2023 Chevrolet Malibu

Check engine light will come on entire car will shut off. Shuttering, braking locks up, all power is reduced, especially engine power. car will get towed to the Chevrolet dealership in temple, Tx and Killeen, Tx for repairs. When hooked up to the scanner all 7 modules show as faulty. Chevrolet of Killeen replaced only 3 of the modules stating that was the issue. two days after repair same issue has happened. when hooked up to the scanner again all modules were faulty again including the ones that were just repaired. car has been in the shop for 100 days now. the car will cool down, and the check engine light will reset itself showing no issues repeat the process.

The contact owns a 2023 Chevrolet Malibu. The contact stated that while driving 30-35 MPH, another vehicle collided with her vehicle on the rear end of the vehicle as well as the rear passenger side. The contact mentioned that the seat belt did retract during the impact. The air bags on the front driver and passenger sides deployed partially. The vehicle was still drivable. The insurance company informed the contact that they are waiting for a response from the auto body shop. The vehicle was not deemed a total loss. The contact stated she did not sustain any injuries. No Medical Attention. A police report was filed, however the police report was unknown. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 29,000.

At 40,000 miles, check engine light illuminated. Code reader stated P023F fuel pump secondary circuit open. When trying to take 2023 Malibu to dealership for repairs car would not start. Had to have car towed to dealership. Dealership confirmed same fuel pump error code. Confirmed no recall. Car is currently being repaired by dealership at my expense as dealership & GM says fuel pump is not covered by powertrain warranty. Cost is over $1500! Fuel pump should last longer than 40,000 miles! Please research this faulty fuel pump!

I brought in my used vehicle to the dealership the same dealership that I purchased my car from due to another issue i was having with the car. Upon inspection from the dealership a diagnostic test was done on the vehicle, the dealership gave me a invoice stating "airbag malfunction needs the airbag on horn". I purchased this used vehicle from this dealership 4-4-25,. 6-10-25 i returned for the issue I was having and the dealership gave me this invoice with the information concerning the airbag. Yes it is available for inspection. My safety is in jeopardy if no airbag deploys for the driver if im in any type of accident. I was not made aware by the dealership of not having a airbag. No the vehicle has not been inspected by police, insurance representative. No, there was no warning lamps, messages before finding out this information at the dealership . I did receive a acknowledgement of vehicle accident history stating " This vehicle is a used vehicle that has had prior structural body repair work, indicating that the vehicle has previously been in an accident. " No further information. I have no information as towhen this accident took place.

The fuel line to the engine is leaking an 2 gallons leaked onto my driveway. Also, the vehicle cabin was consumed with fuel fumes which was a hazard and dangerous. The was danger of the vehicle exploding or catching fire. No warning lights appeared. The incident occurred on [XXX]. The fleet vehicle has been taken to Belle Tire for repair; however, not inspected by the manufacturer. My husband and my safety were put at risk because car could have exploded when ignition was turned on. Please contact me at [XXX] by 2/28/25...thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Chevrolet Malibu equipped with Continental Tires, Tire Line: Pro Contact, Tire Size: 245/40/R19, DOT Number: 6Y66WBR27. The contact stated that while his wife was driving at highway speeds, there was a blowout of the front driver's side tire. The cause of the failure was not yet determined. The tire was replaced. The contact stated that later while inspecting the vehicle it was discovered that the front passenger’s side tire had developed a sidewall blister. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 11,000.

The contact rented a 2023 Chevrolet Malibu. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. Additionally, the contact stated that there was a grinding sound coming from underneath the vehicle. The rental agency was contacted and made aware of the failure. The contact returned the vehicle on the next business day, and the failure was reported. The failure mileage was approximately 38,706. The VIN was unavailable.

My car randomly shuts off when but still says it’s on at a stop light which causes a lot of problems because I have to push the start button to turn off and turn on again. Something is wrong with the wiring, in order for me to turn my car off I have to unplug my battery otherwise my car safety alarm will activate and hazard lights will go off and trunk will open. Which also cause my horn to go out. Everytime I turn my car on it says service ESC which I have no clue what that means and have asked multiple people . My air bag service light is on and it has no reason to be on as my car has not had any problems with my airbags. My car automatically brake while on the highway going 75 when a car swerved into my lane ahead of me and the hard activated the abs which caused my car to swerve uncontrollably and almost caused my car to flip.