I PURCHASED A 2001 CHEVY MONTE CARLO SS IN 9-01. I DID NOT REALIZE UNTIL RECENTLY THE ENGINE WAS BUILT 2000. I WOULD NOT HAVE PURCHASED. MY CAR HAS HAD MULTIPLE PROBLEMS. THE RECENT OCCURRED JULY 20TH 2019. MY ODOMETER IS 117,166 ORIGINAL MILES. THE INTAKE MANIFOLDS AND UPPER INTAKE MANIFOLD IS ALL MADE OF A PLASTIC. I WENT TO S…
Read full complaint
I PURCHASED A 2001 CHEVY MONTE CARLO SS IN 9-01. I DID NOT REALIZE UNTIL RECENTLY THE ENGINE WAS BUILT 2000. I WOULD NOT HAVE PURCHASED. MY CAR HAS HAD MULTIPLE PROBLEMS. THE RECENT OCCURRED JULY 20TH 2019. MY ODOMETER IS 117,166 ORIGINAL MILES. THE INTAKE MANIFOLDS AND UPPER INTAKE MANIFOLD IS ALL MADE OF A PLASTIC. I WENT TO START MY CAR WHICH HAS BEEN RUNNING FINE. AROUND 6-7:00 PM I HEARD A LOUD BOOM. IT STARTLED ME AND MY NIEGHBORS EVEN CAME OUT. I NOTICED SMOKE COMING FROM THE FRONT DRIVERS SIDE. I POPPED THE HOOD AND FLAMES WERE SHOOTING STRAIGHT UP THE FIREWALL ONTO THE INSIDE HOOD. I IMMEDIATELY SCREAMED GET ME WATER AND NOTICED THE FIRE EXTINGUISHER. I SMASHED THE GLASS GRABBED IT AND BEGAN TO PUT OUT THE FIRE. REMIND YOU THE CAR HAS A COVER I WAS USING BOTH HANDS REMOVED THE OIL CAP PULLED THE COVER AND STILL SPRAYING I PUT THE COVER OUT AND CONTINUED WITH THE ENGINE PLACING THE OIL CAP TO PREVENT CROSS CONTAMINATION. I WAS ABLE TO PUT OUT THE FIRE I HAD CUTS TO MY HAND AND IT SINGED THE HAIR ON MY ARMS AND MY WRIST HAD A SLIGHT BURN. HOWEVER, I HAVE KNOW IDEA HOW I WAS OVER LOOKED ON THE 5-17-04 FUEL PRESSURE REGULATOR RECALL PART #03064B MY CAR IS A 3.8 LITRE K SERIES. IF I WOULD HAVE HAD MY GRANDDAUGHTER SHE IS IN A CAR SEAT THE DAMAGE WOULD HAVE BEEN MUCH WORSE. THE FLAMES WERE SO HIGH THEY ALMOST REACHED THE TREE BRANCH. THE SCARY PART IS GMAC IS AWARE OF THE POSSIBLE FIRE AND IS TRYING TO SETTLE WITH ME FOR MINIMAL AMOUNT. I JUST SPENT THOUSANDS BECAUSE THE CAR HIT 100,000 SO NEW RADIATOR, TUNE UP ETC. THIS WAS A VERY EXPENSIVE PURCHASE AND TO THINK I HAVE BEEN DRIVING A TIME BOMB. LUCKILY I WASN'T IN TRAFFIC OR IN A PLACE WHERE I HAD TO PULL MY GRANDDAUGHTER OUT AND THE CAR SEAT BECAUSE THE ENTIRE CAR WOULD HAVE BURNED. I HONESTLY THOUGHT IT WAS GOING TO BLOW UP. I CAN ACTUALLY SHOVE MY FIST IN THAT UPPER INTAKE MANIFOLD. SEE COMPLAINT ODI112351110
NHTSA ODI #11244180
Mileage unknown · Jan 4, 2016
Unknown Or Other
HOW IS IT ACCEPTABLE THAT, 75 DAYS AFTER THE RECALL WAS ISSUED, THERE IS STILL NO RESOLUTION FOR NHSTA RECALL #15V701 THIS IS A DANGEROUS SITUATION-GM NEEDS TO COMMIT TO GETTING THE PARTS MADE.
