2016 Chevrolet Malibu

The contact owns a 2016 Chevrolet Malibu. The contact stated while driving on several occasions at various speeds, the check engine warning light illuminated, and the vehicle lost power. Additionally, the message “Engine Power Reduced" was displayed. The vehicle was taken to an independent mechanic and was diagnosed and determined that the throttle body sensor needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 107,000.

I am filing a complaint regarding ongoing and worsening issues with my Chevrolet vehicle, which appear to point to broader defects involving the engine and electrical systems. Months ago, while driving, the car suddenly lost power and displayed "Engine Power Reduced." I had to keep using it due to work needs. Over time, it hesitated more during acceleration and felt increasingly unsafe. When I finally brought it to a Chevrolet service center, I was told the issue involved the pistons. The vehicle also regularly shows a "Shift to Park" warning even when the gear is in Park, raising concerns about the transmission's reliability. The power loss continues, especially when going uphill — again triggering the "Engine Power Reduced" alert and dropping the speed to no more than 35 MPH. A diagnostic showed a P0302 code for a cylinder 2 misfire. The radio head unit, already replaced once under warranty, failed again after just 9 months. Prior to the worsening idle and gear issues, I also received network-related codes involving the ECM and transmission computers. Although I’ve replaced the alternator, the car still shows "Service Electric System" warnings, suggesting ongoing electrical problems. I also noticed GM’s N182195660 campaign involving predictive monitoring for Stochastic Pre-Ignition (SPI) on SCP platforms. My car has the 2.0L turbo engine, and I’m concerned it may be experiencing SPI or coolant intrusion issues affecting overall performance and system integrity. I’m requesting that Chevrolet investigate these problems thoroughly and determine whether my vehicle qualifies for recall, extended warranty, or defect coverage. These issues are persistent, serious, and deserve immediate attention. Thank you for your time. I hope to see resolution soon.

Took my car to Chevy dealership to diagnose my car, as it was rough idling, causing hesitation, and knocking... all while the check engine light was on. They showed me two codes my car was giving from the check engine light. They said he would look further into it. They told me I needed a tune up, though I had gotten a tune up 4 months prior. They fixed some things and charged me over $4,000. The day I drove off the lot, the problems were still present. On my way home going about 50 mph, my car slowed down and the engine reduced power illuminated. I kept driving because I needed a car for work. The car continued to decline and acted like it didn't want to accelerate when pressing the gas. I finally took it back into chevy, and they told me it was my pistons. I'm 90% sure there is a defect that they won't tell me about, or the won't fix. I've had the car 2 years. Now the car won't run.

To whom it may concern, I am writing to formally report a recurring safety-related issue with my 2016 Chevrolet Malibu. The vehicle consistently displays a “Shift to Park” warning message, even when the gear selector is properly in the Park position. This malfunction prevents the car from turning off completely and poses a serious safety and reliability concern. This issue first occurred while the vehicle was under warranty, and the dealership performed a repair. However, the problem has returned, and my warranty has since expired. Despite the previous fix, the issue continues to persist. This malfunction is widely documented among other 2016–2019 Chevy Malibu owners and appears to stem from a design or manufacturing flaw in the shifter assembly or park switch. I am concerned that this defect could: Prevent the vehicle from being securely parked. Lead to battery drain due to the vehicle not shutting off. Pose a risk if the driver believes the car is in park when it is not. I am requesting that Chevrolet consider this a safety defect and either recall the affected vehicles or offer extended coverage for repairs. I also ask that NHTSA investigate this issue further as it compromises the safety, reliability, and proper functioning of the vehicle. Thank you for your attention to this matter. I would appreciate any assistance or updates regarding how this issue will be addressed. Vehicle Info: 2016 Chevrolet Malibu E2 Year: 2016 Make: Chevrolet Model: Malibu Mileage: 60,000 VIN: ALREADY INSERT Previous repair date(s): 02/21/2020 Sincerely, [XXX] [XXX] [XXX] Toledo, Ohio INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Chevrolet Malibu. The contact stated that occasionally while attempting to accelerate the vehicle stalled. The contact stated that the failure also occurred while stopped at a traffic light. The contact was able to restart the vehicle and continued driving; however, the check engine warning light illuminated. The vehicle was taken to an independent mechanic where the vehicle was diagnosed and the contact was advised that the throttle position sensor, and the intake airflow system were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 163,000.

Happened around 46000 miles after receiving a recall notice in the mail about the pedal positioning sensor causing a reduced engine power signal, and immediately reducing speeds on the interstate. Local Chevy dealership replaced. Fast-forward 80K miles and the same incident is happening, however likely not going to be covered by GM. Same message, same code being detected.

I had my vehicle for about 2 years. I noticed that after I went over a certain amount of mileage, my car went into an engine power reduce mode. With the engine power reduce mode my vehicle could only go 25 mph. This was happening to me when I was driving on major highways, etc.. I would have to pull over and stop the vehicle because after certain amount of time it also would tell me oil pressure low to stop engine. I took it to the Chevy dealership to have it looked at. I got the runaround with trying to figure out exactly what the issue was. They kept telling me that it was something else I spent over $1600 in repairs due to them, telling me that they found the issue and corrected it. After about another week or two, The same issue happened, engine power reduced stop engine oil pressure low. The most dangerous part about it is again I’m driving on interstates heading to work, etc. and the car is slows down on the interstate not allowing me to go over 25 mph again having to pull over on the interstate to give the car a break, crank it back up and get to a safe location. After having multiple mechanics look at it, still unable to fix. It started to get worse where once it pops up engine power reduce, oil pressure low stop engine, the car started jerking & shaking really bad. The only way to stop this from happening is to again shut the car down. I can’t keep shutting the car down in the middle of the interstate and on major roads. I took the vehicle to the Chevy dealership first they couldn’t find the issue. They said it was another issue that wasn’t even the issue so I paid over $1600 for nothing. I took it to Rick Hendrick, who couldn’t find an issue and all they could tell me was to trade it in. This vehicle issue needs to be recalled. My bf is now having the exact same issue that my car was having & after researching, others are as well. Same year, same model, just a different color. This vehicle needs to be recalled for this ongoing safety issue ASAP!

I will be driving at posted speed limits (typically 55 to 60 MPH) and while going up a hill, the engine loses power. I get a notice on my screen that states engine power reduced. Speed reduces to no more than 35 MPH. This can put others in danger if they are too close or if the roads are icy due to it being winter in Indiana. I put on my hazard lights, and I am able to pull off the side of the road, turn off the car for 5 minutes and restart it and have power back. But engine light remains on. Mechanics cannot find anything wrong. No warnings prior to the incident. In fact, the car loses power and then the message appears on screen. This has happened 7 times in the last 4 months.