IllustrationWHILE TRAVELING IN A RURAL HOUSING AREA 30 MPH, THE RIGHT FRONT WHEEL DETACHED FROM THE VEHICLE WHEN TURNING LEFT. THE VEHICLE WAS TOWED TO A DEALERSHIP WHERE PURCHASED TO DETERMINE CAUSE. THE OWNER STATES THAT THE ENTIRE BALL JOINT BROKE FROM THE VEHICLE AND BOLT AND COTTER PIN WORE OFF. PLEASE PROVIDE FURTHER DEAILS TS
1997 Chevrolet Monte Carlo
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Monte Carlo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 28 of 164 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports1 fire reports8 injury reports
What owners actually said
164 reportsFUEL TANK IS RUSTING AT THE STEM AND CAUSES FUEL LEAKAGES. DEALER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
ENGINE POSSIBLY BLOWN, ALL SCHEDULED MAINTENANCE COMPLETED, COULD BE HEAD GASKET, ANY RECALLS?*AK
TWICE AUTOMATIC TRANSMISSION FAILED, SLIPPING BACK AND FORTH INTO NEUTRAL, AND THEN SLAMMED BACK INTO GEAR. AUTOMATIC TRANSMISSION WAS REPLACED, SAME PROBLEM OCCURRED WITH THE REPLACEMENT. OWNER HAD PIECES OF TRANSMISSION THAT CAME FROM TRANSFER CASE. PLEASE DESCRIBE DETAILS. *AK
WHILE PULLING OUT OF A PARKING SPACE CONSUMER PUT VEHICLE INTO REVERSE AND VEHICLE STARTED TO DRIVE IN REVERSE AT HIGH SPEEDS . CONSUMER HAD FOOT ON BRAKE, BUT VEHICLE WAS NOT STOPPING. CONTACTED DEALER. *AK
VEHICLE WAS LEAKING OIL. OIL IS CHANGED EVERY 5000 MILES, AND VEHICLE IS BURNING OIL TOO FAST. TOOK VEHICLE TO A MECHANIC, AND MECHANIC STATED GASKETS WERE CRACKED UNDER THE MOTOR. CONSUMER DID NOT KNOW THE CAUSE. *AK CONSUMER STATED THAT THEY REFUSED TO FIX THE VEHICLE BECAUSE MECHANIC STATED IT WAS THE HARDEST ENGINE TO GET …
Read full complaint
VEHICLE WAS LEAKING OIL. OIL IS CHANGED EVERY 5000 MILES, AND VEHICLE IS BURNING OIL TOO FAST. TOOK VEHICLE TO A MECHANIC, AND MECHANIC STATED GASKETS WERE CRACKED UNDER THE MOTOR. CONSUMER DID NOT KNOW THE CAUSE. *AK CONSUMER STATED THAT THEY REFUSED TO FIX THE VEHICLE BECAUSE MECHANIC STATED IT WAS THE HARDEST ENGINE TO GET OUT TO REPLACE GASKETS. *YH
THE BRAKE PEDAL GOES ALL THE WAY TO THE FLOOR. WITHOUT PRIOR WARNING THERE IS NOISE COMING FROM THE REAR WINDOW.*JB
WHILE DRIVING 15MPH, STEERING WHEEL LOCKED UP. *AK VEHICLE WOULD NOT TURN FROM LEFT TO RIGHT, CONSUMER HAD TO STOP TO UNLOCK STEERING. *JB
HAD NO POWER STEERING, HAD TO STOP AND BACK UP TO COMPLETE TURN, STEERING COME AND GO. STOPPED TO CHECK COULD NOT DETERMINE THE CAUSE, FOUND POWER STEERING PUMP EMPTY.
CONSUMER WAS TRAVELING ABOUT 60MPH ON HIGHWAY WHEN ANOTHER VEHICLE VEERED INTO CONSUMER'S LANE. UPON IMPACT, DRIVER'S SIDE AIRBAG DIDN'T DEPLOY. DEALERSHIP WAS AWARE OF PROBLEM. *AK
Official recalls
103V527000 · Steering:rack And Pinion
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98019 · Degraded Braking Performance
Opened Aug 31, 1998 · Closed Dec 13, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE98023 · Degraded Braking Performance
Opened Apr 23, 1998 · Closed Aug 31, 1998
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.