IllustrationIN THE LAST YEAR I HAVE PURCHASED FOUR GAS CAPS AND HAVE THE SAME PROBLEM. THE ENGINE LIGHT KEEPS GOING ON AND OFF. I HAVE HAD IT TESTED AT AUTO ZONE AND THEY STATED IT IS THE GAS CAP. GM STATED THAT THERE IS NO PROBLEM WITH THERE GAS CAPS. *TR
2008 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2008 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
740–25K
12425–50K
16950–75K
14675–100K
190100–150K
98150K+
801 reports with mileage · 186 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 460 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 231 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
30 crash reports5 fire reports15 injury reports
What owners actually said
987 reportsTL* THE CONTACT OWNS A 2008 CHEVROLET MALIBU. WHILE PARKED, THE CONTACT NOTICED WATER LEAKING FROM THE SUNROOF AND INTO THE INTERIOR OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 99,467 .
TL* THE CONTACT OWNS A 2008 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING, THE BRAKE LIGHTS WERE ILLUMINATED WITHOUT THE BRAKE PEDAL BEING ENGAGED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 70,000.
THREE OF MY CAR DOORS DO NOT LOCK UNLESS MANUALLY LOCKED. THE ELECTRONICS HAVE FAILED ON ALL THREE DOORS. I HAVE TO REPLACE THE MOTOR IN EACH DOOR, AT THE COST OF OVER $750. THE COST IS NOT THE ONLY PROBLEM. THE MOTORS THAT FAILED IN EACH DOOR WILL BE REPLACED BY THE SAME FAULTY PART. I CAN'T BELIEVE IT COSTS $300 TO FIX ONE DOO…
Read full complaint
THREE OF MY CAR DOORS DO NOT LOCK UNLESS MANUALLY LOCKED. THE ELECTRONICS HAVE FAILED ON ALL THREE DOORS. I HAVE TO REPLACE THE MOTOR IN EACH DOOR, AT THE COST OF OVER $750. THE COST IS NOT THE ONLY PROBLEM. THE MOTORS THAT FAILED IN EACH DOOR WILL BE REPLACED BY THE SAME FAULTY PART. I CAN'T BELIEVE IT COSTS $300 TO FIX ONE DOOR'S LOCKS ALONE. THE DRIVERS LOCK HAD GREATER PROBLEMS THAN THE OTHERS BECAUSE SOMETIMES IT LOCKS ME IN THE CAR BECAUSE IT SHIFTS THE LOCK A LITTLE AND THE DOOR GETS JAMMED. THIS SHOULD BE RECALLED. I FILED A COMPLAINT WITH GM. *TR
TL* THE CONTACT OWNS A 2008 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE REVERSING, IT WAS DISCOVERED THAT THE BRAKE LIGHTS ERRONEOUSLY ILLUMINATED. THE BRAKE LIGHTS WOULD NOT ILLUMINATE WHEN THE BRAKES WERE DEPRESSED. THE CONTACT ALSO STATED THAT THE TRACTION CONTROL WARNING LIGHT ILLUMINATED SPORADICALLY. THE VEHICLE WAS TA…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE REVERSING, IT WAS DISCOVERED THAT THE BRAKE LIGHTS ERRONEOUSLY ILLUMINATED. THE BRAKE LIGHTS WOULD NOT ILLUMINATE WHEN THE BRAKES WERE DEPRESSED. THE CONTACT ALSO STATED THAT THE TRACTION CONTROL WARNING LIGHT ILLUMINATED SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE BRAKE SWITCH HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 91,000.
TL* THE CONTACT OWNS A 2008 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 65 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE CONTACT STOPPED THE VEHICLE ON THE SHOULDER AND SHUT OFF THE ENGINE. AFTER ALLOWING THE VEHICLE TO SIT FOR SEVERAL MINUTES, THE VEHICLE WAS RESTARTED AND THE POWER STEERING ASSIST RESUMED NORMAL …
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 65 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE CONTACT STOPPED THE VEHICLE ON THE SHOULDER AND SHUT OFF THE ENGINE. AFTER ALLOWING THE VEHICLE TO SIT FOR SEVERAL MINUTES, THE VEHICLE WAS RESTARTED AND THE POWER STEERING ASSIST RESUMED NORMAL OPERATION. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING HOWEVER, THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. ADDITIONALLY, THE STEERING WHEEL WOULD SHAKE VIOLENTLY WHILE PARKED WITH THE ENGINE RUNNING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
ON SEVERAL OCCASION I HAVE NOTICE THAT MY BRAKE LIGHTS COME ON WITHOUT ME EVEN PRESSING THE BRAKES. IT ALSO LIGHTS UP AND WHEN I PRESS THE BRAKES IT GOES OFF. I HAVE SPOKEN WITH OTHER MALIBU OWNER AND THEY COMPLAIN OF THIS SAME BRAKE FAILURE. IT IS VERY FRUSTRATING AND NOT SAFE. *TR
AUTOMATIC DOOR LOCK FAILED TO OPEN WHEN TRANSMISSION WAS PUT IN PARK. THE ONLY WAY TO OPEN THE DOOR WAS TO PULL UP ON LOCK KNOB WHICH WAS ALMOST IMPOSSIBLE DUE TO LIMITED MOBILITY (ARTHRITIS IN SHOULDER). NEEDED TO REMOVE SEAT BELT, SLIDE OVER AND SIT ON CONSOLE TO REACH LOCK KNOB. AUTOMATIC LOCKS STILL ENGAGE WHEN CAR IS PU…
Read full complaint
AUTOMATIC DOOR LOCK FAILED TO OPEN WHEN TRANSMISSION WAS PUT IN PARK. THE ONLY WAY TO OPEN THE DOOR WAS TO PULL UP ON LOCK KNOB WHICH WAS ALMOST IMPOSSIBLE DUE TO LIMITED MOBILITY (ARTHRITIS IN SHOULDER). NEEDED TO REMOVE SEAT BELT, SLIDE OVER AND SIT ON CONSOLE TO REACH LOCK KNOB. AUTOMATIC LOCKS STILL ENGAGE WHEN CAR IS PUT IN DRIVE BUT WILL NOT OPEN WHEN PUT BACK IN PARK. I CAN NOT EASILY OR QUICKLY EXIT THE CAR WITH THIS FAILURE. GM SAYS NOT A SAFETY ISSUE SINCE AUTOMATIC LOCKS ARE ONLY A CONVENIENCE AND OLDER CARS WERE NOT EQUIPPED WITH AUTOMATIC LOCKS. HOWEVER, ON OLDER CARS THE DOOR WOULD UNLOCK WHEN THE DOOR HANDLE WAS PULLED. ON THE MALIBU PULLING UP ON THE LOCK KNOB IS THE ONLY WAY TO EXIT THE CAR. COST TO HAVE DEALER REPAIR $300. AN INTERNET SEARCH REVEALS AUTOMATIC DOOR LOCK FAILURES ARE VERY COMMON. *TR
STARTED THE CAR TO COME OUT OF A PARKING SPOT, HEARD HUMMING/RATTLING NOISE. STEERING WHEEL STARTED TO VIBRATE THEN WOULD DO RAPID HALF-TURNS BY ITSELF, JERKING LEFT AND RIGHT. SHUT THE CAR OFF AND RESTARTED. SEEMED OK FOR FIRST FEW MINUTES THEN STARTED AGAIN. GOT ON THE ROAD, DRIVING ABOUT 35-40 MPG ON HIGHWAY AND IT BECAME…
Read full complaint
STARTED THE CAR TO COME OUT OF A PARKING SPOT, HEARD HUMMING/RATTLING NOISE. STEERING WHEEL STARTED TO VIBRATE THEN WOULD DO RAPID HALF-TURNS BY ITSELF, JERKING LEFT AND RIGHT. SHUT THE CAR OFF AND RESTARTED. SEEMED OK FOR FIRST FEW MINUTES THEN STARTED AGAIN. GOT ON THE ROAD, DRIVING ABOUT 35-40 MPG ON HIGHWAY AND IT BECAME UNCONTROLLABLE. COULD NOT KEEP IT STRAIGHT WITHIN THE LANE. ALMOST HIT A CAR IN THE LANE ON MY RIGHT! PULLED UP TO AN AUTO SHOP NEAR BY. THEY TEST DROVE AND EXPERIENCED THE ISSUE BUT EXPLAINED THAT WITH THESE CARS, THE TECHNOLOGY IN THEM IS TOO ADVANCED AND WOULD HAVE TO BE TAKEN TO A CHEVY DEALER. MECHANIC EXPLAINED THAT THE MATTER IS QUITE HAZARDOUS AND IT WOULD BE A HUGE RISK DRIVING IT NOW. SINGLE MOM DRIVING 45 MINUTES FROM HOME WITH 2 MINOR CHILDREN. HAD TO GET A TOW TRUCK TO GET BACK HOME, 45 MINUTES AWAY. $$$!! HAD THIS VEHICLE FOR 11 MONTHS ONLY. PRIOR TO THIS ISSUE, HAD DOOR LOCKS ISSUES AS I'VE READY ON OTHER THREADS AND ALSO CURRENTLY EXPERIENCING ISSUES WITH FAULTY TIRE PRESSURE SENSOR AS WELL. NOTHING BUT PROBLEMS WITH THIS CAR SINCE I'VE HAD IT. THIS IS MY FIRST AND VERY LAST CHEVROLET!! *TR
WHILE DRIVING TO WORK THE STEERING SEEMED TO LOCK UP AND THEN WAS VERY HARD TO STEER. I GOT THE CAR SLOWED DOWN AND PULLED OVER AND TURNED IT OFF, AFTER A FEW MINUTES I STARTED THE CAR AND THE STEERING SEEMED OK.THIS HAS HAPPENED A TOTAL OF 7 OR 8 TIMES SINCE 10/1/12. TOOK CAR TO THE DEALER ON 10/13 AND THEY COULD NOT GET THE CA…
Read full complaint
WHILE DRIVING TO WORK THE STEERING SEEMED TO LOCK UP AND THEN WAS VERY HARD TO STEER. I GOT THE CAR SLOWED DOWN AND PULLED OVER AND TURNED IT OFF, AFTER A FEW MINUTES I STARTED THE CAR AND THE STEERING SEEMED OK.THIS HAS HAPPENED A TOTAL OF 7 OR 8 TIMES SINCE 10/1/12. TOOK CAR TO THE DEALER ON 10/13 AND THEY COULD NOT GET THE CAR TO DO IT WHILE THEY DROVE IT. I AM TAKING THE CAR BACK ON 10/22 TO GET IT CHECKED AGAIN. THERE IS DEFINITELY A PROBLEM WITH THE ELECTRICALLY ASSISTED POWER STEERING. *TR
Official recalls
414V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
12V460000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Sep 18, 2012
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
Consequence & remedy
Consequence: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
Remedy: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.