #14574 FROM GM BECAUSE ON HARD BRAKING OIL CAN LEAK AND CAUSE A FIRE. THEY SAY "THIS CONDITION DOES NOT AFFECT THE SAFE OPERATION OF THE VEHICLE." YOUR SHOULD MAKE THEM REVISE THIS NOTICE!!! IT CERTAINLY DOES AFFECT SAFE OPERATION.
NHTSA ODI #10811620
Mileage unknown · Nov 12, 2015
EngineFuel/propulsion System
IN THE MORNING WHEN STARTING THE CAR IT SPUTTERS LIKE IT'S GASPING FOR GAS...I TURN KEY OFF THEN RESTART AND THE ENGINE STARTS NORMALLY
NHTSA ODI #10790061
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 6, 2015
General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Consequence & remedy
Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Jun 23, 2004
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Consequence & remedy
Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration