2000 Chevrolet Monte Carlo

I OWN A 2000 CHEVY. MONTE CARLO. A REVIEW OF THE SERVICE BULLETINS SHOWS THAT THERE IS A KNOWN PROBLEM WITH LOWER AND UPPER INTAKE MANIFOLD GASKETS. MY MECHANICS HAVE TOLD ME IT LEAKING IS A PROBLEM WITH THIS MODEL, BUT EVERYONE WANTS $500 TO $600 TO REPLACE JUST ONE GASKET. IF THERE ARE SERVICE BULLETINS, AND IT IS A KNOWN PROBLEM, WHY ARE CONSUMERS MADE TO PAY FOR THIS? OR HAS GM BEEN TOLD TO REPAIR THIS FOR CUSTOMERS? I HAVE HAD TO HAVE SEVERAL THINGS REPLACED MORE THAN ONCE. SUCH AS THE WINDOW MOTORS ASSEMBLIES, ON THE DRIVER SIDE MORE THAN THREE TIMES ALONE. *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE CONTACT WAS UNABLE TO START THE VEHICLE. HE CHECKED UNDER THE HOOD AND ATTEMPTED TO RESTART THE VEHICLE WHEN THE UPPER INTAKE EXPLODED WHICH RESULTED IN A FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT DISCONNECTED THE BATTERY CABLE IN THE EVENT SOMEONE TRIED TO RESTART THE VEHICLE. THE CHEVROLET MANUFACTURER ADVISED HIM TO CONTACT THEM IN TWO WEEKS SINCE HE FILED A REPORT WITH THEM. THERE WERE NO INJURIES AND THE VEHICLE WAS TOWED TO THE DEALER. THE FAILURE MILEAGE WAS 116,000.

1. TOOK MY CAR IN FOR SERVICE FOR AN INTERMITTENT "CHECK ENGINE" LIGHT. SERVICE REQUIRED WAS A PURGE SOLENOID FOR THE CHARCOAL CANNISTER. 2. AFTER RETURNING THE CAR HOME AND IT SITTING FOR A COUPLE DAYS, I WENT TO START THE CAR AND THE BATTERY WAS DEAD. JUMPED THE BATTERY WITH ANOTHER CAR AND WHEN I WENT TO TURN THE KEY IN THE MONTE CARLO, THE INTAKE MANIFOLD EXPLODED IN ABOUT 20 DIFFERENT PIECES IN A DEAFENING EXPLOSION. 3. NOTHING HAS BEEN DONE TO REPAIR YET, BUT THE DAMAGE IS CATASTROPHIC. I'M LOOKING AT $$$$$ REPAIR. I HAVE PICTURES OF IT IF NEEDED. IF I HAD BEEN STANDING OVER THE ENGINE AND MY WIFE HAD TURNED THE KEY I WOULD BE LOOKING AT A HOSPITAL STAY. *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. AFTER DRIVING 40 MPH, THE CONTACT SMELLS BURNING OIL AND OCCASIONALLY NOTICES SMOKE UNDER THE HOOD OF THE VEHICLE. HE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 09V116000 (ENGINE AND ENGINE COOLING). THE REMEDY WAS TO REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF THE ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS. THE CONTACT BELIEVES THAT THIS WILL NOT REPAIR THE ACTUAL DEFECT AND THE LEAK WILL STILL OCCUR. HE BELIEVES THAT THE RECALL SHOULD OFFER A PERMANENT REPAIR TO STOP THE LEAKAGE. THE FAILURE MILEAGE WAS 50,000 AND CURRENT MILEAGE WAS 137,674.

TL*THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE SENSOR IN HER EGR WOULD CATCH FIRE. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE BEGAN TO SMOKE AND SMELLED OF BURNT PLASTIC. SHE DEPRESSED THE ACCELERATOR PEDAL AND FELT AS IF SHE WERE PUSHING ON AIR. THE CONTACT HEARD AIR BLOWING SO SHE TOOK THE VEHICLE TO A MECHANIC. THE MECHANIC DISCOVERED THAT THE SENSOR WAS COMPLETELY MELTED AND HE REPAIRED THE VEHICLE. HOWEVER, THE ISSUE RECURRED TWO DAYS LATER. THE MECHANIC COULD NOT DETERMINE WHAT CAUSED THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE SECOND FAILURE AND THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 221,000.

