Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
1025–50K
350–75K
675–100K
5100–150K
5150K+
30 reports with mileage · 70 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports8 fire reports9 injury reports
What owners actually said
100 reports
98,100 miles · Feb 6, 2006
Vehicle Speed ControlCrash
DT*: THE CONTACT STATED WHILE ENTERING A CURVE AND APPLYING NORMAL BREAK PRESSURE THE VEHICLE SUDDENLY ACCELERATED FROM 40 TO 70MPH. THE SUDDEN ACCELERATION CAUSED THE DRIVER TO LOOSE CONTROL AND CRASH INTO A TREE ON THE ROADSIDE. THE ENGINE CONTINUED TO REV, BUT THE TREE WOULD NOT ALLOW ANY ADDITIONAL FORWARD MOTION. THE IG…
Read full complaint
DT*: THE CONTACT STATED WHILE ENTERING A CURVE AND APPLYING NORMAL BREAK PRESSURE THE VEHICLE SUDDENLY ACCELERATED FROM 40 TO 70MPH. THE SUDDEN ACCELERATION CAUSED THE DRIVER TO LOOSE CONTROL AND CRASH INTO A TREE ON THE ROADSIDE. THE ENGINE CONTINUED TO REV, BUT THE TREE WOULD NOT ALLOW ANY ADDITIONAL FORWARD MOTION. THE IGNITION WAS TURNED OFF BEFORE PLACING THE SHIFTER INTO PARK. THE DRIVER WAS WEARING A SEATBELT AND RECEIVED NO INJURIES. THE POLICE FILED A REPORT AT THE ACCIDENT SCENE. THE VEHICLE WAS TOWED TO A WRECKING YARD WHERE IT WAS LATER INSPECTED BY THE INSURANCE COMPANY AND DEEMED A TOTAL LOSS. THE MANUFACTURER WAS ALERTED AND INFORMED THE CONTACT THE VEHICLE WOULD BE INSPECTED TO HELP DETERMINE A CAUSE IF IT WAS TOWED TO A LOCAL SERVICE DEALER. THE VEHICLE CURRENTLY REMAINS IN THE POSSESSION OF THE INSURANCE COMPANY.
NHTSA ODI #10149506
58,000 miles · Aug 22, 2005
Service Brakes, Hydraulic
DT: THE CONTACT STATES THE VEHICLE SPINS OUT OF CONTROL WHEN THE BRAKES ARE APPLIED. THE CONSUMER HAS CONTACTED THE MANUFACTURER, WHO STATED THERE WAS NO RECALL. WHEN THE VEHICLE SPINS OUT OF CONTROL THE ROAD CONDITIONS ARE NORMAL. THE CONSUMER STATES THAT THE VEHICLE DOES MAKE A LOUD SQUEAKING NOISE. THE BRAKES HAVE BEEN RE…
Read full complaint
DT: THE CONTACT STATES THE VEHICLE SPINS OUT OF CONTROL WHEN THE BRAKES ARE APPLIED. THE CONSUMER HAS CONTACTED THE MANUFACTURER, WHO STATED THERE WAS NO RECALL. WHEN THE VEHICLE SPINS OUT OF CONTROL THE ROAD CONDITIONS ARE NORMAL. THE CONSUMER STATES THAT THE VEHICLE DOES MAKE A LOUD SQUEAKING NOISE. THE BRAKES HAVE BEEN REPLACED ONCE DURING THE PAST YEAR, AND HAVE BEEN REPAIRED AT LEAST 3 TIMES SINCE THEN. THE VEHICLE SPINS OUT OF CONTROL DURING NORMAL BRAKING PROCEDURES. THE SERVICE DEALER STATES THAT THE BRAKES ARE WEARING UNEVENLY. *AK
NHTSA ODI #10133717
94,000 miles · Sep 21, 2004
Steering
WHEN MAKING A LEFT HAND TURN AT 5 MPH VEHICLE LOST POWER STEERING. CONSUMER PULLED OVER, AND HAD THE VEHICLE TOWED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10093981
Mileage unknown · Sep 8, 2004
Steering