NHTSA ODI #10817556
110,000 miles · May 29, 2015
Electrical SystemUnknown Or Other
2001 MONTE CARLO SS; I'VE HAD MANY DIFFERENT OCCASIONS ON WHERE THE CAR JUST DIES WHILE I'M DRIVING IT. THEY HAD A RECALL FOR THE "IGNITION KEY" I TOOK IT IN, THEY "FIXED" THE KEY-NOT THE IGNITION, AND STILL, TO THIS DAY, THE VEHICLE CONTINUES TO DIE WHILE DRIVING, WHICH INCLUDES LOSS OF POWER STEERING COMPLETELY. LUCKILY, I HAV…
Read full complaint
2001 MONTE CARLO SS; I'VE HAD MANY DIFFERENT OCCASIONS ON WHERE THE CAR JUST DIES WHILE I'M DRIVING IT. THEY HAD A RECALL FOR THE "IGNITION KEY" I TOOK IT IN, THEY "FIXED" THE KEY-NOT THE IGNITION, AND STILL, TO THIS DAY, THE VEHICLE CONTINUES TO DIE WHILE DRIVING, WHICH INCLUDES LOSS OF POWER STEERING COMPLETELY. LUCKILY, I HAVE NOT HAD A CAR ACCIDENT DUE TO THIS ISSUE, BUT IT'S STILL SCARY WHEN IT HAPPENS. IT HAPPENED AGAIN TODAY, 5/29/2015 WHILE DRIVING AND COMPLETELY LOST STEERING CONTROL WHEN IT DIED.
NHTSA ODI #10722350
59,689 miles · Mar 2, 2004
Unknown Or Other
YOU RECALLED SOME CHEVROLETS, (IMPALA,MONTE & ECT) FOR THE SAME PROBLEM THAT I'M HAVING WITH MY CAR,WHICH IS A 2001 CHEVROLET MONTE #[XXX] YOU RECALLED 2000-2003 LAST 8 #'S [XXX] THROUGH [XXX] WHICH MY CAR IS BETWEEN THAT. THE ONLY DIFFERENCE IS THAT MY VEHICLE HAS A 3.4 & THE RECALL WAS FOR THE 3.8 ONLY. YOU REALLY MUST RECAL…
Read full complaint
YOU RECALLED SOME CHEVROLETS, (IMPALA,MONTE & ECT) FOR THE SAME PROBLEM THAT I'M HAVING WITH MY CAR,WHICH IS A 2001 CHEVROLET MONTE #[XXX] YOU RECALLED 2000-2003 LAST 8 #'S [XXX] THROUGH [XXX] WHICH MY CAR IS BETWEEN THAT. THE ONLY DIFFERENCE IS THAT MY VEHICLE HAS A 3.4 & THE RECALL WAS FOR THE 3.8 ONLY. YOU REALLY MUST RECALL THE 3.4 ALSO. WHERE I TOOK MY CAR THEY SAID THERE HAVE BEEN A LOT OF THE CARS THAT WHERE 3.4 THAT THEY HAVE REPLACED. *AK *NM UPDATED 07/26/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10051141
Mileage unknown · Jul 6, 2001
Service Brakes, HydraulicSteeringUnknown Or Other
ENGINE LIGHT CAME ON, AND THE DEALERSHIP COULD NOT DETERMINE A CAUSE FOR PROBLEM. THEN, WHILE BACKING UP AT APPROXIMATELY 5 MPH, ENGINE LIGHT CAME ON, AND STEERING CONTROL WAS LOST. ON-STAR REPRESENTATIVE STATED THAT ANTI-THEFT DEVICE CAME ON AND CAUSED THE ENGINE TO SHUT OFF. *AK CONSUMER HAD TO USE THE EMERGENCY BRAKE TO…
Read full complaint
ENGINE LIGHT CAME ON, AND THE DEALERSHIP COULD NOT DETERMINE A CAUSE FOR PROBLEM. THEN, WHILE BACKING UP AT APPROXIMATELY 5 MPH, ENGINE LIGHT CAME ON, AND STEERING CONTROL WAS LOST. ON-STAR REPRESENTATIVE STATED THAT ANTI-THEFT DEVICE CAME ON AND CAUSED THE ENGINE TO SHUT OFF. *AK CONSUMER HAD TO USE THE EMERGENCY BRAKE TO STOP VEHICLE ON ONE OCCASION WHEN THE BRAKES FAILED. *SLC
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2001 Chevrolet Monte Carlo Problems, Complaints & Recalls | Skip That Year
Illustration