MY CHEVY MONTE CARLO'S MANIFOLD INTAKE GASKET ERODED AWAY LETTING THE ENGINE OIL AND COOLANT TO LEAK OUT. IT IS NOT A NEW CAR, BUT WHEN I TOOK IT TO THE REPAIR SHOP THE OWNER SAID HE KNEW EXACTLY WHAT THE PROBLEM WAS WITHOUT EVEN LOOKING, BUT DID OF COURSE, AND CONFIRMED THAT THE INTAKE GASKET WAS ERODED AWAY DUE TO ITS BEING PLASTIC INSTEAD OF THE METAL GASKET THAT SHOULD BE USED IN THE CHEVORLET V6 ENGINES. HE STATED THAT HE HAD REPLACED GASKET AFTER GASKET SINCE CHEVY HAD "CHEAPENED UP" THE ENGINES. I ASKED MANY OTHER REPAIRMEN AND THE DEALER AND IT WAS CONFIRMED. I BELIEVE THIS IS AN INDUSTRY PROBLEM, ACROSS THEIR ENGINEERING BOONDAGGLES WHICH HAVE BEEN PUT UPON THE PUBLIC. IT IS NOT A CHEAP FIX, UNLIKE THEIRS, AND COST ME AND MANY OTHERS $800-$1500 DOLLARS IN REPAIR BILLS. CHEVY HAS REFUSED TO HELP WITH THIS RAMPANT PROBLEM. I THINK THIS SHOULD BE A RECALL ISSUE SINCE IT IS NOT AN ISOLATED INCIDENT AND CERTAINLY IS NOT DUE TO ABUSE OF THE VEHICLE OR EVEN EXCESSIVE MILEAGE AND WEAR. MY CAR HAS 73000 MILES ON IT AND HAVEN'T DONE ANYTHING BUT BE GOOD TO THIS VEHICLE. I HAVE SEARCHED MANY SITES IN ORDER FOR MY COMPLAINT TO BE REGISTERED. PLEASE ADVISE ME ABOUT ANY STEPS I CAN PURSUE TO MAKE CHEVY AND GM "UNDO" THE DEFECT THEY CREATED. THANK YOU. JAH *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE CONTACT ATTEMPTED TO START THE VEHICLE, BUT WAS UNSUCCESSFUL. HE ATTEMPTED TO JUMPSTART THE VEHICLE AND THE ENGINE BLEW UP IN FLAMES. A LOCAL MECHANIC STATED THAT THE INTAKE MANIFOLD WAS DEFECTIVE. THE MANUFACTURER STATED THAT THERE WERE TOO MANY MILES ON THE VEHICLE. THERE WERE NO RECALLS RELATED TO THE VIN; THEREFORE, THEY WOULD NOT BE LIABLE FOR THE REPAIRS. THE DEALER HAS NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE 140,000.

TL*THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE BATTERY DIED AND THE CONTACT JUMPSTARTED THE VEHICLE. WHEN THE VEHICLE STARTED, THERE WAS AN EXPLOSION THAT CAUSED THE INTAKE MANIFOLD TO BLOW ITS COVER. PRIOR TO THE CONTACT PURCHASING THE VEHICLE, A RECALL WAS PERFORMED RELATING TO NHTSA CAMPAIGN ID NUMBER 04V090000 (FUEL SYSTEM, GASOLINE:DELIVERY). SINCE THE RECALL REPAIR WAS PREVIOUSLY PERFORMED, THE DEALER WOULD NOT REPAIR THE VEHICLE FOR FREE. THE FAILURE MILEAGE WAS 103,767 AND CURRENT MILEAGE WAS 103,983.

WITH NO INDICATION OF TROUBLE, THE CAR STALLS AND SHUTS DOWN WHILE DRIVING. SOMETIMES IT CAN BE RE-STARTED, SOMETIMES IT CANNOT BE RESTARTED. AFTER TOWED TO THE DEALER, THE PROBLEM DOES NOT OCCUR AND NO CAUSE IS IDENTIFIED. LAST YEAR THE DEALER REPLACED THE IDLE AIR CONTROL AND CLEANED THE THROTTLE BODY, BUT THE PROBLEM RETURNED INTERMITTENTLY. IT HAS OCCURRED ONCE / WEEK FOR THE LAST MONTH. *TR