CONSUMER WAS PULLING INSIDE OF A PARKING LOT AND THE STEERING WHEEL FAILED TO STEER. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE SOLENOID SWITCH NEEDED TO BE REPLACED. *AK
NHTSA ODI #10091647
106,000 miles · Jul 18, 2004
Electrical SystemFire
WHILE ON VACATION IN WILLIAMSBURG VA. HEARD ANNOUCMENT OVER THE INTERCOM AT A CRACKER BARREL RESTURAUNT .. OWNER OF WHITE CHEVY MONTE CARLO WITH MD TAGS GO TO YOUR CAR ASAP.. WHEN ARRIVED IN PARKING LOT.. MANAGER OF REST. WAS STANDING NEXT TO MY CAR WITH A FIRE EXT. AND THE ENGINE WAS ENGULFED IN FLAMES.. THE VEHICLE TRAVELED ON…
Read full complaint
WHILE ON VACATION IN WILLIAMSBURG VA. HEARD ANNOUCMENT OVER THE INTERCOM AT A CRACKER BARREL RESTURAUNT .. OWNER OF WHITE CHEVY MONTE CARLO WITH MD TAGS GO TO YOUR CAR ASAP.. WHEN ARRIVED IN PARKING LOT.. MANAGER OF REST. WAS STANDING NEXT TO MY CAR WITH A FIRE EXT. AND THE ENGINE WAS ENGULFED IN FLAMES.. THE VEHICLE TRAVELED ONLY ABOUT 4 MILES FROM THE HOTEL WE WERE STAYING AT, SO IT WAS NOT EXTREMELY HOT...THE VEHICLE CONTINUED TO BURN UNTIL THE FIRE DEPARTMENT ( YORK COUNTY) ARRIVED AND RIPPED OPEN THE HOOD BECAUSE THE HOOD LATCH RELEASE CABLE HAD BURNED THROUGH AND YOU COUND NOT GET THE HOOD UP.. THE CAR WAS VERY WELL MAINTAINED, ENGINE HAD BEEN RECENTLY DEGREASED AND LOOKED AND DROVE LIKE A NEW CAR... THE CAR HAS BEEN TOTALLED OUT BY ERIE INS CO. AND LEFT IN VA. WE HAD TO GET A RENTAL BACK TO BALTIMORE.... THE FIRE APPEARED TO BE ELECTRICAL IN NATURE DUE TO THE FACT THAT THE AREA WORST BURNED ON THE HOOD WAS RIGHT OVER THE DISTIBUTOR. PICTURES ARE AVAILABLE IF NEEDED FOR ANY INVESTIGATION... HAS THIS TYPE OF UNEXPECTED ENGINE FIRE OCCURRED IN OTHER 3.1 SERIES CHEVY ENGINE OR MONTE CARLO'S?
NHTSA ODI #10081289
Mileage unknown · May 12, 2004
Air Bags
AIR BAG ON PASSENGER SIDE DASH HAS LIFTED UP - THE VINYL COVER HAS LIFTED OFF. THERE WAS NO IMPACT OR ANY OTHER REASON FOR THIS TO HAPPEN. THE AIR BAG IS STILL IN THE DASH AND HAS NOT IMPLODED BUT I AM FEARFUL THAT THIS MIGHT HAPPEN. CHEVROLET HAS SAID THEY WILL REVIEW THE PROBLEM AND PERHAPS MAY OR MAY NOT PAY 50% TO HAVIN…
Read full complaint
AIR BAG ON PASSENGER SIDE DASH HAS LIFTED UP - THE VINYL COVER HAS LIFTED OFF. THERE WAS NO IMPACT OR ANY OTHER REASON FOR THIS TO HAPPEN. THE AIR BAG IS STILL IN THE DASH AND HAS NOT IMPLODED BUT I AM FEARFUL THAT THIS MIGHT HAPPEN. CHEVROLET HAS SAID THEY WILL REVIEW THE PROBLEM AND PERHAPS MAY OR MAY NOT PAY 50% TO HAVING THE AIR BAG REPAIRED WHICH THEY SAY MEANS INSTALLING AN ENTIRE NEW SYSTEM. I CONTEND THAT THIS IS A DEFECT AND CHEVROLET SHOULD TAKE CARE OF THE PROBLEM FREE OF CHARGE. CHEVROLET SAID BECAUSE OF THE YEAR AND MILEAGE (62,000) THAT IT IS NOT UNDER WARRENTY AND THEY CANNOT BE RESPONSIBLE.
NHTSA ODI #10072512
108,238 miles · Apr 29, 2004
Exterior Lighting
BRAKE LIGHTS DO NOT WORK IF THE TURN-SIGNAL/BRIGHT LIGHT/WIPER LEVER IS MOVED SLIGHTLY FORWARD OF ITS NORMAL POSITION. AFTER USING THE TURN SIGNALS OR BRIGHT LIGHTS THE BRAKE LIGHTS WILL NOT WORK UNLESS THE LEVER IS PULLED UP TOWARD THE DRIVER. THE CAR HAS NOT BEEN INVOLVED IN ANY ACCIDENT, NOR HAS THE TURN SIGNAL LEVER BEEN …
Read full complaint
BRAKE LIGHTS DO NOT WORK IF THE TURN-SIGNAL/BRIGHT LIGHT/WIPER LEVER IS MOVED SLIGHTLY FORWARD OF ITS NORMAL POSITION. AFTER USING THE TURN SIGNALS OR BRIGHT LIGHTS THE BRAKE LIGHTS WILL NOT WORK UNLESS THE LEVER IS PULLED UP TOWARD THE DRIVER. THE CAR HAS NOT BEEN INVOLVED IN ANY ACCIDENT, NOR HAS THE TURN SIGNAL LEVER BEEN REMOVED IN THE FIVE YEARS I HAVE OWNED THE VEHICLE. THERE ARE NO OTHER ELECTRICAL PROBLEMS WITH THE VEHICLE AND THE FAILURE SEEMS TO BE A RESULT OF DESIGN. THE LIGHT ON THE REAR DECK STILL WORKS. DRIVER MAY NOT BE AWARE OF THE FAILURE AND A REAR-END COLLISION IS POSSIBLE AS A RESULT OF SUDDEN BRAKING. PROBLEM WAS JUST DISCOVERED AND HAS NOT YET BEEN REPAIRED.
NHTSA ODI #10068069
85,000 miles · Apr 12, 2004
Suspension
HUB SENSOR MALFUNCTIONED. AS A RESULT, WHEN APPLYING THE BRAKES ITPRODUCED A CLICKING NOISE. *AK
NHTSA ODI #10066936
28,000 miles · Apr 5, 2004
Engine And Engine Cooling
THE VEHICLE HAS AN INTERNAL COOLANT LEAK WITHIN THE ENGINE COMPARTMENT. THE LEAK OCCURRED BECAUSE THE INTAKE MANIFOLD GASKET WAS MADE WITH A THIN MATERIAL WHICH DISINTEGRATED AND CREATED AN ORANGE SLUG IN THE ENGINE, PER THE DEALERSHIP. *JB
NHTSA ODI #10065509
32,377 miles · Apr 1, 2004
Fuel System, Gasoline
THE GAS TANK RUSTED AND HAD TO BE REPLACED. *PH THE CONSUMER SMELLED GAS AND VIEWED GAS LEAKING. *SC *JB
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA98019 · Degraded Braking Performance
Opened Aug 31, 1998 · Closed Dec 13, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
1998 Chevrolet Monte Carlo Problems, Complaints & Recalls | Skip That Year
Illustration